Impact of application of organic waste materials on microbial and enzyme activities of mine soils in the Lusatian coal mining region

The objective of the present work was to study the short-term stimulation of microbial and enzyme activity in mine soils by application of organic waste materials in lysimeter and mesocosm studies. The mine soils derived from tertiary and quaternary deposits were ameliorated with brown coal filter ash (tertiary deposits) and lime (quaternary deposits). At the beginning of recultivation the soils were treated with varying amounts of sewage sludge, coal sludge, composted sewage sludge and compost to a depth of 30 cm. In the first 2 years after application of organic waste materials we found a very low level of microbial properties especially in the sandy materials from quaternary deposits but a significant increase in microbial respiration, substrate induced respiration and enzyme activities like invertase and alkaline phosphatase with increasing application rates of sewage sludge, compost and sewage sludge mixed with coal sludge. This can be explained by an increase in organic matter and nutrient content of the soils and an improvement of soil physical properties such as water and nutrient retention capacity. Additionally it can be assumed, that constituents of the coal admixtures of tertiary deposits can be mineralised or converted by the soil microorganisms. In the tertiary materials ameliorated with brown coal ash the highest amounts of microbial and enzyme activities were measured after application of nitrogen-rich sewage sludge or very high amounts of mature compost mainly consisting of green waste. Compared with sewage sludge the stimulating effects of composted sewage sludge were quite lower because of organic matter fragmentation and a reduced energy and nutrient supply to soil microorganisms. This revised version was published online in June 2006 with corrections to the Cover Date.     

Detection of anaerobic processes and microorganisms in immobilized activated sludge of a wastewater treatment plant with intense aeration

Attached activated sludge from the Krasnaya Polyana (Sochi) wastewater treatment plant was studied after the reconstruction by increased aeration and water recycle, as well as by the installation of a bristle carrier for activated sludge immobilization. The activated sludge biofilms developing under conditions of intense aeration were shown to contain both aerobic and anaerobic microorganisms. Activity of a strictly anaerobic methanogenic community was revealed, which degraded organic compounds to methane, further oxidized by aerobic methanotrophs. Volatile fatty acids, the intermediates of anaerobic degradation of complex organic compounds, were used by both aerobic and anaerobic microorganisms. Anaerobic oxidation of ammonium with nitrite (anammox) and the presence of obligate anammox bacteria were revealed in attached activated sludge biofilms. Simultaneous aerobic and anaerobic degradation of organic contaminants by attached activated sludge provides for high rates of water treatment, stability of the activated sludge under variable environmental conditions, and decreased excess sludge formation.     

Microbiological monitoring in the biodegradation of sewage sludge and food waste

AIM: To study the microbiology of intensive, in-vessel biodegradation of a mixture of sewage sludge and vegetable food waste. METHODS AND RESULTS: The biodegradation was performed in a closed reactor with the addition of a starter culture of Bacillus thermoamylovorans SW25 under conditions of controlled aeration, stirring, pH and temperature (60 degrees C). The content of viable bacterial cells, determined by flow cytometry, increased from 5 x 108 g-1 of dry matter to 61 x 108 g-1 for 6 days of the process and then dropped to the initial value at the end of the process. The reductions of organic matter, 16S rRNA of methanogens and coenzyme F420 fluorescence during 10 days of the treatment were 67, 54 and 87% of the initial values, respectively. The biodegradability of the organic matter decreased during the 10 days of the treatment from 3.8 to 1.3 mg CO2 g-1 of organic matter per day. The treatment of sewage sludge and food waste at 60 degrees C did not remove enterobacteria, which are the agents of intestinal infections, from the material. The percentage of viable enterobacterial cells, determined by fluorescent in situ hybridization (FISH) with Enterobacteriaceae-specific oligonucleotide probe and flow cytometry, varied from 1 to 14% of the viable bacterial cells. CONCLUSIONS: The mixture of sewage sludge and food waste can be degraded by the aerobic thermophilic bacteria; the starter culture of Bacillus thermoamylovorans SW25 can be used to perform this process; and enterobacteria can survive under treatment of sewage sludge and food waste at 60 degrees C for 13 days. SIGNIFICANCE AND IMPACT OF THE STUDY: The results show that FISH with an oligonucleotide probe can be used to study not only the growth but also the degradation of biomass. Obtained results could be used to design the bioconversion of sewage sludge and food waste into organic fertilizer.     

Organic matter components, aggregate stability and biological activity in a horticultural soil fertilized with different rates of two sewage sludges during ten years

The effects of the application as fertilizer during ten years of two sewage sludges (aerobically and anaerobically digested, at rates of 400, 800, and 1200 kg of N/ha yr), on the aggregate stability and contents of related organic matter components, microbial biomass and levels of five enzymatic activities (alkaline phosphomonoesterase, phosphodiesterase, urease, arylsulphatase and dehydrogenase) were investigated. The application of both sludges at mid and high rates gave rise to significant increases of organic matter, humified substances and humic acids, but no effects on carbohydrates, microbial gums and aggregate stability were observed. As for biological activity in soils, the high variability of data led to a general absence of statistical significance despite the large differences between treatments observed. Significant increases of phosphodiesterase activity were nevertheless produced by the high rate of aerobic sludge and the mid and high rates of the anaerobic sludge.     

Venturi aeration and thermophilic aerobic sewage sludge digestion in small-scale reactors

Summary The aeration performance of two venturi aeration reactors (operating volumes 381 and 251) was studied for an air-water system. It was found that the mass transfer coefficient (k _la) could be described in terms of the superficial gas velocity (V _s) alone by the simple expressionk _La=aV _infb ^supS with constantsa=0.313,b=0.579 for the 38-1 reactor anda=0.214,b=0.534 for the 25-1 reactor. A similar relationship was obeyed when the 38-1 reactor was aerated with a diffuser tile (a=17.0,b=1.52). A linear relationship betweenk _La and gas hold-up was observed for the 38-1 reactor with both venturi and diffuser aeration. The 25-1 reactor was used successfully for the thermophilic aerobic digestion of sewage sludge. A mean sludge temperature rise of 30°C was observed. Chemical oxygen demand, pH, and total solids content of the digested sludge differed significantly from the feed sludge and were similar to values obtained for full-scale thermophilic aerobic digestion. No significant differences between inorganic solids content, dissolved oxygen concentration, or redox potential were observed between feed and digested sludge.     

The theory and design of aerobic biological treatment

The processing of numerous experimental data shows that the high-level and rough treatments of multicomponent sewage water follow different laws. In the case of rough treatment, the classical Monod's model is fairly adequate to the experiment. High concentrations of a pollutant "saturate" the complex of microorganisms (activated sludge or biofilm) and the general oxidation process follows a zero order for the substrate. In the case of high-level treatment, the model of an n order (n > 1) for the substrate is adequate to the experiment. Generalized models of aerobic treatment, independent of the reactor type (an aeration tank, trickling filter, rotating disk), are proposed.     

Microbial composition of the activated sludge of Moscow wastewater treatment plants

The contribution of the major technologically important microbial groups (ammonium- and nitrite-oxidizing, phosphate-accumulating, foam-inducing, and anammox bacteria, as well as planctomycetes and methanogenic archaea) was characterized for the aeration tanks of the Moscow wastewater treatment facilities. FISH investigation revealed that aerobic sludge were eubacterial communities; the metabolically active archaea contributed insignificantly. Stage II nitrifying microorganisms and planctomycetes were significant constituents of the bacterial component of activated sludges, with Nitrobacter spp. being the dominant nitrifiers. No metabolically active anammox bacteria were revealed in the sludge from aeration tanks. The sludge from the aeration tanks using different wastewater treatment technologies were found to have differing characteristics. Abundance of the nitrifying and phosphate-accumulating bacteria in the sludge generally correlated with microbial activity in microcosms and with efficiency of nitrogen and phosphorus removal from wastewater. The highest microbial numbers and activity were found in the sludge of the tanks operating according to the technologies developed in the universities of Hannover and Cape Town. The activated sludge from the Novokur’yanovo facilities, where abundant growth of filamentous bacteria resulted in foam formation, exhibited the lowest activity. The group of foaming bacteria included Gordonia spp. and Acinetobacter spp utilizing petroleum and motor oils, Sphaerotilus spp. utilizing unsaturated fatty acids, and Candidatus ‘Microthrix parvicella’. Thus, the data on abundance and composition of metabolically active microorganisms obtained by FISH may be used for the technological control of wastewater treatment.     

Effect of sewage sludge treatment and additional aerobic post-stabilization revealed by infrared spectroscopy and multivariate data analysis

Sewage sludge samples representing different stages during waste water and sewage sludge treatment were collected at four Austrian municipal waste water treatment plants. Changes of sludge composition are reflected by a specific infrared spectroscopic pattern. Anaerobically digested sludge was subjected to aeration in lab-scale reactors in order to find out if post-aeration after anaerobic digestion provides enhanced organic matter degradation and stabilization. Spectral data were evaluated by means of multivariate statistics. Similar spectral characteristics of sludge degradation stages were visualized by principal component analysis. The effect of additional aerobic treatment of anaerobically stabilized sludge was revealed by discriminant analysis that distinguishes additionally aerated sludge from all the other degradation stages of sludge because of changes in the spectral pattern by increasing stabilization. Based on partial least squares regression (PLSR) a correlation coefficient of R² = 0.91 was found between spectral characteristics and the chemical oxygen demand (COD).     

Porphyrin formation byArthrobacter globiformis

The extraction properties, absorption spectra, and chromatographic behaviour of the red extracellular pigment in cultures ofArthrobacter globiformis grown in a mineral salts-glucose medium were identical with those of coprophyrin III. Iron and zinc in small amounts were required for maximum production of the porphyrin. Large amounts of iron failed to suppress porphyrin accumulation in spite of their complete removal from the medium by the bacteria. The effect of iron on porphyrin metabolism in microorganisms is discussed. Accumulation of the porphyrin was highest with moderate aeration; it was almost completely suppressed upon exposure of porphyrin-accumulating cultures to low as well as high aeration rates. At a low aeration rate it was restored by addition of succinic acid, glutamic acid or δ-aminolevulinic acid but at a high aeration by δ-aminolevulinic acid only. At a low aeration rate more porphyrin was formed from δ-aminolevulinic acid than at a high rate.     

Influence of process conditions on end product formation from Clostridium thermocellum 27405 in solid substrate cultivation on paper pulp sludge

Solid substrate cultivation of thermophilic, anaerobic bacteria offers an alternative production method for many bio-based chemicals; however the process must be optimized for each substrate-organism fermentation. The effects of initial substrate moisture content (SMC, 30%, 50% and 70% wet-basis), supplemental nutrient concentration (SNC, 12%, 50% and 100%) and duration of cultivation time (6, 10 and 14 days), on product formation (lactate, ethanol and acetate) by Clostridium thermocellum 27405 were examined during growth on paper pulp sludge. Water activities at moisture contents above 30% wet-basis were essentially identical ( approximately 0.99), yet the water contents differed significantly, and affected the metabolic activity of C. thermocellum. Increases in initial substrate moisture content from 50% to 70% for cultures supplemented with 50% or 100% nutrients resulted in a 75-145 mM increase in total end products. At 70% SMC, the addition of 100% SNC generated a 56% increase in product formation above the addition of 50% nutrient supplementation. Increases in the quantity of free water present in the solid substrate cultivation system up to the water holding capacity of the paper pulp sludge led to improved performance of this anaerobic bacterium. While nutrient supplementation is common in the form of salts for many aerobic microorganisms, efficient metabolism for anaerobic C. thermocellum grown in SSC was highly dependent on added salts, vitamins and reducing agents. Further studies are needed to determine if this is a general effect for other anaerobes grown in solid substrate cultures.     

Thermophilic anaerobic digestion of sewage sludge: focus on the influence of the start-up. A review

The thermophilic anaerobic digestion (TAD) of sewage sludge has often been found to be less stable than mesophilic treatment. In comparison to mesophilic digesters, thermophilic reactors treating sludge are generally characterized by relatively high concentrations of volatile fatty acids (VFA) in the effluent along with poor effluent quality, indicating a lower level of process stability. However, reviewing the literature related to the procedure for obtaining a thermophilic inoculum, it seems that most of the problems associated with the instability and the accumulation of organic intermediates are the result of the manner in which the thermophilic sludge has been obtained. In this paper, the different options available for obtaining an anaerobic digester operating at thermophilic temperature (55°C) have been reviewed. In this light, rapid heating to the target temperature followed by the development of thermophilic microorganisms, which can be determined by VFA dropping to ≤500?mg acetic acid L^?1 before increasing the organic loading rate (OLR), has been determined the most suitable means of establishing TAD.     

Physiology and enzymology of thermophilic anaerobic bacteria degrading starch

Abstract The capability of secreting thermoactive enzymes exhibiting α-amylase and pullulanase with debraching activity, seems to be widely distributed amongst anaerobic thermophilic bacteria. Interestingly, pullulanase formed by these bacteria displays dual specificity by attacking α-1,6- as well as α-1,4-glycosidic linkages in branched glucose polymers. Unlike the enzyme system of aerobic microorganisms the majority of starch hydrolysing enzymes of anaerobic bacteria is metal indepedent and is extremely thermostable. This enzyme system is controlled by substrate induction and catabolite repression; enzyme expression is accomplished when maltose or maltose-containing carbohydrates are used as substrates. By developing a process in continuous culture we were able to greatly enhance enzyme synthesis and release by anaerobic thermophilic bacteria. An elevation in the specific activities of cell-free amylases and pullulanases could also be achieved by entrapping of bacteria in calcium alginate beads. The unique properties of extracellular enzymes of thermophilic anaerobic bacteria makes this group of organisms suitable candidates for inductrial application.     

Fate of explosives and their metabolites in bioslurrytreatment processes

Microcosm tests simulating bioslurry reactors with 40% soil content, containing high concentrations of TNT and/or RDX, and spiked with either [14C]-TNT or [14C]-RDX were conducted to investigate the fate of explosives and their metabolites in bioslurry treatment processes. RDX is recalcitrant to indigenous microorganisms in soil and activated sludge under aerobic conditions. However, soil indigenous microorganisms alone were able to mineralize 15% of RDX to CO2 under anaerobic condition, and supplementation of municipal anaerobic sludge as an exogenous source of microorganisms significantly enhanced the RDX mineralization to 60%. RDX mineralizing activity of microorganisms in soil and sludge was significantly inhibited by the presence of TNT. TNT mineralization was poor (< 2%) and was not markedly improved by the supplement of aerobic or anaerobic sludge. Partitioning studies of [14C]-TNT in the microcosms revealed that the removal of TNT during the bioslurry process was due mainly to the transformation of TNT and irreversible binding of TNT metabolites onto soil matrix. In the case of RDX under anaerobic conditions, a significant portion (35%) of original radioactivity was also incorporated into the biomass and bound to the soil matrix.     

Anaerobic Processes as the Core Technology for Sustainable Domestic Wastewater Treatment: Consolidated Applications, New Trends, Perspectives, and Challenges

Anaerobic digesters have been responsible for the removal of large fraction of organic matter (mineralization of waste sludge) in conventional aerobic sewage treatment plants since the early years of domestic sewage treatment (DST). Attention on the anaerobic technology for improving the sustainability of sewage treatment has been paid mainly after the energy crisis in the 1970s. The successful use of anaerobic reactors (especially up-flow anaerobic sludge blanket (UASB) reactors) for the treatment of raw domestic sewage in tropical and sub-tropical regions (where ambient temperatures are not restrictive for anaerobic digestion) opened the opportunity to substitute the aerobic processes for the anaerobic technology in removal of the influent organic matter. Despite the success, effluents from anaerobic reactors treating domestic sewage require post-treatment in order to achieve the emission standards prevailing in most countries. Initially, the composition of this effluent rich in reduced compounds has required the adoption of post-treatment (mainly aerobic) systems able to remove the undesirable constituents. Currently, however, a wealth of information obtained on biological and physical-chemical processes related to the recovery or removal of nitrogen, phosphorus and sulfur compounds creates the opportunity for new treatment systems. The design of DST plant with the anaerobic reactor as core unit coupled to the pre- and post-treatment systems in order to promote the recovery of resources and the polishing of effluent quality can improve the sustainability of treatment systems. This paper presents a broader view on the possible applications of anaerobic treatment systems not only for organic matter removal but also for resources recovery aiming at the improvement of the sustainability of DST.     

Effects of oxygen exposure on respiratory activities of Desulfovibrio desulfuricans strain DvO1 isolated from activated sludge

The present study addresses the effects of oxygen exposure on the aerobic and anaerobic respiratory activity of Desulfovibrio desulfuricans strain DvO1. This strain was isolated from the highest sulfate-reduction positive most-probable-number dilution (10(6)) of an activated sludge sample, which had been subjected to 120 h of continuous aeration. Washed cell suspensions of strain DvO1 were aerated at 50% atmospheric oxygen saturation in sulfide-free media for a period of 33 h in the presence or absence of an external electron donor (10 mM lactate). During the aeration periods, samples were removed at intervals for determination of anaerobic INT [2-(p-iodophenyl)-3-(p-nitrophenyl)-5-phenyl tetrazolium chloride]-reducing activity, anaerobic sulfate-reducing activity, and oxygen-reducing activity. The cell suspension aerated in the absence of lactate showed negligible endogenous oxygen reduction rates and therefore did not consume oxygen during the aeration period. In contrast, the cell suspension aerated in the presence of lactate sustained significant rates of oxygen reduction during the entire 33 h aeration period. Despite this, no explicit differences in the potential INT-, oxygen-, or sulfate-reducing activities were evident between the two cell suspensions during the aeration periods. Strain DvO1 remained viable throughout the 33 h aeration periods irrespective of the presence or absence of lactate, however, the oxygen exposure resulted in a dose-dependent reversible metabolic inactivation. Notably, lactate-dependent anaerobic sulfate-reducing activity recovered quickly upon anaerobiosis, and was more oxygen tolerant than lactate-dependent oxygen-reducing activity.     

Fate of Cryptosporidium oocysts, Giardia cysts, and microbial indicators during wastewater treatment and anaerobic sludge digestion.

The extent of reduction in selected microorganisms was tested during both aerobic wastewater treatment and anaerobic digestion of sludge at the wastewater treatment plant in Ottawa to compare the removal of two encysted pathogenic protozoa with that of microbial indicators. Samples collected included the raw wastewater, the primary effluent, the treated wastewater, the mixed sludge, the decanted liquor, and the cake. All of the raw sewage samples were positive for Cryptosporidium oocysts and Giardia cysts, as well as for the other microorganisms tested. During aerobic wastewater treatment (excluding the anaerobic sludge digestion), Cryptosporidium and Giardia were reduced by 2.96 log10 and 1.40 log10, respectively. Clostridium perfringens spores, Clostridium perfringens total counts, somatic coliphages, and heterotrophic bacteria were reduced by approximately 0.89 log10, 0.96 log10, 1.58 log10, and 2.02 log10, respectively. All of the other microorganisms were reduced by at least 3.53 log10. Sludge samples from the plant were found to contain variable densities of microorganisms. Variability in microbial concentrations was sometimes great between samples, stressing the importance of collecting a large number of samples over a long period of time. In all cases, the bacterial concentrations in the cake (dewatered biosolids) samples were high even if reductions in numbers were observed with some bacteria. During anaerobic sludge digestion, no statistically significant reduction was observed for Clostridium perfringens, Enterococcus sp., Cryptosporidium oocysts, and Giardia cysts. A 1-2 log10 reduction was observed with fecal coliforms and heterotrophic bacteria. However, the method utilized to detect the protozoan parasites does not differentiate between viable and nonviable organisms. On the other hand, total coliforms and somatic coliphages were reduced by 0.35 log10 and 0.09 log10, respectively. These results demonstrate the relative persistence of the protozoa in sewage sludge during wastewater treatment.     

Putative anaerobic activity in aerated composts

It has been suggested that anaerobic microenvironments develop in aerobic composts, regardless of the aeration system used, and that anaerobic activity is responsible for odor generation and nitrogen losses. This study was designed to measure levels of microorganisms capable of anaerobic growth in two aerated composts: municipal solid waste, a relatively nutrient-rich compost, and pulp and paper-mill solid waste, which is relatively nutrient-poor. Anaerobic microorganisms were isolated from both composts at mesophilic and thermophilic temperatures. The majority of the anaerobic mesophiles were facultative anaerobes, whereas facultative, anaerobic thermophiles varied from 0 to 100%. Serially-diluted samples were spot-plated onto various media to preserve microbial consortia. Levels of aerobic and anaerobic exoenzyme production on spot-plates were similar on cell-wall, starch, and casein media. Although microbial levels on spread plates indicate that aerobes are present in much higher numbers than anaerobes (in 47 of 56 subsamples, 90% of the population were aerobes), microbial growth levels and exoenzyme production on spot-plates indicate that anaerobes may be responsible for a large portion (greater than or equal to 72%) of the metabolic activity in anaerobic microenvironments of aerobic composts.     

Thermophilic aerobic wastewater treatment,process performance,biomass characteristics,and effluent quality

Thermophilic aerobic wastewater treatment is reviewed. Thermophilic processes have been studied in laboratory and pilot-scale while full-scale applications are rare. The paper focuses on the microbiology of aerobic thermophiles, performance of the aerobic wastewater treatments, sludge yield, and alternatives to enhance performance of thethermophilic process. Thermophilic processes have been shown to operate under markedly high loading rates (30–180 kg COD m⁻³d⁻¹).Reported sludge production values under thermophilic conditions vary between 0.05 and0.3 kg SS kg COD_removed, which are about the same or lower than generally obtained in mesophilic processes. Compared to analogous mesophilic treatment, thermophilic treatment commonly suffers from poorer effluent quality, measured by lower total COD and filtrated (GF-A) COD removals. However, in the removal of soluble (bacterial membrane filtered) COD both mesophilic and thermophilic treatments have produced similar results. Sludge settle ability in thermophilic processes have been reported to be better or poorer than in analogous mesophilic processes, although cases with better settling properties are rare. Combining thermophilic with mesophilic treatment or ultrafiltration may in some cases markedly improve effluent quality. This revised version was published online in June 2006 with corrections to the Cover Date.     

Microbial community in anaerobic hydrogen-producing microflora enriched from sludge compost

Hydrogen production by thermophilic anaerobic microflora enriched from sludge compost was studied by using an artificial medium containing cellulose powder. Hydrogen gas was evolved with the formation of acetate, ethanol, and butyrate by decomposition of the cellulose powder. The hydrogen production yield was 2.0 mol/mol-hexose by either batch or chemostat cultivation. A medium that did not contain peptone demonstrated a lower hydrogen production yield of 1.0 mol/mol-hexose with less formation of butyrate. The microbial community in the microflora was investigated through isolation of the microorganisms by both plating and denaturing gradient gel electrophoresis (DGGE) of the' PCR-amplified V3 region of 16S rDNA. Sixty-eight microorganisms were isolated from the microflora and classified into nine distinct groups by genetic fingerprinting of the PCR-DGGE or by a random amplified polymorphic DNA analysis and determination of the partial sequence of 16S rDNA. Most of the isolates belonged to the cluster of the thermophilic Clostridium/Bacillus subphylum of low G+C gram-positive bacteria. Product formation by most of the isolated strains corresponded to that produced by the microflora. Thermoanaerobacterium thermosaccharolyticium was isolated in the enrichment culture with or without added peptone. and was detected with strong intensity by PCR-DGGE. Two other thermophilic cellulolytic microorganisms, Clostridium thermocellum and Clostridium cellulosi, were also detected by PCR-DGGE, although they could not be isolated. These findings imply that hydrogen production from cellulose by microflora is performed by a consortium of several species of microorganisms.     

Effect of seeding during thermophilic composting of sewage sludge

The effect of seeding on the thermophilic composting of sewage sludge was examined by measuring the changes in CO2 evolution rates and microbial numbers. Although the succession of thermophilic bacteria and thermophilic actinomycetes clearly reflected the effect of seeding, no clear difference was observed in the overall rate of composting or quality of the composted product.