Direct In Situ Viability Assessment of Bacteria in Probiotic Dairy Products Using Viability Staining in Conjunction with Confocal Scanning Laser Microscopy

The viability of the human probiotic strains Lactobacillus paracasei NFBC 338 and Bifidobacterium sp. strain UCC 35612 in reconstituted skim milk was assessed by confocal scanning laser microscopy using the LIVE/DEAD BacLight viability stain. The technique was rapid (<30 min) and clearly differentiated live from heat-killed bacteria. The microscopic enumeration of various proportions of viable to heat-killed bacteria was then compared with conventional plating on nutrient agar. Direct microscopic enumeration of bacteria indicated that plate counting led to an underestimation of bacterial numbers, which was most likely related to clumping. Similarly, LIVE/DEAD BacLight staining yielded bacterial counts that were higher than cell numbers obtained by plate counting (CFU) in milk and fermented milk. These results indicate the value of the microscopic approach for rapid viability testing of such probiotic products. In contrast, the numbers obtained by direct microscopic counting for Cheddar cheese and spray-dried probiotic milk powder were lower than those obtained by plate counting. These results highlight the limitations of LIVE/DEAD BacLight staining and the need to optimize the technique for different strain-product combinations. The minimum detection limit for in situ viability staining in conjunction with confocal scanning laser microscopy enumeration was ~10⁸ bacteria/ml (equivalent to ~10⁷ CFU/ml), based on Bifidobacterium sp. strain UCC 35612 counts in maximum-recovery diluent.     

Direct in situ viability assessment of bacteria in probiotic dairy products using viability staining in conjunction with confocal scanning laser microscopy

The viability of the human probiotic strains Lactobacillus paracasei NFBC 338 and Bifidobacterium sp. strain UCC 35612 in reconstituted skim milk was assessed by confocal scanning laser microscopy using the LIVE/DEAD BacLight viability stain. The technique was rapid (<30 min) and clearly differentiated live from heat-killed bacteria. The microscopic enumeration of various proportions of viable to heat-killed bacteria was then compared with conventional plating on nutrient agar. Direct microscopic enumeration of bacteria indicated that plate counting led to an underestimation of bacterial numbers, which was most likely related to clumping. Similarly, LIVE/DEAD BacLight staining yielded bacterial counts that were higher than cell numbers obtained by plate counting (CFU) in milk and fermented milk. These results indicate the value of the microscopic approach for rapid viability testing of such probiotic products. In contrast, the numbers obtained by direct microscopic counting for Cheddar cheese and spray-dried probiotic milk powder were lower than those obtained by plate counting. These results highlight the limitations of LIVE/DEAD BacLight staining and the need to optimize the technique for different strain-product combinations. The minimum detection limit for in situ viability staining in conjunction with confocal scanning laser microscopy enumeration was approximately 10(8) bacteria/ml (equivalent to approximately 10(7) CFU/ml), based on Bifidobacterium sp. strain UCC 35612 counts in maximum-recovery diluent.     

Spray Dried Formulation of 5-Fluorouracil Embedded with Probiotic Biomass: In Vitro and In Vivo Studies

The present study is utilizing the targeted therapeutic approach and antioxidant potential of selected probiotic biomass in mitigating toxic side effects of chemotherapeutic agents. Multicomponent carrier system consisting of 5-fluorouracil (5-FU) and selected probiotic strain with higher free radical scavenging activity was prepared using spray drying technique. Prepared spray dried microparticles were characterized for various physical, pharmaceutical, and biopharmaceutical properties including particle size, moisture content, entrapment efficiency, in vitro drug release, DSC, XRD, cell uptake, histopathology, and pharmacokinetic studies. In addition to the above, optimized formulation was subjected to in vivo targeting efficacy studies using radiographic technique. Optimized formulation meets the necessary physical requirement for pharmaceutical powder. X-ray studies revealed that the prepared spray dried formulations are able to target the colon. Pharmacokinetic endpoints with an extended t _1/2 and lower C _max indicate lower systemic toxicity. Intact nature of colonic epithelium in experimental formulation clearly demonstrates the protective role of Lactobacillus rhamnosus in minimizing the harmful consequence induced by 5-FU. Existing outcomes provide the basis for a combination of targeted therapeutic approach with natural antioxidant capacity of potential probiotic strain which could help to mitigate the problems associated with traditional chemotherapy.     

Survival of Lactobacillus plantarum 44a after spraying and drying in feed and during exposure to gastrointestinal tract fluids in vitro

A good probiotic strain should be able to survive the conditions of handling and storage to be delivered in high concentration to the host. That is especially important when stressful conditions are prevalent in the carrier, for instance in low water content foods like animal feed. The aim of this research was to study the survival of the probiotic candidate Lactobacillus plantarum 44a after spraying and drying in feed, and during storage and exposure to gastrointestinal tract fluids in vitro. In addition, the viability of the strain during exposure to distilled water and 2% NaCl was studied. Feed was sprayed with a suspension of asymptotically equal to 2 x 10(10) CFU of L. plantarum 44a in 10, 15, 20, 25 and 30% v/w of the feed and dried to constant weight (6% moisture) in a convective oven at 25 degrees C. L. plantarum 44a survived 14.67, 36, 51.86, 78.9 and 105.3% respectively in relation to the original % v/w of the feed. After 3 weeks of storage at 25 degrees C, survival was similarly low in all the treatments. L. plantarum 44a stored in feed containing 13% moisture, vacuum-packaged and stored in refrigeration, maintained high viability (approximately 100%) after 1 year of storage. Survival was not affected after feed-containing lactobacilli was exposed to gastrointestinal fluids in a simulation model. Viability of L. plantarum 44a as a cell suspension in PBS added directly to distilled water or distilled water with 2% NaCl was maintained up to 48 h; after 72 h, viability started to decline. It is concluded that L. plantarum 44a maintained high viability after being dried and stored in feed even after exposure to gastric and intestinal fluids in vitro.     

A high-throughput screening strategy for accurate quantification of menaquinone based on fluorescence-activated cell sorting

To enhance the screening efficiency and accuracy of a high-yield menaquinone (vitamin K₂, MK) bacterial strain, a novel, quantitative method by fluorescence-activated cell sorting (FACS) was developed. The staining technique was optimized to maximize the differences in fluorescence signals between spontaneous and MK-accumulating cells. The fluorescence carrier rhodamine 123 (Rh123), with its ability to reflect membrane potential, proved to be an appropriate fluorescent dye to connect the MK content with fluorescence signal quantitatively. To promote adequate access of the fluorescent molecule to the target and maintain higher cell survival rates, staining and incubation conditions were optimized. The results showed that 10 % sucrose facilitated uptake of Rh123, while maintaining a certain level of cell viability. The pre-treatment of cells with MgCl₂ before staining with Rh123 also improved cell viability. Using FACS, 50 thousands cells can easily be assayed in less than 1 h. The optimized staining protocol yielded a linear response for the mean fluorescence against high performance liquid chromatography-measured MK content. We have developed a novel and useful staining protocol in the high-throughput evaluation of Flavobacterium sp. mutant libraries, using FACS to identify mutants with increased MK-accumulating properties. This study also provides reference for the screening of other industrial microbial strains.     

Study of Adhesion and Survival of Lactobacilli and Bifidobacteria on Table Olives with the Aim of Formulating a New Probiotic Food

With the aim of developing new functional foods, a traditional product, the table olive, was used as a vehicle for incorporating probiotic bacterial species. Survival on table olives of Lactobacillus rhamnosus (three strains), Lactobacillus paracasei (two strains), Bifidobacterium bifidum (one strain), and Bifidobacterium longum (one strain) at room temperature was investigated. The results obtained using a selected olive sample demonstrated that bifidobacteria and one strain of L. rhamnosus (Lactobacillus GG) showed a good survival rate, with a recovery of about 10⁶ CFU g⁻¹ after 30 days. The Lactobacillus GG population remained unvaried until the end of the experiment, while a slight decline (to about 10⁵ CFU g⁻¹) was observed for bifidobacteria. High viability, with more than 10⁷ CFU g⁻¹, was observed throughout the 3-month experiment for L. paracasei IMPC2.1. This strain, selected for its potential probiotic characteristics and for its lengthy survival on olives, was used to validate table olives as a carrier for transporting bacterial cells into the human gastrointestinal tract. L. paracasei IMPC2.1 was recovered from fecal samples in four out of five volunteers fed 10 to 15 olives per day carrying about 10⁹ to 10¹⁰ viable cells for 10 days.     

Generation of uncultivable forms of Lactobacillus plantarum 8R-A3 under solid-state cultivation on wheat bran

This paper shows that in the solid-state cultivation of Lactobacillus plantarum 8R-A3 on wheat bran, a biofilm was formed on the surface of the carrier within 48 h. Prolongation of fermentation caused a drop in the number of CFU from 96% of the initial total number of cells to 8.8% by 72 h. When the temperature was raised from 37 to 45°C, which led to drying of the fermentation mass, the CFU index decreased to <10⁴. According to fluorescence microscopy data, up to 40% of bacteria with signs of life survived in the dry specimens. After keeping the mice on a diet with the introduction of 0.05% of fermented bran dried for 72 hours, a strain genetically identical to the L. plantarum 8R-A3 was extracted from the colon. In animals with amikacin-inhibited intestinal lactobacilli, their normal level recovered. It is suggested that L. plantarum 8R-A3 generates uncultivable forms, which are reanimated by passage through the animal organism and exhibit probiotic activity. The biofilm formed in the solid-state cultivation contributes to the survival of lactobacilli cells in drying of the fermentation mass.     

Study of adhesion and survival of lactobacilli and bifidobacteria on table olives with the aim of formulating a new probiotic food

With the aim of developing new functional foods, a traditional product, the table olive, was used as a vehicle for incorporating probiotic bacterial species. Survival on table olives of Lactobacillus rhamnosus (three strains), Lactobacillus paracasei (two strains), Bifidobacterium bifidum (one strain), and Bifidobacterium longum (one strain) at room temperature was investigated. The results obtained using a selected olive sample demonstrated that bifidobacteria and one strain of L. rhamnosus (Lactobacillus GG) showed a good survival rate, with a recovery of about 10(6) CFU g(-1) after 30 days. The Lactobacillus GG population remained unvaried until the end of the experiment, while a slight decline (to about 10(5) CFU g(-1)) was observed for bifidobacteria. High viability, with more than 10(7) CFU g(-1), was observed throughout the 3-month experiment for L. paracasei IMPC2.1. This strain, selected for its potential probiotic characteristics and for its lengthy survival on olives, was used to validate table olives as a carrier for transporting bacterial cells into the human gastrointestinal tract. L. paracasei IMPC2.1 was recovered from fecal samples in four out of five volunteers fed 10 to 15 olives per day carrying about 10(9) to 10(10) viable cells for 10 days.     

Comparative Survival Rates of Human-Derived Probiotic Lactobacillus paracasei and L. salivarius Strains during Heat Treatment and Spray Drying

Spray drying of skim milk was evaluated as a means of preserving Lactobacillus paracasei NFBC 338 and Lactobacillus salivarius UCC 118, which are human-derived strains with probiotic potential. Our initial experiments revealed that NFBC 338 is considerably more heat resistant in 20% (wt/vol) skim milk than UCC 118 is; the comparable decimal reduction times were 11.1 and 1.1 min, respectively, at 59°C. An air outlet temperature of 80 to 85°C was optimal for spray drying; these conditions resulted in powders with moisture contents of 4.1 to 4.2% and viable counts of 3.2 × 10⁹ CFU/g for NFBC 338 and 5.2 × 10⁷ CFU/g for UCC 118. Thus, L. paracasei NFBC 338 survived better than L. salivarius UCC 118 during spray drying; similar results were obtained when we used confocal scanning laser microscopy and LIVE/DEAD BacLight viability staining. In addition, confocal scanning laser microscopy revealed that the probiotic lactobacilli were located primarily in the powder particles. Although both spray-dried cultures appeared to be stressed, as shown by increased sensitivity to NaCl, bacteriocin production by UCC 118 was not affected by the process, nor was the activity of the bacteriocin peptide. The level of survival of NFBC 338 remained constant at ~1 × 10⁹ CFU/g during 2 months of powder storage at 4°C, while a decline in the level of survival of approximately 1 log (from 7.2 × 10⁷ to 9.5 × 10⁶ CFU/g) was observed for UCC 118 stored under the same conditions. However, survival of both Lactobacillus strains during powder storage was inversely related to the storage temperature. Our data demonstrate that spray drying may be a cost-effective way to produce large quantities of some probiotic cultures.     

Complete genome sequence analysis of a strain Lactobacillus pentosus ZFM94 and its probiotic characteristics

Lactic acid bacteria have been attracting increased attentions recent years because of harboring probiotic properties. In present study, a Lactobacillus pentosus strain ZFM94 was screened from healthy infant feces and its probiotic characteristics were investigated. We found that ZFM94 was resistant to environmental stresses (temperature, pH and NaCl), tolerant to gastrointestinal juice and bile salts, with inhibitory action against pathogens and capacity of folate production etc. Additionally, complete genome sequence of the strain was analyzed to highlight the probiotic features at genetic level. Genomic characteristics along with the experimental studies is critically important for building an appropriate probiotic profile of novel strains. Genes that correspond to phenotypes mentioned above were identified. Moreover, genes potentially related to its adaptation, such as carbon metabolism and carbohydrate transporter, carbohydrate-active enzymes, and a novel gene cluster RaS-RiPPs, were also revealed. Together, ZFM94 could be considered as a potential probiotic candidate.     

Advantageous Direct Quantification of Viable Closely Related Probiotics in Petit-Suisse Cheeses under In Vitro Gastrointestinal Conditions by Propidium Monoazide - qPCR

Species-specific Quantitative Real Time PCR (qPCR) alone and combined with the use of propidium monoazide (PMA) were used along with the plate count method to evaluate the survival of the probiotic strains Lactobacillus acidophilus La-5 and Bifidobacterium animalis subsp. lactis Bb-12, and the bacteriocinogenic and potentially probiotic strain Lactobacillus sakei subsp. sakei 2a in synbiotic (F1) and probiotic (F2) petit-suisse cheeses exposed throughout shelf-life to in vitro simulated gastrointestinal tract conditions. The three strains studied showed a reduction in their viability after the 6 h assay. Bb-12 displayed the highest survival capacity, above 72.6 and 74.6% of the initial populations, respectively, by plate count and PMA-qPCR, maintaining population levels in the range or above 6 log CFU/g. The prebiotic mix of inulin and FOS did not offer any additional protection for the strains against the simulated gastrointestinal environment. The microorganisms'' populations were comparable among the three methods at the initial time of the assay, confirming the presence of mainly viable and culturable cells. However, with the intensification of the stress induced throughout the various stages of the in vitro test, the differences among the methods increased. The qPCR was not a reliable enumeration method for the quantification of intact bacterial populations, mixed with large numbers of injured and dead bacteria, as confirmed by the scanning electron microscopy results. Furthermore, bacteria plate counts were much lower (P<0.05) than with the PMA-qPCR method, suggesting the accumulation of stressed or dead microorganisms unable to form colonies. The use of PMA overcame the qPCR inability to differentiate between dead and alive cells. The combination of PMA and species-specific qPCR in this study allowed a quick and unequivocal way of enumeration of viable closely related species incorporated into probiotic and synbiotic petit-suisse cheeses and under stress conditions.     

High-Throughput Screen for Poly-3-Hydroxybutyrate in Escherichia coli and Synechocystis sp. Strain PCC6803

A novel, quantitative method for detecting poly-3-hydroxybutyrate (PHB) amounts in viable cells was developed to allow for high-throughput screening of mutant libraries. The staining technique was demonstrated and optimized for the cyanobacterium Synechocystis sp. strain PCC6803 and the eubacterium Escherichia coli to maximize the fluorescence difference between PHB-accumulating and control cells by flow cytometry. In Synechocystis, the level of nonspecific dye binding was reduced by using nonionic stain buffer that allowed quantitation of fluorescence levels. In E. coli, the use of a mild sucrose shock facilitated uptake of Nile red without significant loss of viability. The optimized staining protocols yielded a linear response for the mean fluorescence against (chemically measured) PHB. The staining protocols are novel methods useful in the high-throughput evaluation of combinatorial libraries of Synechocystis and E. coli using fluorescence-activated cell sorting to identify mutants with increased PHB-accumulating properties.     

Identification of One Novel Candidate Probiotic Lactobacillus plantarum Strain Active against Influenza Virus Infection in Mice by a Large-Scale Screening

In this study, we developed a large-scale screening of bacterial strains in order to identify novel candidate probiotics with immunomodulatory properties. For this, 158 strains, including a majority of lactic acid bacteria (LAB), were screened by two different cellular models: tumor necrosis factor alpha (TNF-α)-activated HT-29 cells and peripheral blood mononuclear cells (PBMCs). Different strains responsive to both models (pro- and anti-inflammatory strains) were selected, and their protective effects were tested in vivo in a murine model of influenza virus infection. Daily intragastric administrations during 10 days before and 10 days after viral challenge (100 PFU of influenza virus H1N1 strain A Puerto Rico/8/1934 [A/PR8/34]/mouse) of Lactobacillus plantarum CNRZ1997, one potentially proinflammatory probiotic strain, led to a significant improvement in mouse health by reducing weight loss, alleviating clinical symptoms, and inhibiting significantly virus proliferation in lungs. In conclusion, in this study, we have combined two cellular models to allow the screening of a large number of LAB for their immunomodulatory properties. Moreover, we identified a novel candidate probiotic strain, L. plantarum CNRZ1997, active against influenza virus infection in mice.     

Single bioreactor gastrointestinal tract simulator for study of survival of probiotic bacteria

The aim of the present study was to design an in vitro model system to evaluate the probiotic potential of food. A single bioreactor system-gastrointestinal tract simulator (GITS) was chosen for process simulation on account of its considerable simplicity compared to multi-vessel systems used in previous studies. The bioreactor was evaluated by studying the viability of four known probiotic bacteria (Lactobacillus acidophilus La-5, Lactobacillus johnsonii NCC 533, Lactobacillus casei strain Shirota, and Lactobacillus rhamnosus GG) as a function of their physiological state. L. acidophilus and L. johnsonii survived in GITS better when introduced at an early stationary or exponential phase compared to being previously stored for 2 weeks at 4 degrees C. These two species were more resistant to bile salts and survived better than L. casei and L. rhamnosus GG. The latter two species gave large losses (up to 6 log) in plate counts independent of growth state due to the bile. However, experiments with some commercial probiotic products containing Lb. GG bacteria showed much better survival compared with model food (modified deMan-Rogosa-Sharpe growth medium), thus demonstrating the influence of the food matrix on the viability of bacteria. The study demonstrated that GITS can be successfully used for evaluation of viability of probiotic bacteria and functionality of probiotic food.     

Screening and Evaluation of Human Intestinal Lactobacilli for the Development of Novel Gastrointestinal Probiotics

The aim of this study was to screen intestinal lactobacilli strains for their advantageous properties to select those that could be used for the development of novel gastrointestinal probiotics. Ninety-three isolates were subjected to screening procedures. Fifty-nine percent of the examined lactobacilli showed the ability to auto-aggregate, 97% tolerated a high concentration of bile (2% w/v), 50% survived for 4 h at pH 3.0, and all strains were unaffected by a high concentration of pancreatin (0.5% w/v). One Lactobacillus buchneri strain was resistant to tetracycline. None of the tested strains caused lysis of human erythrocytes. Six potential probiotic strains were selected for safety evaluation in a mouse model. Five of 6 strains caused no translocation, and were considered safe. In conclusion, several strains belonging to different species and fermentation groups were found that have properties required for a potential probiotic strain. This study was the first phase of a multi-phase study aimed to develop a novel, safe and efficient prophylactic and therapeutic treatment system against gastrointestinal infections using genetically modified probiotic lactobacilli.     

Comparative survival rates of human-derived probiotic Lactobacillus paracasei and L. salivarius strains during heat treatment and spray drying

Spray drying of skim milk was evaluated as a means of preserving Lactobacillus paracasei NFBC 338 and Lactobacillus salivarius UCC 118, which are human-derived strains with probiotic potential. Our initial experiments revealed that NFBC 338 is considerably more heat resistant in 20% (wt/vol) skim milk than UCC 118 is; the comparable decimal reduction times were 11.1 and 1.1 min, respectively, at 59 degrees C. An air outlet temperature of 80 to 85 degrees C was optimal for spray drying; these conditions resulted in powders with moisture contents of 4.1 to 4.2% and viable counts of 3.2 x 10(9) CFU/g for NFBC 338 and 5.2 x 10(7) CFU/g for UCC 118. Thus, L. paracasei NFBC 338 survived better than L. salivarius UCC 118 during spray drying; similar results were obtained when we used confocal scanning laser microscopy and LIVE/DEAD BacLight viability staining. In addition, confocal scanning laser microscopy revealed that the probiotic lactobacilli were located primarily in the powder particles. Although both spray-dried cultures appeared to be stressed, as shown by increased sensitivity to NaCl, bacteriocin production by UCC 118 was not affected by the process, nor was the activity of the bacteriocin peptide. The level of survival of NFBC 338 remained constant at approximately 1 x 10(9) CFU/g during 2 months of powder storage at 4 degrees C, while a decline in the level of survival of approximately 1 log (from 7.2 x 10(7) to 9.5 x 10(6) CFU/g) was observed for UCC 118 stored under the same conditions. However, survival of both Lactobacillus strains during powder storage was inversely related to the storage temperature. Our data demonstrate that spray drying may be a cost-effective way to produce large quantities of some probiotic cultures.     

Quantitative detection of probiotic Bifidobacterium strains in bacterial mixtures by using real-time PCR

Strain-specific rRNA-targeted primers were designed for the quantitative detection of Bifidobacterium infantis Y1, B. breve Y8 and B. longum Y10 used in a pharmaceutical probiotic product (VSL-3). PCR and real-time PCR techniques with the selected primers were employed for the direct enumeration of the bifidobacteria in the probiotic preparation and for studying their kinetic characteristics in batch cultures. These analysis revealed that B. infantis Y1 was the predominant strain in the probiotic product and that its growth rate was the highest. Since B. infantis Y1, B. breve Y8 and B. longum Y10 are co-cultured during the industrial production of VSL-3, the kinetic characteristics of these strains can explain their different concentrations in the probiotic preparation. A validation of the PCR quantification method was performed by identifying a representative number of isolates from the bacterial mixtures with automated ribotyping. The methodology described represents a useful tool for the specific quantitative detection of bacterial strains and species in complex mixtures such as pharmaceutical preparations, dairy starter cultures, faecal samples and biopsies.     

A Statistical Approach to Optimize the Spray Drying of Starch Particles: Application to Dry Powder Coating

This article describes the preparation of starch particles, by spray drying, for possible application to a dry powder coating process. Dry powder coating consists of spraying a fine powder and a plasticizer on particles. The efficiency of the coating is linked to the powder morphological and dimensional characteristics. Different experimental parameters of the spray-drying process were analyzed, including type of solvent, starch concentration, rate of polymer feeding, pressure of the atomizing air, drying air flow, and temperature of drying air. An optimization and screening of the experimental parameters by a design of the experiment (DOE) approach have been done. Finally, the produced spray-dried starch particles were conveniently tested in a dry coating process, in comparison to the commercial initial starch. The obtained results, in terms of coating efficiency, demonstrated that the spray-dried particles led to a sharp increase of coating efficiency value.