Defining an optimal carbon source/methionine feed strategy for growth and cephalosporin C formation by Cephalosporium acremonium.

The effect of the method of methionine addition, growth-limiting carbon source (glucose vs sucrose), and culture growth rate on cephalosporin C production was investigated in a Cephalosporium acremonium defined medium fed batch fermentation. Batch addition of methionine, at a concentration of 3 g/L, prior to the start of a fed sucrose fermentation was found to interfere with the ability of the culture to utilize this sugar, thus limiting growth and decreasing cephalosporin C production. Batch methionine addition had no effect on glucose-limited cultures. Concurrent exponential feeding of methionine with sucrose improved both culture growth and productivity. Under the control of identical carbon source limiting feed profiles, sucrose was observed to support greater cephalosporin C production than glucose. Optimal cephalosporin C production in a C. acremonium defined medium fed batch fermentation was obtained through controlling culture growth during the rapid growth phase at a relatively low level with respect to mumax (mu approximately 0.036 h-1) until achieving a desired cell mass with a concurrent sucrose and methionine feed, followed by maintaining relatively vigorous growth (mu approximately 0.01 h-1) with sucrose for the duration of the fermentation.     

Methionine control of cephalosporin C formation

DL -Norleucine, a nonsulfur analogue of methionine was found to markedly stimulate synthesis of cephalosporin C by Cephalosporium acremonium strain CW19 in three different chemically defined media. Methionine, but not norleucine, stimulated cephalosporin C biosynthesis in a crude medium. The lack of stimulation by norleucine in complex medium was shown to be due to lack of uptake of this amino acid by mycelia growing in such a medium. In defined media containing a suboptimal methionine concentration, norleucine stimulated antibiotic production up to the level reached by optimal methionine. At an optimal dose of methionine, norleucine elicited no further increase in cephalosporin C production, indicating that these two amino acids act by the same mechanism. The data strongly indicate that stimulation by methionine is not a function of its ability to donate sulfur for antibiotic formation. Methionine was found to neither repress nor inhibit cysteine metabolism.     

Production of cephalosporin C using crude glycerol in fed-batch culture of <Emphasis Type="Italic">Acremonium chrysogenum</Emphasis> M35

In this study, cephalosporin C production by Acremonium chrysogenum M35 cultured with crude glycerol instead of rice oil and methionine was investigated. The addition of crude glycerol increased cephalosporin C production by 6-fold in shake-flask culture, and also the amount of cysteine. In fed-batch culture without methionine, crude glycerol resulted only in overall improvement in cephalosporin C production (about 700%). In addition, A. chrysogenum M35 became highly differentiated in fed-batch culture with crude glycerol, compared with the differentiation in batch culture. The results presented here suggest that crude glycerol can replace methionine and plant oil as cysteine and carbon sources during cephalosporin C production by A. chrysogenum M35.     

Targeted inactivation of the mecB gene, encoding cystathionine-gamma-lyase, shows that the reverse transsulfuration pathway is required for high-level cephalosporin biosynthesis in Acremonium chrysogenum C10 but not for methionine induction of the cephalosporin genes

Targeted gene disruption efficiency in Acremonium chrysogenum was increased 10-fold by applying the double-marker enrichment technique to this filamentous fungus. Disruption of the mecB gene by the double-marker technique was achieved in 5% of the transformants screened. Mutants T6 and T24, obtained by gene replacement, showed an inactive mecB gene by Southern blot analysis and no cystathionine-gamma-lyase activity. These mutants exhibited lower cephalosporin production than that of the control strain, A. chrysogenum C10, in MDFA medium supplemented with methionine. However, there was no difference in cephalosporin production between parental strain A. chrysogenum C10 and the mutants T6 and T24 in Shen's defined fermentation medium (MDFA) without methionine. These results indicate that the supply of cysteine through the transsulfuration pathway is required for high-level cephalosporin biosynthesis but not for low-level production of this antibiotic in methionine-unsupplemented medium. Therefore, cysteine for cephalosporin biosynthesis in A. chrysogenum derives from the autotrophic (SH(2)) and the reverse transsulfuration pathways. Levels of methionine induction of the cephalosporin biosynthesis gene pcbC were identical in the parental strain and the mecB mutants, indicating that the induction effect is not mediated by cystathionine-gamma-lyase.     

Production of methionine γ- lyase in recombinant Citrobacter freundii bearing the hemoglobin gene

The production of antileukemic enzyme methionine γ-lyase (MGL) in distinctly related bacteria, Citrobacter freundii and in their recombinants expressing the Vitresocilla hemoglobin (VHb) has been studied. This study concerns the potential of Citrobacter freundii expressing the Vitreoscilla hemoglobin gene (vgb) for the methionine γ- liyase production. Methionine γ- liyase production by Citrobacter freundii and its vgb(-) and vgb(+) bearing recombinant strain was studied in shake-flasks under 200 rpm agitation, culture medium and 30 °C in a time-course manner. The vgb(+) and especially the carbon type had a dramatic effect on methionine γ- liyase production. The vgb(+) strain of C. freundii had about 2-fold and 3.1-fold higher levels of MGL than the host and vgb(-) strain, respectively.     

Biosynthesis of Cephalosporin C: I. Factors Affecting the Fermentation

A series of complex and synthetic media have been developed that are suitable for the production of cephalosporin C and cephalosporin N by a mutant strain of Cephalosporium (C.M.I. 49,137). dl-Methionine increased the yield of both antibiotics, with more effect on cephalosporin N. l-Cystine had a greater enhancing effect on formation of cephalosporin C than on formation of cephalosporin N in synthetic media; serine increased yields of cephalosporin C under certain conditions. Disaccharides or polysaccharides appeared to be the best source for carbohydrates. No evidence was found for precursor action such as is found in penicillin fermentations. The ability of resting cells to produce antibiotic was demonstrated.     

Effect of norleucine on mycelial fragmentation in Cephalosporium acremonium.

DL-Norleucine, which is known to replace methionine for stimulation of cephalosporin C formation, also mimics methionine's effect on arthrospore formation. Thus, hyphal fragmentation, like antibiotic biosynthesis, is divorced from a sulfur donation role.     

Synthesis of cephalosporin C by a methionine analogue resistant mutant of Cephalosporium acremonium

Summary DL-seleno-methionine resistant mutants of Cephalosporium acremonium were isolated which have an enhanced capacity to utilized sulfate for the synthesis of cephalosporin C. Of these mutants, one designated as SMR-I3 produced three-fold more cephalosporin C from sulfate than its parent CW19. Mutant SMR-I3 required less dl-methionine for maximal synthesis of cephalosporin C, but an excess of dl-methionine inhibited the synthesis of the antibiotic. Furthermore, the mutant accumulated excessive methionine in the amino acid pool and possessed superior activity for sulfate uptake. These observations indicate that in the mutant SMR-I3, the biosynthesis of methionine from sulfate is very active and excess methionine becomes available for the synthesis of cephalosporin C.     

Correlation of cephalosporin C synthesis and proteolytic enzymes in a differentiating culture of Acremonium chrysogenum (Cephalosporum acremonium) mutants

The effect of the growth conditions and composition of the nutrient medium on the synthesis of cephalosporin C, alkaline exoproteases and cell differentiation was studied in various strains of Acremonium chrysogenum. It was observed that the changes in the above processes occurred simultaneously and depended on the aeration rate, temperature, illumination level and concentrations of methionine and soybean meal. Close correlation between the synthesis of alkaline exoproteases, cephalosporin C and formation of secondary structures in the strains of A. chrysogenum was shown.     

Assay of cysteine conjugate β-lyase activity with S-(2-benzothiazolyl)cysteine as the substrate

Cysteine conjugate β-lyases convert S-substituted cysteine conjugates to pyruvate, ammonia, and thiols. A simple assay for cysteine conjugate β-lyase activity was developed with S-(2-benzothiazolyl)cysteine as the substrate. The production of 2-mercaptobenzothiazole was measured by its intense absorbance at 321 nm in trichloroacetic acid-quenched reaction mixtures. The formation of 2-mercaptobenzothiazole was directly proportional to protein concentrations of 0.17 to 1.2 mg/ml with rat liver cytosol as the source of β-lyase activity. Production of 2-mercaptobenzothiazole was stoichiometric with pyruvate and was increased by addition of pyridoxal phosphate only at reaction times of 5 min or longer. The simplicity, sensitivity, and specificity of this procedure offer significant advantages over other methods for the assay of cysteine conjugate β-lyase activity.     

A chemically defined medium for cephalosporin C production by Paecilomyces persicinus

A chemically defined medium was developed for the biosynthesis of cephalosporin C by Paecilomyces persicinus Nicot strain P-10. Glucose served as the major carbon source and nitrogen was supplied by five amino acids, l-arginine, l-aspartic acid, l-glutamic acid, glycine and dl-methionine. Omission of any of the first four diminished or prevented production of cephalosporin C; omission of methionine did not. Methionine is not critical for the production of cephalosporin C in this defined medium. Production of the antibiotic was affected by the concentrations of inorganic salts employed. Biotin was required for growth and cephalosporin C synthesis. The addition of l-lysine precursors to the medium did not influence cephalosporin C levels and l-lysine itself inhibited antibiotic production. Known precursors of -lactam antibiotics as well as oleic acid did not affect biosynthesis of cephalosporin C. Chemical changes occurring in the defined medium revealed that glucose was efficiently utilized after 96 hours incubation whereas total soluble nitrogen levels increased following an initial sharp decrease. Mycelial weight and cephalosporin C production were both maximal after 96 hours incubation. Mycelial nitrogen was highest after 48 hours incubation whereas mycelial lipid levels were greatest after 72 hours.     

Expression of cystathionine β-synthase and cystathionine γ-lyase in human pregnant myometrium and their roles in the control of uterine contractility

Background

Human uterus undergoes distinct molecular and functional changes during pregnancy and parturition. Hydrogen sulfide (H₂S) has recently been shown to play a key role in the control of smooth muscle tension. The role of endogenous H₂S produced locally in the control of uterine contractility during labour is unknown.

Methodology/Principal Findings

Human myometrium biopsies were obtained from pregnant women undergoing cesarean section at term. Immunohistochemistry analysis showed that cystathionine-γ-lyase (CSE) and cystathionine-β-synthetase (CBS), the principle enzymes responsible for H₂S generation, were mainly localized to smooth muscle cells of human pregnant myometrium. The mRNA and protein expression of CBS as well as H₂S production rate were down-regulated in labouring tissues compared to nonlabouring tissues. Cumulative administration of L-cysteine (10⁻⁷–10⁻² mol/L), a precursor of H₂S, caused a dose-dependent decrease in the amplitude of spontaneous contractions in nonlabouring and labouring myometrium strips. L-cysteine at high concentration (10⁻³ mol/L) increased the frequency of spontaneous contractions and induced tonic contraction. These effects of L-cysteine were blocked by the inhibitors of CBS and CSE. Pre-treatment of myometrium strips with glibenclamide, an inhibitor of ATP-sensitive potassium (K_ATP) channels, abolished the inhibitory effect of L-cysteine on spontaneous contraction amplitude. The effects of L-cysteine on the amplitude of spontaneous contractions and baseline muscle tone were less potent in labouring tissues than that in nonlabouring strips.

Conclusion/Significance

H₂S generated by CSE and CBS locally exerts dual effects on the contractility of pregnant myometrium. Expression of H₂S synthetic enzymes is down-regulated during labour, suggesting that H₂S is one of the factors involved in the transition of pregnant uterus from quiescence to contractile state after onset of parturition.     

Dissimilation of methionine in cell suspension cultures from Catharanthus roseus L.

Plant cell suspension cultures from Catharanthus roseus were investigated for their capability to dissimilate methionine or its analogs in order to reutilize the sulphane group for cysteine biosynthesis. Three steps have been described as prerequisites of this process: (a) oxidative degradation by the amino-acid oxidase of methionine giving rise to methanethiol production; (b) demethylation by methyltransferases leading to homocysteine and S-methylmethionine (c) replacement of the homocysteine sulphane sulphur by alkylthiol yielding methionine and free hydrogen sulphide. A reversal of the cystathionine pathway as a source of cysteine was ruled out because the cells lack cystathionine γ-lyase. The absence of this enzyme is compensated by the S-alkyl exchange of homocysteine with methylmercaptan. Hydrogen sulphide thus liberated is used for de novo synthesis of cysteine. The complete pathway can be catalyzed by the constitutive set of enzymes present in the higher plant.     

Role of Cystathionine β-Lyase in Catabolism of Amino Acids to Sulfur Volatiles by Genetic Variants of Lactobacillus helveticus CNRZ 32

Catabolism of sulfur-containing amino acids plays an important role in the development of cheese flavor. During ripening, cystathionine β-lyase (CBL) is believed to contribute to the formation of volatile sulfur compounds (VSCs) such as methanethiol and dimethyl disulfide. However, the role of CBL in the generation of VSCs from the catabolism of specific sulfur-containing amino acids is not well characterized. The objective of this study was to investigate the role of CBL in VSC formation by Lactobacillus helveticus CNRZ 32 using genetic variants of L. helveticus CNRZ 32 including the CBL-null mutant, complementation of the CBL-null mutant, and the CBL overexpression mutant. The formation of VSCs from methionine, cystathionine, and cysteine was determined in a model system using gas chromatography-mass spectrometry with solid-phase microextraction. With methionine as a substrate, CBL overexpression resulted in higher VSC production than that of wild-type L. helveticus CNRZ 32 or the CBL-null mutant. However, there were no differences in VSC production between the wild type and the CBL-null mutant. With cystathionine, methanethiol production was detected from the CBL overexpression variant and complementation of the CBL-null mutant, implying that CBL may be involved in the conversion of cystathionine to methanethiol. With cysteine, no differences in VSC formation were observed between the wild type and genetic variants, indicating that CBL does not contribute to the conversion of cysteine.     

Differential Effects of Cystathionine-γ-lyase-Dependent Vasodilatory H(2)S in Periadventitial Vasoregulation of Rat and Mouse Aortas

Background

Hydrogen sulfide (H₂S) is a potent vasodilator. However, the complex mechanisms of vasoregulation by H₂S are not fully understood. We tested the hypotheses that (1) H₂S exerts vasodilatory effects by opening KCNQ-type voltage-dependent (K_v) K⁺ channels and (2) that H₂S-producing cystathionine-γ-lyase (CSE) in perivascular adipose tissue plays a major role in this pathway.

Methodology/Principal Findings

Wire myography of rat and mouse aortas was used. NaHS and 5-(4-hydroxyphenyl)-3H-1,2-dithiole-3-thione (ADTOH) were used as H₂S donors. KCNQ-type K_v channels were blocked by XE991. 4-Propargylglycine (PPG) and ß-cyano-l-alanine (BCA), or 2-(aminooxy)-acetic acid (AOAA) were used as inhibitors of CSE or cystathionine-ß-synthase (CBS), respectively. NaHS and ADTOH produced strong vasorelaxation in rat and mouse aortas, which were abolished by KCNQ channel inhibition with XE991. Perivascular adipose tissue (PVAT) exerted an anticontractile effect in these arteries. CSE inhibition by PPG and BCA reduced this effect in aortas from rats but not from mice. CBS inhibition with AOAA did not inhibit the anticontractile effects of PVAT. XE991, however, almost completely suppressed the anticontractile effects of PVAT in both species. Exogenous l-cysteine, substrate for the endogenous production of H₂S, induced vasorelaxation only at concentrations >5 mmol/l, an effect unchanged by CSE inhibition.

Conclusions/Signficance

Our results demonstrate potent vasorelaxant effects of H₂S donors in large arteries of both rats and mice, in which XE991-sensitive KCNQ-type channel opening play a pivotal role. CSE-H₂S seems to modulate the effect of adipocyte-derived relaxing factor in rat but not in mouse aorta. The present study provides novel insight into the interaction of CSE-H₂S and perivascular adipose tissue. Furthermore, with additional technical advances, a future clinical approach targeting vascular H₂S/KCNQ pathways to influence states of vascular dysfunction may be possible.     

Endogenous Inhibitors for Pollen Germination and Pollen Tube Elongation in Pinus densiflora SIEB,et Zucc.

Sulfur metabolism in Cephalosporium acremonium was investigated using a mutant, 8650⁺/ OAH^?/SeMe^R, which could not convert cysteine or inorganic sulfur to methionine. The production of cephalosporin by the mutant depended on the amount of S-sulfocysteine in a chemically defined medium supplemented with a low level of methionine sufficient to support optimal growth. S-Sulfocysteine was detected in an extract of cells grown in the presence of sodium thiosulfate and l-serine. Furthermore, an NADPH-linked reduction of S-sulfocysteine to cysteine was demonstrated in a cell-free extract. These facts suggest that S-sulfocysteine is a direct precursor in cysteine biosynthesis in C. acremonium and an alternative pathway involving the compound is one of the most important ones in cephalosporin C production by this fungus.