Production of the polyunsaturated fatty acids arachidonic acid and eicosapentaenoic acid by the fungus Pythium ultimum

Several strains of species of the fungal genus Pythium, and of Phytophthora cinnamomi, were screened for content of the polyunsaturated fatty acids (PUFAs) arachidonic acid (AA) and eicosapentaenoic acid (EPA). The aim of the investigation was to establish alternative sources of these PUFAs, which are of importance in human nutrition. As a relatively prolific producer of EPA and AA, P. ultimum strain #144 was selected for a study of conditions that enhance their production over baseline levels that are present in the fungus when cultured for 6 d at 25 degrees C with rotary shaking (120 r.p.m.) in Vogel's medium containing sucrose as the carbon substrate. The levels of AA and EPA under these conditions were 133 +/- 27 and 138 +/- 25 mg l-1 (n = 5), respectively. Maximal production of these fatty acids was accomplished by the following sequence of steps. (1) Incubate the cultures for 6 d after inoculation under the conditions described above. Then (2) add glucose to the cultures (2%, w/v, final concentration) and incubate for a further 6 d at 13 degrees C. Under these conditions, the AA content of the mycelium was 205% higher than baseline levels and the EPA content was 198% higher. (3) Allow the cultures to remain stationary for 10 d which increases the AA content to 253% above baseline levels and the EPA content by 236%. Using such a procedure, 322 mg AA l-1 and 383 mg EPA 1-1 were produced.     

Effect of culture media and conditions on polyunsaturated fatty acids production by Mortierella alpina

To improve the polyunsaturated fatty acid (PUFA) production by Mortierella, culture media and conditions were investigated. M. alpina ATCC 32222 had the highest yield of arachidonic acid, gamma-linolenic acid and linoleic acid among 11 test microbes. Soluble starch at 10% and the mixture of KNO3 and yeast extract at 2:1 (w/w) was the best carbon and nitrogen sources for arachidonic acid and total PUFAs production, respectively. The optimal C/N ratio ranged from 5.1 to 9.0. Each gram of carbon produced 17.4 mg of linoleic acid, 17.0 mg of gamma-linolenic acid, 103.0 mg of arachidonic acid and 194.2 mg of total PUFAs at 20 degrees C, while it yielded 21.4 mg of linoleic acid, 25.6 mg of gamma-linolenic acid, 2.6 mg of gamma-linolenic acid, 110.3 mg of arachidonic acid, 4.3 mg of eicosapentaenoic acid and 218.4 mg of total PUFAs at 12 degrees C. A high degree of unsaturation was found at low temperature incubation. Linseed oil supplementation (1%, w/v) increased the PUFAs production and each gram of carbon produced 403.4 mg of alpha-linolenic acid, 123.1 mg of arachidonic acid, 33.6 mg of eicosapentaenoic acid, 1.68 mg of docosahexaenoic acid and 943.2 mg of total PUFAs. From the optimization of culture media and conditions, PUFAs production increased from 30% to 5 times that was optimal for practical use.     

Growth of and omega-3 fatty acid production by Phaeodactylum tricornutum under different culture conditions

Detailed studies were carried out on the effects of nitrogen source, phosphate, sodium chloride, growth factors, precursors, CO2, temperature, initial pH, and inoculum size on biomass and eicosapentaenoic acid (EPA) production by Phaeodactylum tricornutum. The EPA content of total fatty acids increased with increasing concentrations of nitrate and urea. Sodium chloride was not required for growth or EPA production. While vitamins B1 and B12 did not affect growth significantly, EPA yield was increased by 65% by B12 supplementation. Maximum EPA production occurred when the air gassing supply was supplemented with 1% CO2. Optimum culture temperature and initial pH for EPA production were 21.5 to 23 degrees C and 7.6, respectively. EPA yields of up to 133 mg/liter of culture were observed. EPA constituted up to 30 to 40% of total fatty acids.     

Growth of and omega-3 fatty acid production by Phaeodactylum tricornutum under different culture conditions.

Detailed studies were carried out on the effects of nitrogen source, phosphate, sodium chloride, growth factors, precursors, CO2, temperature, initial pH, and inoculum size on biomass and eicosapentaenoic acid (EPA) production by Phaeodactylum tricornutum. The EPA content of total fatty acids increased with increasing concentrations of nitrate and urea. Sodium chloride was not required for growth or EPA production. While vitamins B1 and B12 did not affect growth significantly, EPA yield was increased by 65% by B12 supplementation. Maximum EPA production occurred when the air gassing supply was supplemented with 1% CO2. Optimum culture temperature and initial pH for EPA production were 21.5 to 23 degrees C and 7.6, respectively. EPA yields of up to 133 mg/liter of culture were observed. EPA constituted up to 30 to 40% of total fatty acids.     

Tannase production by Paecilomyces variotii

Surface response methodology was applied to the optimization of the laboratory scale production of tannase using a lineage of Paecilomyces variotii. A preliminary study was conducted to evaluate the effects of variables, including temperature ( degrees C), residue (%) (coffee husk:wheat bran), tannic acid (%) and salt solutions (%) on the production of tannase during 3, 5 and 7 days of fermentation. Among these variables, temperature, residues and tannic acid had significant effects on tannase production. The variables were optimized using surface response methodology. The best conditions for tannase production were: temperature (29-34 degrees C); tannic acid (8.5-14%); % residue (coffee husk:wheat bran 50:50) and incubation time of 5 days. The supplementation of external nitrogen and carbon sources at 0.4%, 0.8% and 1.2% concentration on tannase production were studied in the optimized medium. Three different nitrogen sources included yeast extract, ammonia nitrate and sodium nitrate along with carbon source (starch) were studied. Only ammonia nitrate showed a significant effect on tannase production. After the optimization process, the tannase activity increased 8.6-fold.     

Utilization of rice bran as nutrient source for fermentative lactic acid production

To reduce nutrient cost for lactic acid production, rice bran, one of agricultural wastes, was chosen as a nutrient source in this study. Although rice bran is rich in protein and vitamins, the use of rice bran without any treatment was inefficient in lactic acid production. Rice bran was treated by acid-hydrolysis before it was put in experiment, when it was hydrolyzed at initial pH 1, 30 g/L rice bran could provide a productivity to that degree of about 8 g/L YE, showing such a desirable result that the use of rice bran as nutrient source would be a solution for reducing nutrient cost. However, the addition of hydrolyzed rice bran prolonged lag phase of fermentation, especially, in the fermentation with rice bran hydrolyzed at initial pH 0.5, a prolonged lag phase of about 40 h was observed. According to the quantitative determination of thiamine, pyridoxine, organic nitrogen and carbon, the prolongation of lag phase might be the result from the destruction of B vitamins and excessive hydrolysis of protein. To shorten the lag phase, combining hydrolyzed rice bran with yeast extract (YE) of small amount was considered to be a solution. When 3g/L YE was combined with 30 g/L rice bran hydrolyzed at initial pH 1, obtained was a productivity 1.6 times higher than that of the control fermentation with 15 g/L YE.     

Protective effect of eicosapentaenoic acid on palmitate-induced apoptosis in neonatal cardiomyocytes

Long chain polyunsaturated fatty acids (PUFAs) play an important role in cardioprotection. These effects have been largely attributed to membrane docosahexaenoic acid. Conversely, saturated fatty acids trigger apoptosis in cardiomyocytes, with modifications of mitochondrial properties including cardiolipin loss, cytochrome c release and caspase-3 activation. The purpose of this study was to investigate the chronic effect of eicosapentaenoic acid (EPA) on mitochondrial apoptosis induced by palmitate treatment and the associated signalling pathways. Confluent cultures of rat neonatal cardiomyocytes were treated for 2 days in media enriched with either EPA or arachidonic acid (AA) and then exposed to palmitate (0.5 mM) to induce apoptosis, in the absence of PUFA supplements. The EPA treatment resulted in significant membrane enrichment in n-3 PUFAs, especially in docosapentaenoic acid (DPA), and a large decrease in AA. Both AA and EPA treatments prevented caspase-3 activation, translocation of Bax to the mitochondria and release of cytochrome c induced by palmitate treatment. Furthermore, EPA, but not AA prevented the loss of mitochondrial cardiolipin due to apoptosis. These results suggest that EPA supplementation is able to protect cardiomyocytes against palmitate-induced apoptosis via an implication of different mitochondrial elements, possibly through its elongation to DPA, which is very efficient in cardiomyocytes.     

Incorporation of [3H]Arachidonic and [14C]Eicosapentaenoic Acids into Glycerophospholipids and Their Metabolism via Lipoxygenases in Isolated Brain Cells from Rainbow Trout Oncorhaynchus mykaiss

The incorporation of [3H]arachidonate [( 3H]AA) and [14C]eicosapentaenoate [( 14C]EPA) into glycerophospholipids was studied in isolated brain cells from rainbow trout, a teleost fish whose lipids are rich in (n-3) polyunsaturated fatty acids (PUFAs). EPA was incorporated into total lipid to a greater extent than AA, but the incorporation of both PUFAs into total glycerophospholipids was almost identical. The incorporation of both AA and EPA was greatest into phosphatidylethanolamine (PE). However, when expressed per milligram of individual phosphoglycerides, both AA and EPA were preferentially incorporated into phosphatidylinositol (PI), the preference being significantly greater with AA. On the same basis, significantly more EPA than AA was incorporated into phosphatidylcholine (PC). When double-labelled cells were challenged with calcium ionophore A23187, the 3H and 14C released from the cells closely paralleled each other, peaking at 10 min after addition of ionophore. The 12-monohydroxylated derivative was the pre-dominant lipoxygenase product from both AA and EPA with a rank order of 12-hydroxyeicosatetraenoic acid (12-HETE) greater than leukotriene B4 (LTB4) greater than 5-HETE greater than 15-HETE for the AA products and 12-hydroxyeicosapentaenoic acid (12-HEPE) greater than 5-HEPE greater than LTB5 greater than 15 HEPE for EPA products. The 3H/14C (dpm/dpm) ratios in the glycerophospholipids, total released radioactivity, and the lipoxygenase products suggested that PC rather than PI was the likely source of eicosanoid precursors in trout brain cells.     

Effects of polyunsaturated fatty acids and gonadotropin on prostaglandin series E production in a primary testis cell culture system for the European sea bass

Prostaglandin series E (PGE) production by mixed populations of isolated sea bass Dicentrarchus labrax testicular cells was measured after culture at 20° C in L-15 for up to 24 h in the absence or presence of arachidonic acid (AA), eicosapentaenoic acid (EPA), docosahexaenoic acid (DHA) and/or gonadotropin (hCG). AA stimulated a significant dose- and time-dependent increase in PGE production. EPA stimulated PGE production only during the first 6 h although levels were 26·4% those induced with AA; DHA reduced PGE production. Although hCG alone had no effect, it enhanced AA-induced PGE formation and suppressed EPA-induced PGE production. These results suggest that essential PUFAs modulate significantly testicular PGE production in vitro and therefore may have important effects on steroidogenesis and spermiation in the male European sea bass.     

Cellulolytic enzymes on lignocellulosic substrates in solid state fermentation by <Emphasis Type="Italic">Aspergillus niger</Emphasis>

The production of cellulolytic enzymes by Aspergillus niger on lignocellulosic substrates groundnut fodder, wheat bran, rice bran and sawdust in solid state fermentation in a laboratory scale was compared. Czapek Dox liquid broth amended with cellulose (0.5%) was used to moisten lignocellulosic solid supports for cultivation of Aspergillus niger. The production of filter paperase, carboxymethyl cellulase and -glucosidase were monitored at daily intervals for 5 days. The peak production of the enzymes occurred within 3 days of incubation. Among solid supports used in the study, wheat bran was the best solid matrix followed by groundnut fodder in production of cellulolytic enzymes in solid state fermentation. Groundnut fodder supported significant production of FPase (2.09 FPU/g), CMCase (1.36 U/g) and -glucosidase activity (0.0117 U/g) in solid state fermentation. Considerable secretion of protein (5.10 mg/g) on groundnut fodder at peak time interval 1st day of incubation was recorded.     

Content of polyunsaturated fatty acids (PUFAs) in serum and liver of rats fed restricted diets supplemented with vitamins B2, B6 and folic acid

The aim of study was to investigate an influence of nutritional deficiency and dietary addition of vit. B(2), B(6) and folic acid on PUFAs content in rats' serum and liver. Limitation of consumption full value diet to 50% of its previously determined daily consumption, enriched with m/a vitamins, significant decreased of linoleic (LA) and alpha-linolenic (ALA) acids as well as distinctly increased arachidonic (AA) and docosahexaenoic (DHA) acids content in serum in 30th day. In 60th day lower content of AA and DHA fatty acids was found. Nutrition with such diet, lasting 90 days caused decrease of LA content and increase of AA. Diet limitation to its 30% of daily consumption decreased of eicosapentaenoic acid (EPA) and DHA in the 30th day, while AA and DHA content was increased in the 60th day. Distinct decrease of AA content and increase of EPA content were found in the 90th day of experiment. Use of diets, with limited consumption to 50% caused increase of LA and ALA acids content while AA and DHA acids content were significantly decreased in the liver, in 90th day. Limited consumption supplemented diet to 30% caused in liver significant decrease of LA and increase of EPA acids content.     

The inhibitory effect of polyunsaturated fatty acids on human CYP enzymes

The inhibitory effect of saturated fatty acids (SFAs): palmitic acid (PA), stearic acid (SA) and polyunsaturated fatty acids (PUFAs): linoleic acid (LA), linolenic acid (LN), arachidonic acid (AA), eicosapentaenoic acid (EPA) and docosahexaenoic acid (DHA) on six human drug-metabolizing enzymes (CYP1A2, 2C9, 2C19, 2D6, 2E1 and 3A4) was studied. Supersomes from baculovirus-expressing single isoforms were used as the enzyme source. Phenacetin O-deethylation (CYP1A2), diclofenac 4-hydroxylation (CYP2C9), mephenytoin 4-hydroxylation (CYP2C19), dextromethorphan O-demethylation (CYP2D6), chlorzoxazone 6-hydroxylation (CYP2E1) and midazolam 1-hydroxylation (CYP3A4) were used as the probes. Results show that all the five examined PUFAs competitively inhibited CYP2C9- and CYP2C19-catalyzed metabolic reactions, with Ki values ranging from 1.7 to 4.7 microM and 2.3 to 7.4 microM, respectively. Among these, AA, EPA and DHA tended to have greater inhibitory potencies (lower IC(50) and Ki values) than LA and LN. In addition, these five PUFAs also competitively inhibited the metabolic reactions catalyzed by CYP1A2, 2E1 and 3A4 to a lesser extent (Ki values>10 microM). On the other hand, palmitic and stearic acids, the saturated fatty acids, had no inhibitory effect on the activities of six human CYP isozymes at concentrations up to 200 microM. Incubation of PUFAs with CYP2C9 or CYP2C19 in the presence of NADPH resulted in the decrease of PUFA concentrations in the incubation mixtures. These results indicate that the PUFAs are potent inhibitors as well as the substrates of CYP2C9 and CYP2C19.     

Polyunsaturated fatty acids production by solid-state fermentation on polyurethane foam by Mortierella alpina

Polyunsaturated fatty acids (PUFAs) are essential in healthy diets and their production is extremely important. Natural sources of PUFAs includes animal and aquatic products such as marine fish oil, however there are several limitations such as the decrease of fish stocks throughout the world. Thus, microbial oils are a preferable source of PUFAs. Herein, it was studied the production of PUFAs by Mortierella alpina under solid-state fermentation (SSF) using polyurethane foam as inert substrate and synthetic medium or lignocellulosic hydrolysate as source of C, N, and other nutrients. Several parameters of fermentation conditions were evaluated as carbon source, inductors addition, ratio C/N and temperature. The highest amount of total PUFAs per mass of solid (535.41 ± 24.12 mg/g), linoleic acid (129.66 ± 5.84 mg/g), and α-linoleic acid (401.93 ± 18.10 mg/g) were produced when the culture medium contained 20 g/L glucose, 10% (w/v) linseed oil, the C/N ratio was adjusted to 25 and the incubation temperature was 25°C for 3 days decreasing to 16°C on the remaining 4 days of fermentation. In addition, a hemicellulosic hydrolysate can be used as low-cost substrate to produce PUFAs, although the production was lower than the achieved with synthetic medium. SSF showed an interesting technology for microbial PUFAs production.     

Parametric optimization of feruloyl esterase production from Aspergillus terreus strain GA2 isolated from tropical agro-ecosystems cultivating sweet sorghum

A fungal strain, Aspergillus terreus strain GA2, isolated from an agricultural field cultivating sweet sorghum, produced feruloyl esterase using maize bran. In order to obtain maximum yields of feruloyl esterase, the solid state fermentation (SSF) conditions for enzyme production were standardized. Effective feruloyl esterase production was observed with maize bran as substrate followed by wheat bran, coconut husk, and rice husk among the tested agro-waste crop residues. Optimum particle size of 0.71- 0.3 mm and moisture content of 80% favored enzyme production. Moreover, optimum feruloyl esterase production was observed at pH 6.0 and a temperature of 30 degrees C. Supplementation of potato starch (0.6%) as the carbon source and casein (1%) as the nitrogen source favored enzyme production. Furthermore, the culture produced the enzyme after 7 days of incubation when the C:N ratio was 5. Optimization of the SSF conditions revealed that maximum enzyme activity (1,162 U/gds) was observed after 7 days in a production medium of 80% moisture content and pH 6.0 containing 16 g maize bran [25% (w/v)] of particle size of 0.71-0.3 mm, 0.6% potato starch, 3.0% casein, and 64 ml of formulated basal salt solution. Overall, the enzyme production was enhanced by 3.2-fold as compared with un-optimized conditions.     

Contrasting effects of membrane enrichment with polyunsaturated fatty acids on phospholipid composition and cholesterol efflux from cholesterol-loaded J774 mouse or primary human macrophages

A high consumption of polyunsaturated fatty acids (PUFAs), particularly n-3 PUFAs, is atheroprotective. PUFAs incorporation into membrane phospholipids alters the functionality of membrane proteins. We studied the consequences of the in vitro supplementation of several PUFAs on the FA profiles and on ABCA1-dependent cholesterol efflux capacities from cholesterol-loaded macrophages. Arachidonic acid (AA, C20:4 n-6) and, to a lesser extent, eicosapentaenoic acid (EPA, C20:5 n-3), dose-dependently impaired cholesterol efflux from cholesterol-loaded J774 mouse macrophages without alterations in ABCA1 expression, whereas docosahexaenoic acid (DHA, C22:6 n-3) had no impact. AA cells exhibited higher proportions of arachidonic acid and adrenic acid (C22:4 n-6), its elongation product. EPA cells exhibited slightly higher proportions of EPA associated with much higher proportions of docosapentaenoic acid (C22:5 n-3), its elongation product and with lower proportions of AA. Conversely, both EPA and DHA and, to a lesser extent, AA decreased cholesterol efflux from cholesterol-loaded primary human macrophages (HMDM). The differences observed in FA profiles after PUFA supplementations were different from those observed for the J774 cells. In conclusion, we are the first to report that AA and EPA, but not DHA, have deleterious effects on the cardioprotective ABCA1 cholesterol efflux pathway from J774 foam cells. Moreover, the membrane incorporation of PUFAs does not have the same impact on cholesterol efflux from murine (J774) or human (HMDM) cholesterol-loaded macrophages. This finding emphasizes the key role of the cellular model in cholesterol efflux studies and may partly explain the heterogeneous literature data on the impact of PUFAs on cholesterol efflux.     

Role of omega-3 polyunsaturated fatty acids on cyclooxygenase-2 metabolism in brain-metastatic melanoma

Cyclooxygenase-2 (COX-2) is important in the progression of epithelial tumors. Evidence indicates that omega-6 PUFAs such as arachidonic acid (AA) promote the growth of tumor cells; however, omega-3 fatty acids [eicosapentaenoic acid (EPA) and docosahexaenoic acid (DHA)] inhibit tumor cell proliferation. We investigated the effects of omega-3 PUFA on the expression and function of COX-2 in 70W, a human melanoma cell line that metastasizes to the brain in nude mice. We show that 1) tumor necrosis factor-alpha upregulates the expression of both COX-2 mRNA and prostaglandin E2 (PGE2) production, and 2) omega-3 and omega-6 PUFA regulate COX-2 mRNA expression and PGE2 production. AA increased COX-2 mRNA expression and prostaglandin production in omega-6-stimulated 70W cells. Conversely, COX-2 mRNA expression decreased in cells incubated with EPA or DHA. AA increased Matrigel invasion 2.4-fold, whereas EPA or DHA did not. Additionally, PGE2 increased in vitro invasion 2.5-fold, whereas exposure to PGE3 significantly decreased invasion. Our results demonstrate that incubation of 70W cells with either AA or PGE2 increased invasiveness, whereas incubation with EPA or DHA downregulated both COX-2 mRNA and protein expression, with a subsequent decrease in Matrigel invasion. Taken together, these results indicate that omega-3 PUFA regulate COX-2-mediated invasion in brain-metastatic melanoma.     

Tetracycline production with sweet potato residue by solid state fermentation

For saving energy in antibiotic production and reducing the amount of agricultural wastes, solid state fermentation was used in this study to produce tetracycline with sweet potato residue by Streptomyces viridifaciens ATCC 11989. It was found that the optimal media for tetracycline production were sweet potato residue 100 g, organic nitrogen (rice bran, wheat bran, or peanut meal) 20 g, (NH(4))(2)SO(4) 2.4 g, KH(2)PO(4) 0.4 g, CaCO(3) 1.8 g, NaCl 0.6 g, MgCl(2) 0.8 g, soluble starch 10 g, methionine 0.2 g, histidine 0.8 g, and monosodium glutamate 1.6 g with initial moisture content 68-72%, and initial pH 5.8-6.0. Each gram of dry weight substrate was inoculated with 1.0 x 10(8) conidia and incubated at 26 degrees C for 5-7 days, producing 4720 mug of total tetracycline equivalent potency. When incubated at 26 degrees C with the initial moisture content 68%, the conidia in solid media germinated on the second day, mycelia grew abundantly on the third day and reached stationary phase on the sixth day. The antibiotic production was consistent with the morphogenesis of S. viridifaciens: activity could be detected on the third day, had the maximal potency on the sixth day, and decreased slightly on the tenth day. (11-3-88 tly).     

Comparative study of aflatoxins M1 and B1 production in solid-state and shaking liquid cultures

Production of aflatoxins M1 (AFM) and B1 (AFB) by Aspergillus flavus NRRL 3251 in solid-state and shaking liquid cultures using rice as the carbon source was compared. In general, solid-state cultures produced more aflatoxins than shaking liquid cultures on an equal rice weight basis. Solid-state cultures with continuous shaking yielded higher levels of toxins than those with intermittent shaking. However, intermittent shaking is a feasible replacement for the continuous shaking method for AFM production. A typical solid rice culture supplemented with yeast extract produced 30 and 2600 mg per kg rice of AFM and AFB, respectively, in 8 days at 29 degrees C. The optimal culture conditions for toxin production in a shaking liquid culture were also studied. Parameters under consideration included the amount of carbon (rice) and nitrogen source, initial medium pH, and aeration rate. At optimum conditions, a representative shaking liquid culture produced 18 and 1680 mg per kg rice of AFM and AFB, respectively, in 5 days at 29 degrees C. This shaking liquid culture appears feasible for scaling up and routine production of AFM and AFB for toxicological investigations.     

Statin treatment alters serum n-3 and n-6 fatty acids in hypercholesterolemic patients

Statins are highly effective cholesterol-lowering drugs but may have broader effects on metabolism. This investigation examined effects of simvastatin on serum levels of n-6 and n-3 polyunsaturated fatty acids (PUFAs). Subjects were 106 healthy adults with hypercholesterolemia randomly assigned to receive placebo or 40 mg simvastatin daily for 24 weeks. Serum fatty acids were analyzed by gas chromatography. Total fatty acid concentration fell 22% in subjects receiving simvastatin (P<.001), with similar declines across most fatty acids. However, concentrations of arachidonic acid (AA, 20:4n-6), eicosapentanoic acid (EPA, 20:5n-3) and docosahexaenoic acid (DHA, 22:6n-3) were unchanged. Relative percentages of linoleic acid (LA, 18:2n-6) and alpha-linolenic acid (LNA, 18:3n-3), decreased while AA and DHA increased (P's < or = .007). In addition, simvastatin increased the AA:EPA ratio from 15.5 to 18.8 (P<.01), and tended to increase the AA:DHA ratio (P=.053). Thus, simvastatin lowered serum fatty acid concentrations while also altering the relative percentages of important PUFAs.