Thermal inactivation of Listeria monocytogenes during a process simulating temperatures achieved during microwave heating

Conventional heating was used to expose cells of Listeria monocytogenes, either in broth or in situ on chicken skin, to the mean times and temperatures that are achieved during a 28 min period of microwave cooking of a whole chicken. Heating L. monocytogenes by this method in culture broth resulted in a reduction in viable cell numbers by a factor of greater than 10(6) upon reaching 70 degrees C. Simulated microwave cooking of L. monocytogenes in situ, on chicken skin, resulted in more variability in the numbers of survivors. Heating for the full cook time of 28 min, however, resulted in a mean measured temperature of 85 degrees C and no surviving listerias were detected. This indicated a reduction in viable numbers of greater than 10(6). To reduce temperature variation, cells were heated on skin in a submerged system in which exposure to 70 degrees C for 2 min resulted in a reduction in viable cell numbers of all strains of listerias tested of between 10(6) and 10(8). These results show that when a temperature of 70 degrees C is reached and maintained for at least 2 min throughout a food there is a substantial reduction in the numbers of L. monocytogenes. The survival of this organism during microwave heating when temperatures of over 70 degrees C are reported is probably due to uneven heating by microwave ovens resulting in the presence of cold spots in the product. The heat resistance of L. monocytogenes is comparable with that of many other non-sporing mesophilic bacteria.     

Effect of growth temperature on virulence of strains of Listeria monocytogenes in the mouse: evidence for a dose dependence

Growth of Listeria monocytogenes at 4°C significantly increased its virulence for mice by the intravenous route and the effect was dose-dependent. Virulence was apparent only at a dose of about or above 10⁴ viable listerias. At slightly lower doses of about 10³, no such effect was observed. Growth at 4°C did not increase the virulence of the strains for mice by oral-gastric challenge when given at doses of approximately 10¹⁰.     

Thermal inactivation of Listeria monocytogenes during rapid and slow heating in sous vide cooked beef

T.B. HANSEN AND S. KNØCHEL. 1996. Heating at slowly rising temperatures is suspected to enhance thermotolerance in Listeria monocytogenes and, since anaerobic environments have been shown to facilitate resuscitation of heat-injured cells of this micro-organism, concern may arise about the possibility of L. monocytogenes surviving in minimally preserved products. The effect of rapid (> 10°C min^-1) and slow (0.3 and 0.6°C min^-1) heating on survival of L. monocytogenes in sous vide cooked beef was therefore examined at mild processing temperatures of 56, 60 and 64°C. No statistically significant difference ( P = 0.70) was observed between the tested heating regimes. Since the average pH of beef was low (5.6), and little or no effect was observed, a pH-dependency of heat shock-induced thermotolerance in L. monocytogenes is suggested to account for this result.     

Combining heat treatment and subsequent incubation temperature to prevent growth from spores of non-proteolytic Clostridium botulinum

Refrigerated processed foods of extended durability rely on a mild heat treatment combined with refrigerated storage to ensure microbiological safety and quality. The principal microbiological safety risk in foods of this type is non-proteolytic Clostridium botulinum. In this article the combined effect of mild heat treatment and refrigerated storage on the time to growth and probability of growth from spores of non-proteolytic Cl. botulinum is described. Spores of non-proteolytic Cl. botulinum (two strains each of type B, E and F) were heated at 90°C for between 0 and 60 min and subsequently incubated at 5°, 10° or 30°C in PYGS broth in the presence or absence of lysozyme. The number of spores that resulted in turbidity depended on the combination of heat treatment, incubation time and incubation temperature they received. Heating at 90°C for 1 or more min ensured a 10⁶ reduction when spores were subsequently incubated at 5°C for up to 23 weeks. Heating at 90°C for 60 min ensured a 10⁶ reduction over 23 weeks when subsequent incubation was at 10°C in the presence of added lysozyme. The same treatment did not reduce the spore population by 10⁶ when subsequent incubation was at 30°C.     

Factors affecting the growth of Listeria monocytogenes on minimally processed fresh endive

The influence of various factors on the fate of Listeria monocytogenes on cut leaves of broad-leaved endive has been studied. Factors considered were temperature, characteristics of the leaves (age, quantity and quality of the epiphytic microflora) and characteristics of the L. monocytogenes inoculum (concentration, strain). The increases in numbers of L. monocytogenes were lower than those of the aerobic mesophilic microflora at 3°, 6°, 10° and 20°C. Doubling times of the populations of L. monocytogenes were in the same order of magnitude as those of aerobic bacteria at 10° and 20°C, but longer at 3° and 6°C. There were positive significant correlations between growth of L. monocytogenes and populations of aerobic bacteria, and between growth of L. monocytogenes and extent of spoilage on the leaves.
Of 225 bacteria isolated from the leaves, 84% were identified as fluorescent pseudomonads; there was no difference in the species isolated from leaves that showed a low growth of L. monocytogenes and leaves that showed a high growth of L. monocytogenes. Populations of L. monocytogenes increased faster during the first 2 and 4 d of storage at 10°C on leaves inoculated with 10–10³ cfu g^-1 than on leaves inoculated with about 10⁵ cfu g^-1, but the population reached after 7 d was lower. The behaviour of L. monocytogenes was similar among the three strains tested.     

Effect of heat treatment on Listeria monocytogenes and Gram-negative bacteria in sheep, cow and goat milks

Sheep milk, compared with cow and goat milk, had a protective effect on Gram-negative bacteria and Listeria spp. heated at 65°C in a test-tube method. This effect was not solely due to fat content as cow milk artificially reconstituted to 10% homologous fat was not as protective. Listeria monocytogenes in whole sheep, cow and goat milks at an inoculum level of 1 times 10⁶ cfu ml^-1 was heated at 68°C for 15 s in the plate pasteurizer and survival was only detected in whole sheep milk after heating. Whole sheep, cow and goat milks containing high levels of L. monocytogenes (1 times 10⁶ cfu ml^-1) could not survive the current HTST plate pasteurization protocol.     

Isolation and characterization of nisin-producing Lactococcus lactis subsp. lactis from bean-sprouts

Bacterial isolates from bean-sprouts were screened for anti- Listeria monocytogenes bacteriocins using a well diffusion method. Thirty-four of 72 isolates inhibited the growth of L.monocytogenes Scott A. One, HPB 1688, which had the biggest inhibition zone against L.monocytogenes Scott A, was selected for subsequent analysis. Both ribotyping and DNAsequencing of 16S ribosomal RNA gene demonstrated that the isolate was Lactococcus lactis subsp. lactis . Polymerase chain reaction and nucleotide sequencing revealed that thegenomic DNA of the bean-sprout isolates contained a nisin Z structural gene. In MRS broth,bean-sprout isolate HPB 1688 survived at 3–4·5°C for at least 20 d, grew at 4°Cand produced anti-listerial compoundsat 5°C. When co-cultured with L. monocytogenes in MRS broth, the isolate inhibited thegrowth of L. monocytogenes at 4°C after 14d and at 10°C after 2 d. When co-inoculatedwith 10²cells g⁻¹ of L.monocytogenes on fresh-cut ready-to-eat Caesar salad, L. lactis subsp. lactis (10⁸cells g⁻¹) was able to reduce the number of L. monocytogenes by 1–1·4 logs after storage for 10 d at 7° and 10°C. A bacteriocin-producing Enterococcusfaecium was also able to reduce the numbers of L. monocytogenes onCaesar salad, butdid not act synergistically when co-inoculated with L. lactis subsp. lactis .     

The use of the bacteriocin, nisin, as a preservative in ricotta-type cheeses to control the food-borne pathogen Listeria monocytogenes

The efficacy of nisin to control the food-borne pathogen Listeria monocytogenes in ricotta-type cheeses over long storage (70 d) at 6–8°C was determined. Cheeses were prepared from unpasteurized milk by direct acidification with acetic acid (final pH 5·9) and/or calcium chloride addition during heat treatment. Nisin was added in the commercial form of Nisaplin^® pre-production to the milk. Each batch of cheese was inoculated with 10²–10³ cfu g⁻¹ of a five-strain cocktail of L. monocytogenes before storage. Shelf-life analysis demonstrated that incorporation of nisin at a level of 2·5 mg l⁻¹ could effectively inhibit the growth of L. monocytogenes for a period of 8 weeks or more (dependent on cheese type). Cheese made without the addition of nisin contained unsafe levels of the organism within 1–2 weeks of incubation. Measurement of initial and residual nisin indicated a high level of retention over the 10-week incubation period at 6–8°C, with only 10–32% nisin loss.     

The lethal effect of carrot on Listeria species

When shredded or sliced carrots were inoculated with Listeria monocytogenes the number of viable listerias decreased rapidly. On carrot slices stored at 8°C there was a decrease after 3 d followed by an increase, after 7 d, to numbers similar to those present initially. The numbers of spoilage micro-organisms increased throughout storage at 8°C. Carrots macerated in a Stomacher Lab Blender also showed an antilisterial activity which resulted in a decrease in number of viable bacteria and in sublethal damage. The effect was shown by five carrot cultivars and acted on nine strains of L. monocytogenes and single strains of L. innocua, L. ivanovii, L. seeligeri, L. welshimeri . This antilisterial effect was heat-labile, was inactivated after a few hours at 4°C or at 30°C and was active over the pH range 5.8 to 7.0. Maceration of carrots in an Atomix blender for 1 min or in liquid nitrogen destroyed the antilisterial activity.     

Vegetable juice aids the recovery of heated spores of non-proteolytic Clostridium botulinum

Heating spores of non-proteolytic Clostridium botulinum at 85C for 2 min followed by plating on a standard laboratory medium reduced the count of viable spores by a factor of greater than 10⁴. A similar result was obtained when the plating medium was supplemented with juice from courgette, carrot or mung bean sprout. When plating was on media supplemented with hen egg white lysozyme or juice from turnip, swede, flat bean, cabbage or potato, heating at 85C for 10 min did not reduce the viable count by a factor of 10⁴. Thus these vegetable juices increased the measured heat resistance of spores of non-proteolytic Cl. botulinum . These findings are relevant to the safety of minimally processed (e.g. sous-vide ) foods.     

Effect of heat treatments on the microbial load of 'nono'

Fresh nono samples were subjected to temperature treatments of 55, 60, 65 and 70°C at holding times of 5, 10, 20 and 30 min. Treatment at 65°C for 30 min was most effective in leaving the least number of viable bacteria (1·97 times 10³ pL 0·04) without affecting the organoleptic quality of the product. Some micro-organisms isolated after the pasteurization treatments were Lactobacillus bulgaricus, L. plantarum, L. helveticus and Streptococcus cremoris while coliform bacteria and fungi did not survive the pasteurization treatments.     

Effect of chill and freezing temperatures on survival of Vibrio parahaemolyticus inoculated in homogenates of oyster meat

Survival of Vibrio parahaemolyticus was determined in oyster meat homogenates at various temperatures. (4°C, 0°C, -18°C and -24°C) and bacterial levels (10², 10⁴, 10⁵ and 10⁷ ml^-1). In all cases, the numbers of V. parahaemolyticus were a logarithmic function of log time. This study indicates that high numbers of V. parahaemolyticus can be inactivated at low temperatures. The time of total inactivation depends on the initial number of micro-organisms and incubation temperature. It is possible to use this information to determine the storage time necessary to reduce V. parahaemolyticus hazards in fish.     

Thermophilic sulfate-reducing bacteria in cold marine sediment

Abstract Sulfate reduction was measured with the ³⁵SO₄²⁻ -tracer technique in slurries of sediment from Aarhus Bay, Denmark, where seasonal temperatures range from 0° to 15°C. The incubations were made at temperatures from 0°C to 80°C in temperature increments of 2°C to search for presence of psychrophilic, mesophilic and thermophilic sulfate-reducing bacteria. Detectable activity was initially only in the mesophilic range, but after a lag phase sulfate reduction by thermophilic sulfate-reducing bacteria were observed. No distinct activity of psychrophilic sulfate-reducing bacteria was detected. Time course experiments showed constant sulfate reduction rates at 4°C and 30°C, whereas the activity at 60°C increased exponentially after a lag period of one day. Thermophilic, endospore-forming sulfate-reducing bacteria, designated strain P60, were isolated and characterized as D esulfotomaculum kuznetsovii . The temperature response of growth and respiration of strain P60 agreed well with the measured sulfate reduction at 50°–70°C. Bacteria similar to strain P60 could thus be responsible for the measured thermophilic activity. The viable population of thermophilic sulfate-reducing bacteria and the density of their spores was determined in most probable number (MPN) dilutions. The density was 2.8·10⁴ cells·.g⁻¹ fresh sediment, and the enumerations suggested that they were all present as spores. This result agrees well with the observed lag period in sulfate reduction above 50°C. No environment with temperatures supporting the growth of these thermophiles is known in the region around Aarhus Bay.     

Incidence of pathogenic bacteria in raw milk in Ireland

Raw milk from 70 farms was sampled over 13 months for salmonellas, listerias, Escherichia coli, Staphylococcus aureus and mastitic streptococci; total bacterial counts (TBC), coliforms and somatic cells were also counted. TBC ≤30000/ml were obtained in 63% of samples. High count milks were found mainly during the winter months: 13% of samples had > 10⁴ mastitis pathogens/ml of milk. The mean somatic cell count varied from 4.0 × 10⁵ to 8.0 × 10⁵/ml throughout the year with highest counts during the late lactation period. Coliforms were present in all samples, but 65–71% of samples had < 100 coliforms/ml. Up to 60% of supplies had ≤10 E. coli /ml. One of the 589 samples tested (0.1%) was positive for salmonellas. Yersinia enterocolitica and Y. enterocolitica -like organisms were isolated from 39% of samples with up to 68% of samples positive at some sampling periods. A total of 222 strains of yersinias were isolated; Y. enterocolitica (59%) was the most common strain followed by Y. fredriksenii (35%), Y. kristensenii (1.0%), Y. intermedia (4.5%) and Y. aldovae (0.5%). Listerias were isolated from 8.3% of samples tested; 4.9% were Listeria monocytogenes and 3.4% were L. innocua. There was a significant rise in the isolation rate between December and April from a base line of 0–5% during the spring and summer to 35–37% during the winter months while the cows were indoors. Of 66 silage samples tested from the farms involved in the survey 9% of samples were positive for listerias; 3% of these were L. monocytogenes and 6% were L. innocua. Only half of the farms feeding contaminated silage produced milk containing listerias.     

The effect of slurry storage and anaerobic digestion on survival of pathogenic bacteria

The decline in viable numbers of Salmonella typhimurium, Yersinia enterocolitica and Listeria monocytogenes in beef cattle slurry is temperature-dependent; they decline more rapidly at 17°C than at 4°C. Mesophilic anaerobic digestion caused an initial rapid decline in the viable numbers of Escherichia coli, Salm. typhimurium, Y. enterocolitica and L. monocytogenes. This was followed by a period in which the viable numbers were not reduced by 90%. The T₉₀ values of E. coli, Salm. typhimurium and Y. enterocolitica ranged from 0.7 to 0.9 d during batch digestion and 1.1 to 2.5 d during semi-continuous digestion. Listeria monocytogenes had a significantly higher mean T₉₀ value during semi-continuous digestion (35.7 d) than batch digestion (12.3 d). Anaerobic digestion had little effect in reducing the viable numbers of Campylobacter jejuni.     

Listeria monocytogenes isolation from human faecal specimens: experiments with the selective media, PALCAM and L-PALCAMY

The selective media PALCAM and L-PALCAMY were evaluated for their potential ability to detect Listeria monocytogenes in faeces. Recovery on PALCAM was almost total, and similar at 30°C and 35°C with or without CO₂ incubation. Warm enrichment in L-PALCAMY was necessary in order to detect low numbers (<10²/ml faeces). Faeces in excess of 0.25 ml/10 ml L-PALCAMY was inhibitory. The results point to L-PALCAMY and PALCAM as an epidemiological tool.     

Occurrence and Thermoresistance of Spores of Psychrophilic and Psychrotrophic Aerobic Sporeformers in Soil and Foods

Spores of psychrotrophic (able to grow at 5°C) aerobic sporeformers occurred in soil in high numbers (2 × 10³-5 × 10⁶/g), whereas psychrophilic (able to grow at 0°C) spores were present at significantly lower levels (500–10⁵/g). Psychrotrophic spores were absent in herbs and spices: in pasteurized meals prepared industrially their numbers varied from <10 to 1000/g. For spores harvested from Trypticase Soy Agar (TSA), the heat resistance of the cold-tolerant sporeformers was low with D _90°C-values from 1–11 min. The recovery of heated psychrophilic spores on this medium at 5°C was equal to their recovery at 20°C. However, the recovery of heated psychrotrophic spores was lower at 5°C than at 20°C, whereas unheated spores gave the same counts at both temperatures. The heat resistance of naturally occurring spores of cold-tolerant sporeformers washed from soil was comparable with the resistance of spores formed on TSA.     

Toxicity of crude extracellular products of Aeromonas hydrophila in tilapia, Tilapianilotica

Extracellular products (ECP) secreted from Aeromonas hydrophila with haemolytic andproteolytic activity were studied with respect to temperature and time of incubation as well as thelethal toxicity on tilapia, Tilapia nilotica . The highest production of the haemolysin productwas achieved when Aer. hydrophila was grown at 35°C for 30 h. Tilapia erythrocytewas found to be more susceptible than sheep erythrocyte for determining the haemolytic activity.The haemolytic activity against tilapia erythrocyte was completely inactivated after heating theECP at 60°C for 10 min or 55°C for 15 min. The proteolytic activity was maximized whenthe bacterium was grown at 30°C for 36 h. Complete inactivation of the protease enzyme wasperformed after heating the ECP at 80°C for 10 min or 70°C for 15 min. Aeromonashydrophila was found to produce haemolytic and proteolytic exotoxin lethal to tilapia (LD₅₀ 2·1 × 10⁴ cell/fish), as well as heat stable unknown virulent factors thatwere responsible for 20% mortality. The lethality of ECP was decreased by heating andcompletely inactivated by boiling at 100°C for 10 min.     

Nisin induces changes in membrane fatty acid composition of Listeria monocytogenes nisin-resistant strains at 10°C and 30°C

Listeria monocytogenes isolates resistant to 10⁵ IU ml^-1 nisin were obtained at 30°C (NR30) and at 10°C (NR10). Nisin prolonged the lag phase of isolate NR30 at 10°C. Isolates NR30 and NR10 did not produce a nisinase. Protoplasts of isolate NR30 were unaffected by exposure to nisin. The fatty acid composition from the wild-type strain and NR isolates was determined. As expected, temperature-induced differences in the C15/C17 fatty acid ratios were found. Growth of the NR strains in the presence of nisin resulted in significantly different C15/C17 ratios and a significant increase in the percentage of C16:0, C16: 1, C18:0 and C18: 1 fatty acids at 10°C and 30°C. Both the NR10 and NR30 isolates had similar growth rates at low temperatures, but these were slower than the wild-type strain. These results indicate that 'nisin resistance'is an environmentally defined phenotype and that nisin induces changes in the fatty acid composition of the membrane in L. monocytogenes nisin-resistant isolates regardless of the growth temperature.     

Moist-heat disinfection of pathogenic Acanthamoeba cysts

The effect of moist-heat in the disinfection of pathogenic Acanthamoeba cysts was investigated. Temperatures of 56°C or 60°C were not effective in killing cysts of A. polyphaga even after a contact time of 60 min, A 4 log reduction in viability was achieved within 15 min at 65°C and 2 min at 70°C giving decimal reduction rates (D-values) of 3·75 min and 30 s respectively. The ability of a commercial moist-heat contact lens disinfection unit to kill 1 times 10⁵ cysts of Acanthamoeba isolated from contact lens storage cases was also shown. Holding temperatures inside the cases of 65°C for 5·5 min and 70°C (the maximum temperature obtained) for 1 min were recorded during the disinfection cycle.