Fetal calf serum-free culture of Chinese hamster ovary cells employing fish serum

The effects of fish serum on cell growth and human granulocyte-macrophage colony-stimulating factor (hGM-CSF) production in an adhesion culture of Chinese hamster ovary (CHO) cells DR1000L4N were investigated and compared with those of fetal calf serum (FCS). Although fish serum did not stimulate the initial adhesion of CHO cells to culture dishes, it prompted cell growth after cell adhesion with FCS for 24 h. The cell density in the fish serum medium reached 75% that in the FCS medium. Fish serum promoted cell adhesion to and cell growth on collagen-coated dishes. The cell-specific production rate of hGM-CSF in the fish serum medium on collagen-coated dishes was almost the same as that in the FCS medium.     

Stability enhancement of hGM-CSF in transgenic<Emphasis Type="Italic">Nicotiana tabacum</Emphasis> suspension cell cultures

Proteolytic enzymes existing in plant cell cultured media are the major reason for the loss of secreted human granulocyte-macrophage colony-stimulating factor (hGM-CSF). The addition of pepstatin, aprotinin and PMSF relatively decreased the proteolytic degradation of hGM-CSF in a conditioned medium, but sufficient prevention against the proteolytic activity could not be obtained with chemical protease inhibitors. Gelatin, as a competitive substrate for protease, showed a stabilizing effect in a conditioned medium. Compared to the initial hGM-CSF concentration in a conditioned medium, with 10 g/L of gelatin, 68% of the hGM-CSF remained after 5 days. In a cell culture experiment, 5 g/L of gelatin significantly stimulated the hGM-CSF production and accumulation in culture media, with no growth inhibition. Compared to the controls (4.72 μg/L), the extracellular hGM-CSF level could be increased to 39.78 μg/L with the addition of 5 g/L of gelatin.     

Design of serum-free medium for suspension culture of CHO cells on the basis of general commercial media

The design of serum-free media for suspension culture of genetically engineered Chinese hamster ovary (CHO) cells using general commercial media as a basis was investigated. Subcultivation using a commercial serum-free medium containing insulin-like growth factor (IGF)-1 with or without FCS necessitated additives other than IGF-1 to compensate for the lack of FCS and improve cell growth. Suspension culture with media containing several combinations of growth factors suggested the effectiveness of addition of both IGF-1 and the lipid signaling molecule lysophosphatidic acid (LPA) for promoting cell growth. Subcultivation of CHO cells in suspension culture using the commercial serum-free medium EX-CELL™302, which contained an IGF-1 analog, supplemented with LPA resulted in gradually increasing specific growth rate comparable to the serum-containing medium and in almost the same high antibody production regardless of the number of generations. The culture with EX-CELL™302 supplemented with LPA in a jar fermentor with pH control at 6.9 showed an apparently higher cell growth rate than the cultures without pH control and with pH control at 6.8. The cell growth in the medium supplemented with aurintricarboxylic acid (ATA), which was much cheaper than IGF-1, in combination with LPA was synergistically promoted similarly to that in the medium supplemented with IGF-1 and LPA. In conclusion, the serum-free medium designed on the basis of general commercial media could support the growth of CHO cells and antibody production comparable to serum-containing medium in suspension culture. Moreover, the possibility of cost reduction by the substitution of IGF-1 with ATA was also shown.     

Requirement of conditioned medium or a high concentration of serum for anchorage-independent growth of adenovirus type 12 E1a-transformed rat cells (HY1)

Adenovirus type 12 (Ad12) Ela-transformed rat cells (HY1) grew in methocel medium containing 9% fetal calf serum (FCS), but the frequency of colony formation was very low (the order of 10(-4)). The addition of conditioned medium or a high concentration of serum (20% FCS) to the methocel medium accelerated colony formation, and plating efficiency increased 10- to 100-fold. In contrast, in stationary culture, HY1 cells grew well even in 1%-FCS medium. These results indicate that HY1 cells require high concentrations of growth factors for anchorage-independent growth. The effects of conditioned medium or FCS also were demonstrated in several transformed cell lines induced by transfection of combined sets of Ad12-transforming genes (E1a, E1b and E4). These growth behaviors suggest that the first step in cell transformation with adenovirus 12 is the acquisition of responsiveness to growth factors in methocel culture, which must be the function of the Ad12-E1a gene products. The function of the other two Ad12-transforming genes was discussed.     

Differential response of cultured rabbit articular chondrocytes (RAC) to transforming growth factor beta (TGF-beta)-evidence for a role of serum factors

We show that addition of TGF-beta (0.01-10 ng/ml) to proliferating rabbit articular chondrocytes in presence of low level of fetal calf serum (FCS, 2%) results in a sustained decrease of cell number and DNA synthesis up to 72 h. In contrast, incubation with high serum concentration (10% FCS) induces a transient increase of cell number after 48 h without elevation of DNA synthesis. Moreover, when the factor is added in 10% FCS-containing medium, a differential effect is observed at 48 h (either increase or decrease of cell number) depending on the serum level (2 or 10%) present between 24 and 48 h. Recruitment of cells in late S-phase occurred under TGF-beta-treatment in both 2 and 10% FCS. These arrested cells may then be released by further exposure to 10% FCS-containing medium. The data show that factor(s) from the serum modulate(s) the action of TGF-beta on chondrocyte proliferation. Addition of epidermal growth factor (EGF) to the cultures in presence of 2% FCS mimicks the effects observed with 10% serum, suggesting that the serum component(s) involved in the mechanism could be of EGF type.     

Concomitant up-regulation of insulin binding and elevated heat sensitivity in serum depleted CHO cells

When HA-1 CHO cells were cultured in media with a range of fetal calf serum (FCS) concentrations, they became increasingly heat sensitive at low (5%) serum levels. Heat sensitization occurred concomitantly with increased insulin binding capacity. Insulin binding capacity also became more heat sensitive. Thermotolerance induced by a mild treatment (10 min/45 degrees C) 12 hr prior to assay, caused marked heat resistance expressed both as cell survival or insulin binding and abolished differences in sensitivity between the serum adapted cell lines.     

A factor present in fetal calf serum enhances oncogene-induced transformation of rodent fibroblasts.

Our previous studies indicated that addition of the tumor promoters 12-O-tetradecanoylphorbol-13-acetate (TPA) or teleocidin to Dulbecco modified Eagle medium supplemented with calf serum enhanced T24-induced focus formation in both the murine C3H 10T1/2 and rat 6 embryo fibroblast cell lines. In the present studies we have found that fetal calf serum (FCS) is more potent than 12-O-tetradecanoylphorbol-13-acetate in enhancing T24-induced focus formation, in terms of the number and size of the foci, in both C3H 10T1/2 and rat 6 cells. Time course studies indicate that FCS can exert this enhancing effect when it is added several days after the transfection with T24 DNA. In rat 6 cells, an 11-fold increase in T24-induced focus formation occurred when the transfected cultures were maintained for only 1 day in 5% FCS, starting 4 days after the transfection. Several known growth factors, including epidermal growth factor, transforming growth factors alpha and beta, insulin, and platelet-derived growth factor, did not enhance T24-induced transformation in these cell systems. Fractionation studies indicate that the factor present in FCS has a molecular weight of about 1,300, is not lipid soluble, and is acid, base, and heat stable. These findings suggest that a factor(s) normally present in serum may enhance the emergence of tumor cells in vivo, by acting in concert with an activated oncogene, during the multistage carcinogenic process.     

Differential effects of transforming growth factor-beta and epidermal growth factor on the cell cycle of cultured rabbit articular chondrocytes

We examined the effect of transforming growth factor (TGF-beta) on the proliferative rate and cell cycle of cultured rabbit articular chondrocytes using cell counting, cytofluorometry, and [3H]-thymidine incorporation. In the presence of 2% or 10% FCS (fetal calf serum), TGF-beta at 0.01, 0.1, 1, and 10 ng/ml had an inhibitory effect on cell proliferation after 24 h exposure with a dose dependence only for 2% FCS. Flow cytometric analysis of cell DNA content at that time showed that a high proportion of cells were arrested in late S-phase (SQ or G2Q) in either 2% or 10% FCS-containing medium. In both cases, a disappearance of the cell blockage occurred between 24 and 48 h after TGF-beta addition. However, whereas a stimulation of cell proliferation rate was observed at that time in cultures containing 10% FCS, a dose-dependence inhibition of cell growth was detected, in contrast, for 2% FCS-treated cells. Presence of TGF-beta during the last 24 h was not necessary to release the arrested cells. Furthermore, platelet-poor plasma at 10% produced the same effects as FCS, suggesting that platelet-derived factors, such as platelet-derived growth factor (PDGF), could not be responsible for the release of blocked cells in this case. We compared the effect of TGF-beta to that of epidermal growth factor (EGF), used at an optimal concentration (10 ng/ml). In both slowly growing (2% FCS) and proliferating chondrocytes (10% FCS), EGF caused a significant increase of cell proliferation as early as 24 h. No arrest in late S-phase but an augmentation of the percentage of cells in S- and G2M-phases were observed. When combined, TGF-beta and EGF did not induce synergistic effect on the chondrocyte proliferation, as estimated by cell counting. [3H]-thymidine labeling showed that the factors induced identical maxima of incorporation but the peak occurred earlier for TGF-beta than for EGF (approximately 6 h versus 12 h, respectively). Although both factors induce similar cell-number increases at 48 h in 10% FCS-containing medium, these proliferative effects were due to different actions on the cell cycle. The present study indicates that TGF-beta induces first a recruitment of chondrocytes in noncycling SQ- or G2Q-blocked cells. The, the release of these cells may produce either apparent stimulation of cell proliferation if sufficient levels of an unknown serum factor are present (10% FCS) or an inhibition of growth rate when only reduced amounts of this factor are available (2% FCS).(ABSTRACT TRUNCATED AT 400 WORDS)     

Effect of initial cell density on hybridoma growth, metabolism, and monoclonal antibody production.

A murine hybridoma cell line (167.4G5.3) was cultivated in batch mode with varying inoculum cell densities using IMDM media of varying fetal bovine serum concentrations. It was observed that maximum cell concentrations as well as the amount of monoclonal antibody attainable in batch mode were dependent on the inoculum size. Specifically, cultures with lower inoculum size resulted in lower cell yield and lower antibody concentrations. However, in the range of 10(2) to 10(5) cells per ml, the initial cell density affected the initial growth rate by a factor of only 20%. Furthermore, specific monoclonal antibody production rates were independent of initial cell density and the serum concentration. Glutamine was the limiting nutrient for all the cultures, determining the extent of growth and the amount of antibody produced. Serum was essential for cell growth and cultures with initial cell concentrations up to 10(6) cells per ml could not grow without serum. However, when adapted, the cells could grow in a custom-made serum-free medium containing insulin, transferrin, ethanolamine, and selenium (ITES) supplements. The cells adapted to the ITES medium could grow with an initial growth rate slightly higher than in 1.25% serum and the growth rate showed an initial density dependency-inocula at 10(3) cells per ml grew 30% slower than those at 10(4) or 10(5). This difference in growth rate was decreased to 10% with the addition of conditioned ITES medium. The addition of conditioned media, however, did not improve the cell growth for serum-containing batches.     

Limb bud chondrogenesis in cell culture, with particular reference to serum concentration in the culture medium

When limb bud mesodermal cells of stages 23–24 chick embryos were plated at low cell density (2 × 10⁵ cells/cm²) and cultured in medium containing 10% fetal calf serum (FCS) (serum-rich medium), all cells became fibroblastic and no chondrocyte differentiation occurred in the culture. However, when cells of the same origin were cultured in a medium containing only 0.1% FCS (serum-poor medium), almost all the cells formed aggregates which developed further to form cartilage nodules. The loss of chondrogenic activity in serum-rich medium culture was irreversible: cultivation of the limb bud cells in serum-rich medium for 12 h abolished chondrogenic activity completely and these cells could not resume activity on re-cultivation in serum-poor medium. Calf, horse and chick serum at a concentration of 10% also induced the loss of chondrogenic activity in low cell density culture. Failure of chondrogenesis in serum-rich medium culture seemed to be due to the commitment of bipotential limb bud mesodermal cells to fibroblastic cells rather than to selective detachment of pre-committed chondroblasts.     

Serum- and protein-free media formulations for the Chinese hamster ovary cell line DUKXB11

The production of therapeutic proteins in mammalian cell lines is of outstanding importance. The maintenance of most mammalian cell lines in culture requires the addition of serum to the culture medium. The elimination of serum from mammalian cell culture is desirable since serum is expensive and a source of contaminants, e.g. viruses, mycoplasma or prions. Here we describe the composition of serum- and protein-free media for the Chinese hamster ovary (CHO) cell line DUKXB11. The serum-free formulation supports excellent growth of CHO DUKXB11 cells at low (23cells/cm2) and high (2 x 10(4) cells/cm2) seeding densities characterized by a generation time of 10-12h, and, after addition of 0.2% pluronic F-68, the growth of a recombinant suspension cell line derived from DUKXB11. In addition, this formulation also allowed us to adapt recombinant cell lines expressing various amounts of human antithrombin ATIII (ATIII) to serum-free conditions. Secretion of ATIII was readily observed in the serum-free medium. Minor changes to the serum-free formulation resulted in a protein free formulation that supported growth of CHO DUKXB11 cells, growth of recombinant CHO cells expressing ATIII, and production of ATIII.     

Substitution of transferrin by FeCl3 in the development of a low foetal calf serum concentration medium for KB-26.5 hybridoma cell line

KB-26.5, a murine hybridoma cell line producing an IgG₃ monoclonal antibody used in blood type determination, primarily adapted to grow at 5% foetal calf serum (FCS) concentration has been adapted to grow at 0.5% FCS, maintaining its ability to produce antibodies at the same level. In the final step of adaptation, the addition of insulin, transferrin, ethanolamine and selenium to the media formulation was studied, using factorial assay techniques to check the effect of the different compounds and to optimize their required level for satisfactory growth and antibody secretion. KB-26.5 cells required only 20 g/ml of transferrin to adapt to 0.5% FCS medium. Furthermore, transferrin could be substituted by FeCl₃, at a relatively low level of 2 g/ml. Maximum cell density decreased by 31.5% in spinner flask test, but the antibody titer was maintained, thus the specific productivity increased. However, inoculum size had to be increased three-fold with 0.5% FCS medium in order to assure cell growth.     

Effect of increasing selenite concentrations, vitamin E supplementation and different fetal calf serum content on GPx1 activity in primary cultured rabbit hepatocytes

Primary rabbit hepatocytes from 6 week old female New Zealand White rabbits (3.0 x 10(6) viable hepatocytes per treatment) were incubated for 24 h or 48 h with two basic variants of the selenium and vitamin E free DMEM/F12-HAM nutrition medium containing 2.5% or 10% fetal calf serum (FCS). Selenium and vitamin E concentrations of the media were varied by the addition of 0, 10, 50 and 100 ng Se/mL medium as sodium selenite and 100 microg alpha-tocopheryl acetate/mL. Lactic dehydrogenase (LDH) leakage of the hepatocytes was not influenced by the various selenium concentrations of the media, whereas vitamin E addition significantly inhibited LDH release. The activity of cellular glutathione peroxidase (GPx1) was markedly induced by increasing the selenium supplementation of the culture media. Vitamin E supply further enhanced GPx1 induction. In hepatocytes cultivated at the lower serum concentration (2.5% FCS), increasing the selenite concentration of the media raised GPx1 and reduced the intracellular levels of the reduced tripeptide glutathione (GSH). No vectored relation between the selenium concentration of the media and the activity of superoxide dismutase (SOD) could be observed. After both incubation periods (24 h and 48 h) SOD activity was significantly higher in the cytosol of hepatocytes grown in media containing 10% FCS as compared to cells incubated at the 2.5% FCS level. Furthermore, SOD activity was reduced by the addition of vitamin E to the media. In conclusion the results indicate an effective metabolism of rabbit hepatocytes for selenite even in amounts as low as nanograms. A general cytoprotective role for vitamin E can be shown by its ability to decrease LDH leakage and by the reduction of SOD activity.     

Manipulation of medium conditions and differentiation in the rat myogenic cell line L6

Myoblasts of the L6 rat cell line were grown in Ham's F12 nutrient medium containing 10% fetal calf serum (F12 + FCS). Although the cells were confluent by 6 days in culture, fusion was not observed even if cultures were maintained for 10–14 days. At least 80% of the cells in such confluent unfused cultures were in the G₁ phase of the cell cycle and less than 5% of the cells in confluent cultures synthesized DNA during a 4-day period. The synthesis of muscle-specific proteins (α-actin, β-tropomyosin, and myosin light chains LC1_emb and LC2_F) was negligible when compared to fused cultures of L6 cells grown for a similar time in Dulbecco's medium with 10% FCS (DME + FCS). When the unfused cultures were shifted from F12 + FCS to DME + FCS, DNA synthesis could be demonstrated in more than 95% of the cells and fusion occurred, indicating that neither proliferative nor myogenic capacity had been irreversibly lost. Raising the levels of calcium, varying the serum concentration from 0 to 20%, or the addition of medium components (present in DME but reduced or absent in F12) all failed to induce fusion in the L6 cells grown in F12. However, L6 cells will fuse in mixtures of F12 + FCS and DME + FCS. Fusion will also occur if L6 cells are grown at clonal density in F12 + FCS supplemented with calcium. While it has not been possible to determine why F12 + FCS is nonpermissive for L6 cells in confluent mass cultures, the results demonstrate that prolonged residence in the G₁ phase of the cell cycle is not a sufficient condition for L6 myoblast differentiation to occur.     

Human purified interleukin-1 inhibits DNA synthesis and cell growth of osteoblastic cell line (MC3T3-E1), but enhances alkaline phosphatase activity in the cells

We examined the effects of human purified interleukin-1 (IL-1) on DNA synthesis, cell growth, and alkaline phosphatase activity in the osteoblastic cell line MC3T3-E1 under both preconfluent and confluent culture conditions. Addition of IL-1 to the cells markedly inhibited their DNA synthesis and growth over the range 1-10 U/ml. Such significant inhibitory effects were observed in cells cultivated in 1 or 5% fetal calf serum (FCS)-containing alpha modification Eagle's medium (alpha-MEM), but not in alpha-MEM containing 10% FCS. In contrast, alkaline phosphatase activity was enhanced significantly by IL-1 in the cell line cultivated in 1% FCS-containing alpha-MEM. These results demonstrate that human purified IL-1 is effective in inducing the differentiation of osteoblastic cell MC3T3-E1.     

Effects of chick brain extract on the proliferation of chick neuroblasts cultured in media supplemented with low and high serum concentrations

The proliferative activity of chick neuroblasts cultured in a medium containing a low (5%) or a high (20%) concentration of fetal calf serum (FCS) was analyzed and the influence of a chick brain extract was investigated. Morphological observations and tritiated thymidine incorporation measurements have shown that neuroblasts from 6 day-old chick embryo cerebral hemispheres proliferate more actively in the medium with 5% FCS compared to the medium with 20% FCS. The medium containing 5% FCS favoured the maintenance of neuronal cells in a neuroblast stage as shown by electron microscopy. The stimulatory effect of brain extract on the proliferation of neuroblasts is stronger in the low serum culture condition. These findings indicate that a low serum-containing medium is an adequate condition to study neuronal proliferation and effects of growth factors on these cells.     

Cryopreservation and in vitro expansion of chondroprogenitor cells isolated from the superficial zone of articular cartilage

Understanding the proliferation mechanisms of chondroprogenitor cells and their influence on cell differentiation is crucial in order to develop large-scale expansion processes for tissue engineering applications. Proliferation control mechanisms were mainly attributed to substrate limitation and cell-cell contact inhibition. The limiting substrates were found to be components of the FCS, with an optimal proliferation rate achieved in the presence of 40% FCS. In addition, the medium supply rate was found to be essential in reducing substrate limitation. In terms of FCS, 10 microL FCS cm(-2) h(-1) was the threshold feed rate required to prevent substrate limitation. Above this rate, maximum cell densities of 5.3 x 10(5) cells/cm2 were achieved, representing a 53-fold expansion. To reduce the need for high supply rates, the effect of specific growth factors was also investigated. Cell densities of 3.3 x 10(5) cells/cm2 were achieved in batch cultures using 40% FCS and 1 ng/mL TGF-beta1. Chondroprogenitor cells were expanded in this medium up to three passages without compromising their ability to differentiate and produce cartilage-like matrix in pellet cultures. In addition to substrate limitation, cell-cell contact, even at very sparse subconfluent densities, appeared capable of exerting some degree of growth inhibition. The cells exhibited deceleratory growth kinetics, characterized by a decrease of specific growth rates over time.     

Observations on the influence of glutamine,asparagine and peptone on growth and t-PA production of Chinese hamster ovary (CHO) cells

When a transfected CHO cell, that produces tissue-type Plasminogen Activator, t-PA, was transferred from a medium based on 5% Fetal Calf Serum, FCS, to a medium based on 0.8% casein peptone with variable glutamine and asparagine content, it was observed, that the growth of the cells changed from anchorage dependant to suspension culture giving more reproducible cultivations. In the FCS culture t-PA was unstable, observed as a decline in t-PA concentration after 250 h. This decline in t-PA concentration was not observed in the serum free culture, although there was a decline in productivity after 200 h. This change in production profile may be attributed to either no proteolytic attack from serum or by scavenging of proteolytic activities produced by the cells from the peptone peptides. Increasing amounts of glutamine/asparagine gave higher production of t-PA in synchrony with an increasing production of ammonia/ammonium ions. Ammonia inhibition does not seem to be a key factor for this cell line as seen with many others.     

A low-serum medium with BSA and ferrous sulfate for the production of tissue plasminogen activator by human embryo lung cells

A low-serum medium containing bovine serum albumin (BSA) was investigated with respect to the growth of and tissue plasminogen activator (TPA) production by human embryo lung (HEL) cells on microcarrier beads and in collagen gel. BSA and ferrous sulfate were chosen as substitutes for fetal calf serum (FCS) through a simple screening test involving many substances. The growth promoting effects of BSA and ferrous sulfate were independent of each other and from the FCS concentration. Though BSA inhibited initial cell attachment to the carrier surface, it did promote the growth of cells attached to microcarrier beads. Cells grown on microcarrier beads in the low-serum medium containing BSA, ferrous sulfate and 3% FCS produced an amount of TPA similar to that produced by ones grown in the 10% FCS medium. Although cells on the dish surface did not grow at all on serum-free media containing BSA and ferrous sulfate, cells in the collagen gel were able to grow slightly on the serum-free medium. Cells grown on the low-serum medium in collagen gel produced more TPA over a long period than those in the microcarrier beads using the low-serum medium. The optimum concentration of proteose peptone in the TPA production medium for the collagen gel culture was similar to that for the dish surface culture.     

连翘酯苷对小鼠脾脏淋巴细胞体外增殖与分泌功能的影响

目的分析连翘酯苷（FS）对小鼠脾脏T和B淋巴细胞增殖、分泌NO和TNF-α的影响,初步探讨其免疫调节作用机制。方法无菌操作分离小鼠脾脏,制备脾脏细胞并用含10%胎牛血清的RPMI 1640培养,在培养液中分别加入刺激剂刀豆蛋白（ConA）和脂多糖（LPS）以及不同浓度40、80、160μg/mL的FS共培养不同时间,采用MTT法检测T和B淋巴细胞的吸光度变化,ELISA和Griess法分别检测细胞分泌TNF-α和NO的水平。结果低浓度和中浓度FS对ConA诱导T淋巴细胞24 h和48 h后细胞增殖和存活率明显提高,诱导时间延长至72 h后FS明显抑制细胞转化;低浓度FS对LPS诱导脾脏B淋巴细胞24 h后细胞增殖和生存率显著提高;FS促进小鼠脾脏T和B淋巴细胞分泌NO;FS促进B淋巴细胞分泌TNF-α,中浓度FS促进T淋巴细胞分泌TNF-α而高浓度反而抑制其分泌。此外,FS对环磷酰胺（CY）处理小鼠的脾脏淋巴细胞体外增殖有明显影响,对细胞NO分泌影响不显著。结论结果提示FS可能通过影响小淋巴细胞增殖和细胞因子分泌而调节免疫细胞功能。