Inhibition of bacterial growth and malolactic fermentation in wine by bacteriophage

Bacteriophage present in wine can attack bacterial starter cultures and inhibit the malolactic fermentation. The possibility of starter culture failure due to phage attack was studied in a commercial dry red wine of pH 3·23, inoculated with a multiple strain starter culture. During two stages of malolactic fermentation, bacterial growth and malate degradation in the wine were inhibited. A phage capable of lysing isolates of Leuconostoc oenos was isolated from the wine. The isolated phage had an icosahedral head of 42–45 nm diameter and a flexible, regularly cross-striated tail 197–207 nm long with a small baseplate. The results confirm that phage can attack bacterial starter cultures in wine at low pH.     

Factors affecting the induction of malolactic fermentation in red wines with Leuconostoc oenos

Malolactic fermentation was induced in red wines by inoculation with several strains of Leuconostoc oenos . The progress of Malolactic Fermentation was monitored by following the kinetics of bacterial growth and degradation of malic acid. These kinetics varied significantly depending on the strain of Leuc. oenos inoculated, the strain of Saccharomyces cerevisiae used to conduct the alcoholic fermentation, and the wine properties of pH and concentrations of ethanol and sulphur dioxide. Rapid, predictable malolactic fermentation was achieved by inoculating a high density (> 10⁶ cfu/ml) of Leuc. oenos , whereby malic acid degradation was not connected to the growth of the bacterial cells. Wines after malolactic fermentation were not bacteriologically stable and supported the growth of Leuc. oenos inoculated into the wines.     

Occurrence and properties of bacteriophages of Leuconostoc oenos in Australian wines

Bacteriophages specific for Leuconostoc oenos were isolated from four red wines undergoing malolactic fermentation in one winery. Bacteriophages were not found in samples of 16 other wines. The morphology of the phages was examined by electron microscopy. The phages did not lyse all strains of L. oenos, and susceptibility correlated to some extent with the colony morphology of the strain. Phage survived in wines at pH values greater than 3.5 but was inactivated in wines of lower pH and by the addition of sulfur dioxide or bentonite. Phage did not affect the growth of a sensitive strain of L. oenos in filter-sterilized wine.     

Occurrence and properties of bacteriophages of Leuconostoc oenos in Australian wines.

Bacteriophages specific for Leuconostoc oenos were isolated from four red wines undergoing malolactic fermentation in one winery. Bacteriophages were not found in samples of 16 other wines. The morphology of the phages was examined by electron microscopy. The phages did not lyse all strains of L. oenos, and susceptibility correlated to some extent with the colony morphology of the strain. Phage survived in wines at pH values greater than 3.5 but was inactivated in wines of lower pH and by the addition of sulfur dioxide or bentonite. Phage did not affect the growth of a sensitive strain of L. oenos in filter-sterilized wine.     

Controlling Wine Malolactic Fermentation with Nisin and Nisin-Resistant Strains of Leuconostoc oenos

The polypeptide nisin (100 U/ml) prevented malolactic fermentation in wines by indigenous or intentionally added lactic acid bacteria. Nisin (100 U/ml)-resistant mutants of Leuconostoc oenos were obtained and used with nisin in wine to carry out a pure-culture malolactic fermentation in the presence or absence of other lactic acid bacteria. Nisin degradation by mutants was not observed, and residual nisin was detectable in wines 4 months after it was added. Results indicated that nisin or nisin with resistant bacterial starter cultures can be used to control malolactic fermentation in wines.     

Inhibition of malolactic fermentation by cryotolerant yeasts

White wines produced by some cryotolerant strains of Saccharomyces cerevisiae are more resistant to malolactic fermentation than those produced by normal strains: e.g. for two months of storage, the wines, inoculated with Leuconostoc oenos or Lactobacillus plantarum, were fully stabilized with levels of 51-65 mg total SO 2 /l and 5.70-5.75 g titratable acidity/l. The use of these yeasts in wine-making can decrease the quantities of sulfites added to stabilize wines.     

Identification of lactic acid bacteria isolated from Portuguese wines and musts by SDS-PAGE

Thirty-two strains were isolated from spoiled port wines, from musts and from various styles of young, Northeastern Portuguese red table wines that had undergone spontaneous malolactic fermentation. Comparison of their SDS-PAGE whole-cell protein patterns with an SDS-PAGE database of lactic acid bacteria indicated that the isolates were members of the species Leuconostoc oenos or Lactobacillus paracasei subsp. paracasei. The latter were found in low acidity table wines and in port wine. The isolation of Lactobacillus paracasei strains from wines indicates the importance of using known strains for wine deacidification because spontaneous malolactic fermentation of table wines can occur from an indigenous flora, adapted to the particular composition of the wine.     

Microbiology of the malolactic fermentation: Molecular aspects

Abstract Malolactic fermentation conducted by lactic acid bacteria follows alcoholic fermentation during winemaking, and several positive effects make it indispensable for most wines. Research has focused on the growth and physiology of lactic acid bacteria in wine; resulting in the design of malolactic starter cultures. Future work on these starters will concentrate on aromatic changes as additional criteria for strain selection. Although the main features of the malolactic enzyme and its gene are known, the detailed mechanism of the malolactic reaction remains unclear. Cloning and expression of this activity in enological strains of Saccharomyces cereuisiae might be one of the next most important advances in the control of malic acid degradation in wine.     

Growth and energetics of Leuconostoc oenos during cometabolism of glucose with citrate or fructose.

The metabolic and energetic characterization of the growth of Leuconostoc oenos on glucose-citrate or glucose-fructose mixtures enables the potential role of this bacterium in the wine-making process to be ascertained. Moreover, mixotrophic conditions remain a suitable means for improving biomass productivities of malolactic starter cultures. When the malolactic bacterium L. oenos was grown in batch cultures on complex medium at pH 5.0 with glucose-citrate or glucose-fructose mixtures, enhancement of both the specific growth rate and biomass production yields was observed. While growth was possible on fructose as the sole source of energy, citrate alone did not allow subsequent biomass production. The metabolic interactions between the catabolic pathways of the glucose cosubstrates and the heterofermentation of hexoses led to an increased acetate yield as a result of modified NADH oxidation. However, the calculated global coenzyme regeneration showed that the reducing equivalent balance was never equilibrated. The stimulatory effects of these glucose cosubstrates on growth resulted from increased ATP synthesis by substrate-level phosphorylation via acetate kinase. While the energetic efficiency remained close to 10 g of biomass produced per mol of ATP, the increase in the specific growth rate and biomass production yields was directly related to the rate and yield of ATP generation.     

Comparison of Leuconostoc oenos Strains by Pulsed-Field Gel Electrophoresis

Pulsed-field gel electrophoresis of chromosomal DNA digested with NotI or SfiI was used to differentiate individual strains of Leuconostoc oenos. L. oenos isolates with 13 different restriction digest patterns were detected in New Zealand wines undergoing malolactic fermentation. The average genome size was estimated to be 1,800 kb.     

Design of a low-cost culture medium based in whey permeate for biomass production of enological Lactobacillus plantarum strains

The production of malolactic starter cultures requires the obtention of suitably large biomass at low-cost. In this work it was possible to obtain a good amount of biomass, at laboratory scale, of two enological strains of Lb. plantarum, by formulating a culture medium based on whey permeate (WP), a by-product of the cheese industry usually disposed as waste, when this was supplemented with yeast extract (Y), salts (S) and Tween 80 (T) (WPYST). Bacteria grown in WPYST medium exhibited good tolerance to stress conditions of synthetic wine (pH 3.5, ethanol 13% vol/vol). However, when WPYST was added with 8% vol/vol ethanol, cultures inoculated in synthetic wine, showed a lower viability and capacity to consume L-malic acid than when they were cultured in WPYST without ethanol. Subsequently, strains grown in WPYST were inoculated in sterile wine samples (final stage of alcoholic fermentation) of the red varietals Merlot and Pinot noir, and incubated at laboratory scale. Cultures from WPYST, inoculated in Pinot noir wine, showed a better performance than bacteria grown in MRS broth, and exhibited a consumption of L-malic acid higher than 90%. However, cultures from WPYST or from MRS broth, inoculated in sterile Merlot wine, showed a lower survival. This study allowed the formulation of a low-cost culture medium, based on a by-product of the food industry, which showed to be adequate for the growth of two enological strains of Lb. plantarum, suggesting their potentiality for application in the elaboration of malolactic starter cultures.     

Technological properties of Oenococcus oeni strains isolated from typical southern Italian wines

Aims: To isolate indigenous Oenococcus oeni strains suitable as starters for malolactic fermentation (MLF), using a reliable polyphasic approach. Methods and Results: Oenococcus oeni strains were isolated from Nero di Troia wines undergoing spontaneous MLF. Samples were taken at the end of alcoholic fermentation and during MLF. Wine samples were diluted in a sterile physiological solution and plated on MRS and on modified FT80. Identification of O. oeni strains was performed by a polymerase chain reaction (PCR) experiment using strain‐specific primers. Strains were further grouped using a multiplex RAPD‐PCR analysis. Then, six strains were inoculated in two wine‐like media with two different ethanol concentrations (11 and 13% vol/vol) with a view to evaluate their capacity to grow and to perform MLF. In addition, a quantitative PCR (qRT‐PCR) approach was adapted to monitor the physiological state of the strains selected. Conclusion: A positive correlation between the malolactic activity performance and the ability to develop and tolerate stress conditions was observed for two selected O. oeni strains. Significance and Impact of the Study: The results reported are useful for the selection of indigenous MLF starter cultures with desired oenological traits from typical regional wines. It should be the base for the improvement in organoleptic quality of typical red wine.     

Performance and diacetyl production of commercial strains of malolactic bacteria in wine

This study compares 11 commercial cultures of Leuconostoc oenos and Lactobacillus plantarum in Cabernet Sauvignon, Pinot Noir and Chardonnay wines. Performance of the cultures was found to be greatly influenced by wine type. Better survival of the bacteria was observed in Cabernet Sauvignon and Pinot Noir wines. The time necessary to complete malolactic fermentation (MLF) was 65 ± 14 d for Chardonnay, 71 ± 3 d for Cabernet Sauvignon, and 25 ± 8 d for Pinot Noir. The maximal rate of malate utilization was 0·4 g d^-1 for Pinot Noir, and 0·2 g d^-1 for the two other wine types. Final diacetyl concentration was lower in Chardonnay wines (highest 0·58 mg l^-1) compared to the other wines (highest 5·8 mg l^-1). Malic and citric acid were co-metabolized by all strains. None of the strains metabolized glycerol. Significant differences in final diacetyl concentration of wine vinified with the different strains were found. Panelists could reliably differentiate MLF wines from non-MLF wines, irrespective of their diacetyl content, indicating that diacetyl is not the only important MLF flavour.     

Malolactic bioconversion using a<Emphasis Type="Italic"> Oenococcus oeni</Emphasis> strain for cider production: effect of yeast extract supplementation

Yeast extract addition to reconstituted apple juice had a positive impact on the development of the malolactic starter culture used to ensure malolactic fermentation in cider, using active but non-proliferating cells. In this work, the reuse of fermentation lees from cider is proposed as an alternative to the use of commercial yeast extract products. Malolactic enzymatic assays, both in whole cells and cell-free extracts, were carried out to determine the best time to harvest cells for use as an inoculum in cider. Cells harvested at the late exponential phase, the physiological stage of growth corresponding to the maximum values of specific malolactic activity, achieved a good rate of malic acid degradation in controlled cider fermentation. Under the laboratory conditions used, malic acid degradation rates in the fermentation media turned out to be near 2.0 and 2.5 times lower, compared with the rates obtained in whole-cell enzymatic assays, as useful data applicable to industrial cider production.     

Leuconostoc oenos and malolactic fermentation in wine: a review

This review article summarizes the state of the art on Leuconostoc oenos, the bacteria responsible for malolactic fermentation in wine. Both basic and practical aspects related to the metabolism of this microorganism and malolactic fermentation in general are critically reviewed. The former examines the role of genetics for the identification and classification of L. oenos and energetic mechanisms on solute transport (malic and lactic acid). The latter includes practical information on biomass production, optimal growth conditions and stress factors, which are important in growth optimization of malolactic starter cultures. Extensive data and references on the effect of malolactic fermentation on wine composition and sensory analysis are also included. Received 06 May 1999/ Accepted in revised form 13 July 1999     

Timing of malolactic fermentation inoculation in Shiraz grape must and wine: influence on chemical composition

Malolactic fermentation (MLF) is an integral step in red winemaking, which in addition to deacidifying wine can also influence the composition of volatile fermentation-derived compounds with concomitant affects on wine sensory properties. Long-established winemaking protocols for MLF induction generally involve inoculation of bacteria starter cultures post alcoholic fermentation, however, more recently there has been a trend to introduce bacteria earlier in the fermentation process. For the first time, this study shows the impact of bacterial inoculation on wine quality parameters that define red wine, including wine colour and phenolics, and volatile fermentation-derived compounds. This study investigates the effects of inoculating Shiraz grape must with malolactic bacteria at various stages of alcoholic fermentation [beginning of alcoholic fermentation (co-inoculation, with yeast), mid-alcoholic fermentation, at pressing and post alcoholic fermentation] on the kinetics of MLF and wine chemical composition. Co-inoculation greatly reduced the overall fermentation time by up to 6 weeks, the rate of alcoholic fermentation was not affected by the presence of bacteria and the fermentation-derived wine volatiles profile was distinct from wines produced where bacteria were inoculated late or post alcoholic fermentation. An overall slight decrease in wine colour density observed following MLF was not influenced by the MLF inoculation regime. However, there were differences in anthocyanin and pigmented polymer composition, with co-inoculation exhibiting the most distinct profile. Differences in yeast and bacteria metabolism at various stages in fermentation are proposed as the drivers for differences in volatile chemical composition. This study demonstrates, with an in-depth analysis, that co-inoculation of yeast and bacteria in wine fermentation results in shorter total vinification time and produces sound wines, thus providing the opportunity to stabilise wines more rapidly than traditional inoculation regimes permit and thereby reducing potential for microbial spoilage.     

Dynamics of indigenous and inoculated yeast populations and their effect on the sensory character of Riesling and Chardonnay wines

To study the impact of yeast populations on wine flavour and to better understand yeast growth dynamics, wines were produced by the (i) indigenous microflora, (ii) vigorous yeast starter EC1118 and (iii) slowly fermenting yeast Assmannshausen. Sensory analysis revealed that wines differed depending on the fermentation type. However, these yeast-related differences did not exceed the varietal character. Both added starter cultures clearly dominated the Saccharomyces population from the middle of fermentation onwards. The starter cultures differed in their repression of indigenous non- Saccharomyces yeast. EC1118 limited growth of non- Saccharomyces yeasts more strongly than Assmannshausen. Sulphite addition further repressed growth of non- Saccharomyces yeasts. On completion, more than one Saccharomyces strain was present in each fermentation, with the largest variety in the non-inoculated and the smallest in the EC1118-inoculated fermentation. Results from the two genetic assays, karyotyping, and PCR using δ-primers were not fully equivalent, limiting the usefulness of δ-PCR in studies of native Saccharomyces yeasts.     

Specific enumeration of lactic acid bacteria in fermenting grape must and wine by colony hybridization with non-isotopic DNA probes

A. LONVAUD-FUNEL, A. JOYEUX AND O. LEDOUX. 1991. Total DNA extracted from lactic acid bacteria commonly found in musts and wines was randomly labelled with digoxigenin. It was assayed for the detection of several species by dot-blot hybridization. The method proved to be specific as there was no cross-hybridization between most of the species belonging to the genera Leuconostoc, Pediococcus and Lactobacillus , homofermentative and heterofermentative ( Lact. plantarum, Lact. casei, Leuc. mesenteroides, Leuc. oenos, Ped. damnosus, Ped. pentosaceus ). However, it failed for some Lact. brevis strains which strongly hybridized with Lact. hilgardii.
Colony hybridization was performed directly on plates soon after enumeration. Eight probes of the most common species were used; it was possible to follow the evolution of each species during the vinification of two red wines. According to the phase of alcoholic fermentation, then malolactic fermentation, the predominance or regression of bacilli and cocci could be established.     

Identification of pOENI-1 and Related Plasmids in Oenococcus oeni Strains Performing the Malolactic Fermentation in Wine

Plasmids in lactic acid bacteria occasionally confer adaptive advantages improving the growth and behaviour of their host cells. They are often associated to starter cultures used in the food industry and could be a signature of their superiority. Oenococcus oeni is the main lactic acid bacteria species encountered in wine. It performs the malolactic fermentation that occurs in most wines after alcoholic fermentation and contributes to their quality and stability. Industrial O. oeni starters may be used to better control malolactic fermentation. Starters are selected empirically by virtue of their fermentation kinetics and capacity to survive in wine. This study was initiated with the aim to determine whether O. oeni contains plasmids of technological interest. Screening of 11 starters and 33 laboratory strains revealed two closely related plasmids, named pOENI-1 (18.3-kb) and pOENI-1v2 (21.9-kb). Sequence analyses indicate that they use the theta mode of replication, carry genes of maintenance and replication and two genes possibly involved in wine adaptation encoding a predicted sulphite exporter (tauE) and a NADH:flavin oxidoreductase of the old yellow enzyme family (oye). Interestingly, pOENI-1 and pOENI-1v2 were detected only in four strains, but this included three industrial starters. PCR screenings also revealed that tauE is present in six of the 11 starters, being probably inserted in the chromosome of some strains. Microvinification assays performed using strains with and without plasmids did not disclose significant differences of survival in wine or fermentation kinetics. However, analyses of 95 wines at different phases of winemaking showed that strains carrying the plasmids or the genes tauE and oye were predominant during spontaneous malolactic fermentation. Taken together, the results revealed a family of related plasmids associated with industrial starters and indigenous strains performing spontaneous malolactic fermentation that possibly contribute to the technological performance of strains in wine.     

Malolactic fermentation in wine with high densities of non-proliferating Oenococcus oeni

Five strains of Oenococcus oeni (syn. Leuconostoc oenos) under non-proliferating conditions were assessed for the performance of the malolactic fermentation in wine at various initial pH values, malic acid concentration and densities of cells. We succeeded in inducing the malolactic fermentation after inoculation of high densities of O. oeni G6 even in recalcitrant wines where the traditional malolactic fermentation was inhibited by adverse environmental conditions (low pH and high concentration of malic acid). Optimal degrading conditions in wine, under different physico-chemical environments, were determined in order to achieve rapid depletion of malic acid in red wine. Off-odour compounds were not formed under these conditions, suggesting an attractive alternative for wine production. This revised version was published online in November 2006 with corrections to the Cover Date.