Ethanolic fermentation of hydrolysates from ammonia fiber expansion (AFEX) treated corn stover and distillers grain without detoxification and external nutrient supplementation

External nutrient supplementation and detoxification of hydrolysate significantly increase the production cost of cellulosic ethanol. In this study, we investigated the feasibility of fermenting cellulosic hydrolysates without washing, detoxification or external nutrient supplementation using ethanologens Escherichia coli KO11 and the adapted strain ML01 at low initial cell density (16 mg dry weight/L). The cellulosic hydrolysates were derived from enzymatically digested ammonia fiber expansion (AFEX)-treated corn stover and dry distiller's grain and solubles (DDGS) at high solids loading (18% by weight). The adaptation was achieved through selective evolution of KO11 on hydrolysate from AFEX-treated corn stover. All cellulosic hydrolysates tested (36-52 g/L glucose) were fermentable. Regardless of strains, metabolic ethanol yields were near the theoretical limit (0.51 g ethanol/g consumed sugar). Volumetric ethanol productivity of 1.2 g/h/L was achieved in fermentation on DDGS hydrolysate and DDGS improved the fermentability of hydrolysate from corn stover. However, enzymatic hydrolysis and xylose utilization during fermentation were the bottlenecks for ethanol production from corn stover at these experimental conditions. In conclusion, fermentation under the baseline conditions was feasible. Utilization of nutrient-rich feedstocks such as DDGS in fermentation can replace expensive media supplementation.     

Efficient bioconversion of rice straw to ethanol with TiO2/UV pretreatment

Rice straw is a lignocellulosic biomass that constitutes a renewable organic substance and alternative source of energy; however, its structure confounds the liberation of monosaccharides. Pretreating rice straw using a TiO(2)/UV system facilitated its hydrolysis with Accellerase 1000(?), suggesting that hydroxyl radicals (OH·) from the TiO(2)/UV system could degrade lignin and carbohydrates. TiO(2)/UV pretreatment was an essential step for conversion of hemicellulose to xylose; optimal conditions for this conversion were a TiO(2) concentration of 0.1% (w/v) and an irradiation time of 2 h with a UV-C lamp at 254 nm. After enzymatic hydrolysis, the sugar yields from rice straw pretreated with these parameters were 59.8 ± 0.7% of the theoretical for glucose (339 ± 13 mg/g rice straw) and 50.3 ± 2.8% for xylose (64 ± 3 mg/g rice straw). The fermentation of enzymatic hydrolysates containing 10.5 g glucose/L and 3.2 g xylose/L with Pichia stipitis produced 3.9 g ethanol/L with a corresponding yield of 0.39 g/g rice straw. The maximum possible ethanol conversion rate is 76.47%. TiO(2)/UV pretreatment can be performed at room temperature and atmospheric pressure and demonstrates potential in large-scale production of fermentable sugars.     

Separate hydrolysis and fermentation (SHF) of Prosopis juliflora, a woody substrate, for the production of cellulosic ethanol by Saccharomyces cerevisiae and Pichia stipitis-NCIM 3498

Prosopis juliflora (Mesquite) is a raw material for long-term sustainable production of cellulosics ethanol. In this study, we used acid pretreatment, delignification and enzymatic hydrolysis to evaluate the pretreatment to produce more sugar, to be fermented to ethanol. Dilute H(2)SO(4) (3.0%,v/v) treatment resulted in hydrolysis of hemicelluloses from lignocellulosic complex to pentose sugars along with other byproducts such as furfural, hydroxymethyl furfural (HMF), phenolics and acetic acid. The acid pretreated substrate was delignified to the extent of 93.2% by the combined action of sodium sulphite (5.0%,w/v) and sodium chlorite (3.0%,w/v). The remaining cellulosic residue was enzymatically hydrolyzed in 0.05 M citrate phosphate buffer (pH 5.0) using 3.0 U of filter paper cellulase (FPase) and 9.0 U of beta-glucosidase per mL of citrate phosphate buffer. The maximum enzymatic saccharification of cellulosic material (82.8%) was achieved after 28 h incubation at 50 degrees C. The fermentation of both acid and enzymatic hydrolysates, containing 18.24 g/L and 37.47 g/L sugars, with Pichia stipitis and Saccharomyces cerevisiae produced 7.13 g/L and 18.52 g/L of ethanol with corresponding yield of 0.39 g/g and 0.49 g/g, respectively.     

Repression of xylose-specific enzymes by ethanol in Scheffersomyces (Pichia) stipitis and utility of repitching xylose-grown populations to eliminate diauxic lag

During the fermentation of lignocellulosic hydrolyzates to ethanol by native pentose-fermenting yeasts such as Scheffersomyces (Pichia) stipitis NRRL Y-7124 (CBS 5773) and Pachysolen tannophilus NRRL Y-2460, the switch from glucose to xylose uptake results in a diauxic lag unless process strategies to prevent this are applied. When yeast were grown on glucose and resuspended in mixed sugars, the length of this lag was observed to be a function of the glucose concentration consumed (and consequently, the ethanol concentration accumulated) prior to the switch from glucose to xylose fermentation. At glucose concentrations of 95 g/L, the switch to xylose utilization was severely stalled such that efficient xylose fermentation could not occur. Further investigation focused on the impact of ethanol on cellular xylose transport and the induction and maintenance of xylose reductase and xylitol dehydrogenase activities when large cell populations of S. stipitis NRRL Y-7124 were pre-grown on glucose or xylose and then presented mixtures of glucose and xylose for fermentation. Ethanol concentrations around 50 g/L fully repressed enzyme induction although xylose transport into the cells was observed to be occurring. Increasing degrees of repression were documented between 15 and 45 g/L ethanol. Repitched cell populations grown on xylose resulted in faster fermentation rates, particularly on xylose but also on glucose, and eliminated diauxic lag and stalling during mixed sugar conversion by P. tannophilus or S. stipitis, despite ethanol accumulations in the 60 or 70 g/L range, respectively. The process strategy of priming cells on xylose was key to the successful utilization of high mixed sugar concentrations because specific enzymes for xylose utilization could be induced before ethanol concentration accumulated to an inhibitory level.     

The expression of a Pichia stipitis xylose reductase mutant with higher K(M) for NADPH increases ethanol production from xylose in recombinant Saccharomyces cerevisiae

Xylose fermentation by Saccharomyces cerevisiae requires the introduction of a xylose pathway, either similar to that found in the natural xylose-utilizing yeasts Pichia stipitis and Candida shehatae or similar to the bacterial pathway. The use of NAD(P)H-dependent XR and NAD(+)-dependent XDH from P. stipitis creates a cofactor imbalance resulting in xylitol formation. The effect of replacing the native P. stipitis XR with a mutated XR with increased K(M) for NADPH was investigated for xylose fermentation to ethanol by recombinant S. cerevisiae strains. Enhanced ethanol yields accompanied by decreased xylitol yields were obtained in strains carrying the mutated XR. Flux analysis showed that strains harboring the mutated XR utilized a larger fraction of NADH for xylose reduction. The overproduction of the mutated XR resulted in an ethanol yield of 0.40 g per gram of sugar and a xylose consumption rate of 0.16 g per gram of biomass per hour in chemostat culture (0.06/h) with 10 g/L glucose and 10 g/L xylose as carbon source.     

A strain of <Emphasis Type="Italic">Meyerozyma guilliermondii</Emphasis> isolated from sugarcane juice is able to grow and ferment pentoses in synthetic and bagasse hydrolysate media

The search for new microbial strains that are able to withstand inhibitors released from hemicellulosic hydrolysis and are also still able to convert sugars in ethanol/xylitol is highly desirable. A yeast strain isolated from sugarcane juice and identified as Meyerozyma guilliermondii was evaluated for the ability to grow and ferment pentoses in synthetic media and in sugarcane bagasse hydrolysate. The yeast grew in xylose, arabinose and glucose at the same rate at an initial medium pH of 5.5. At pH 4.5, the yeast grew more slowly in arabinose. There was no sugar exhaustion within 60 h. At higher xylose concentrations with a higher initial cell concentration, sugar was exhausted within 96 h at pH 4.5. An increase of 350 % in biomass was obtained in detoxified hydrolysates, whereas supplementation with 3 g/L yeast extract increased biomass production by approximately 40 %. Ethanol and xylitol were produced more significantly in supplemented hydrolysates regardless of detoxification. Xylose consumption was enhanced in supplemented hydrolysates and arabinose was consumed only when xylose and glucose were no longer available. Supplementation had a greater impact on ethanol yield and productivity than detoxification; however, the product yields obtained in the present study are still much lower when compared to other yeast species in bagasse hydrolysate. By the other hand, the fermentation of both xylose and arabinose and capability of withstanding inhibitors are important characteristics of the strain assayed.     

Evaluation of hardboard manufacturing process wastewater as a feedstream for ethanol production

Waste streams from the wood processing industry can serve as feedstream for ethanol production from biomass residues. Hardboard manufacturing process wastewater (HPW) was evaluated on the basis of monomeric sugar recovery and fermentability as a novel feedstream for ethanol production. Dilute acid hydrolysis, coupled with concentration of the wastewater resulted in a hydrolysate with 66 g/l total fermentable sugars. As xylose accounted for 53 % of the total sugars, native xylose-fermenting yeasts were evaluated for their ability to produce ethanol from the hydrolysate. The strains selected were, in decreasing order by ethanol yields from xylose (Y _p/s, based on consumed sugars), Scheffersomyces stipitis ATCC 58785 (CBS 6054), Pachysolen tannophilus ATCC 60393, and Kluyveromyces marxianus ATCC 46537. The yeasts were compared on the basis of substrate utilization and ethanol yield during fermentations of the hydrolysate, measured using an HPLC. S. stipitis, P. tannophilus, and K. marxianus produced 0.34, 0.31, and 0.36 g/g, respectively. The yeasts were able to utilize between 58 and 75 % of the available substrate. S. stipitis outperformed the other yeast during the fermentation of the hydrolysate; consuming the highest concentration of available substrate and producing the highest ethanol concentration in 72 h. Due to its high sugar content and low inhibitor levels after hydrolysis, it was concluded that HPW is a suitable feedstream for ethanol production by S. stipitis.     

Combining chemical flocculation and bacterial co-culture of Cupriavidus taiwanensis and Ureibacillus thermosphaericus to detoxify a hardwood hemicelluloses hydrolysate and enable acetone–butanol–ethanol fermentation leading to butanol

Butanol, a fuel with better characteristics than ethanol, can be produced via acetone–butanol–ethanol (ABE) fermentation using lignocellulosic biomass as a carbon source. However, many inhibitors present in the hydrolysate limit the yield of the fermentation process. In this work, a detoxification technology combining flocculation and biodetoxification within a bacterial co-culture composed of Ureibacillus thermosphaericus and Cupriavidus taiwanensis is presented for the first time. Co-culture-based strategies to detoxify filtered and unfiltered hydrolysates have been investigated. The best results of detoxification were obtained for a two-step approach combining flocculation to biodetoxification. This sequential process led to a final phenolic compounds concentration of 1.4 g/L, a value close to the minimum inhibitory level observed for flocculated hydrolysate (1.1 g/L). The generated hydrolysate was then fermented with Clostridium acetobutylicum ATCC 824 for 120 h. A final butanol production of 8 g/L was obtained, although the detoxified hydrolysate was diluted to reach 0.3 g/L of phenolics to ensure noninhibitory conditions. © 2018 American Institute of Chemical Engineers Biotechnol. Prog., 35: e2753, 2019.     

Overcoming inhibitors in a hemicellulosic hydrolysate: improving fermentability by feedstock detoxification and adaptation of <Emphasis Type="Italic">Pichia stipitis</Emphasis>

In order to improve the fermentative efficiency of sugar maple hemicellulosic hydrolysates for fuel ethanol production, various methods to mitigate the effects of inhibitory compounds were employed. These methods included detoxification treatments utilizing activated charcoal, anion exchange resin, overliming, and ethyl acetate extraction. Results demonstrated the greatest fermentative improvement of 50% wood hydrolysate (v/v) by Pichia stipitis with activated charcoal treatment. Another method employed to reduce inhibition was an adaptation procedure to produce P. stipitis stains more tolerant of inhibitory compounds. This adaptation resulted in yeast variants capable of improved fermentation of 75% untreated wood hydrolysate (v/v), one of which produced 9.8 g/l ± 0.6 ethanol, whereas the parent strain produced 0.0 g/l ± 0.0 within the first 24 h. Adapted strains RS01, RS02, and RS03 were analyzed for glucose and xylose utilization and results demonstrated increased glucose and decreased xylose utilization rates in comparison to the wild type. These changes in carbohydrate utilization may be indicative of detoxification or tolerance activities related to proteins involved in glucose and xylose metabolism.     

树干毕赤酵母NLP31发酵产乙醇的研究

研究了树干毕赤酵母NLP31在木糖质量浓度为45 g/L的3种发酵培养基Ⅰ、Ⅱ和Ⅲ上发酵3轮的发酵性能以及在45 g/L木糖或混合糖(葡萄糖30 g/L,木糖15 g/L)的发酵培养基Ⅲ上的代谢历程。结果表明:树干毕赤酵母NLP31在发酵培养基Ⅲ上,乙醇浓度和乙醇得率均达到最高,分别为(17.29±0.15)g/L和(84.65±0.58)%。在45 g/L木糖或混合糖(葡萄糖30 g/L,木糖15 g/L)的发酵培养基Ⅲ上的代谢历程表明:混合糖发酵达到最大乙醇得率的时间仅为12 h,要比单一木糖发酵缩短了8 h。树干毕赤酵母NLP31在以廉价的无机N源为发酵培养基上的乙醇发酵性能高,能够降低燃料乙醇的生产成本。     

Culture nutrition and physiology impact the inhibitor tolerance of the yeast Pichia stipitis NRRL Y-7124

Pichia stipitis NRRL Y-7124 is one of the natural yeasts best able to utilize biomass because it is able to ferment hexoses and the pentose, xylose, to economically recoverable concentrations of ethanol. To test the impact of culture conditions on inhibitor tolerance, inhibitors were spiked to growing or stationary-phase P. stipitis supplied either glucose or xylose and varying nitrogen and mineral compositions; then the ensuing specific death rate response was measured. Resistance of glucose- or xylose-grown cells to inhibitors was generally greater in stationary-phase cells than log-phase cells, despite a greater exposure of stationary cells to ethanol. Consistent with this, the specific productivity of detoxification products, furan methanol or furan-2,5-dimethanol, from respective spikes of furfural or HMF increased as cultures progressed into stationary phase. However, when xylose was the substrate, ethanol resistance behaved uniquely and was greater for log- than stationary-phase cells. Amino acid enrichment of the growth medium significantly enhanced ethanol tolerance if xylose was the carbon source, but had no impact if glucose supplied carbon. Regardless of the carbon source, amino acid enrichment of the culture medium enhanced the ability of cells to resist furfural and HMF exposure. Mineral compositions tested had little impact on inhibitor resistance except stationary-phase xylose-grown cells were more susceptible to inhibitor exposure when magnesium sulfate was excessive. Observed tolerance optimization based on specific death rate as a function of culture physiological state, carbon source, nitrogen source and mineral composition provides new knowledge supporting process designs to convert biomass to ethanol using P. stipitis.     

Detoxification of corn stover prehydrolyzate by trialkylamine extraction to improve the ethanol production with Pichia stipitis CBS 5776

In order to realize the separated ethanol fermentation of glucose and xylose, prehydrolysis of corn stover with sulfuric acid at moderate temperature was applied, while inhibitors were produced inevitably. A complex extraction was adopted to detoxify the prehydrolyzate before fermentation to ethanol with Pichia stipitis CBS 5776. The best proportion of mixed extractant was 30% trialkylamine-50% n-octanol -20% kerosene. Detoxification results indicated that 73.3% of acetic acid, 45.7% of 5-hydroxymethylfurfural and 100% of furfural could be removed. Compared with the undetoxified prehydrolyzate, the fermentability of the detoxified prehydrolyzate was significantly improved. After 48 h fermentation of the detoxified prehydrolyzate containing 7.80 g/l of glucose and 52.8 g/l of xylose, the sugar utilization ratio was 93.2%; the ethanol concentration reached its peak value of 21.8 g/l, which was corresponding to 82.3% of the theoretical value.     

Kinetics of ethanol production by recombinant Escherichia coli KO11

The fermentation kinetics for separate as well as simultaneous glucose and xylose fermentation with recombinant ethanologenic Escherichia coli KO11 are presented. Glucose and xylose were consumed simultaneously and exhibited mutual inhibition. The glucose exhibited 15 times stronger inhibition in xyclose fermentation than vice versa. The fermentation of condensate from steampretreated willow (Salix) was investigated. The kinetics were studied in detoxified as well as in nondetoxified condensate. The fermentation of the condensate followed two phases: First the glucose and some of the pentoses (xylose in addition to small amounts of arabinose) were fermented simultaneously, and then the remaining part of the pentoses were fermented. The rate of the first phase was independent of the detoxification method used, whereas the rate of the second phase was found to be strongly dependent. When the condensate was detoxified with overliming in combination with sulfite, which was the best detoxification method investigated, the sugars in the condensate, 9 g/L, were fermented in 11 h. The same fermentation took 150 h in nondetoxified condensate. The experimental data were used to develop an empirical model, describing the batch fermentation of recombinant E. coli KO11 in the condensate. The model is based on Monod kinetics including substrate and product inhibition and the sum of the inhibition exerted by the rest of the inhibitors, lumped together. (c) 1995 John Wiley & Sons, Inc.     

Comparison of glucose/xylose cofermentation of poplar hydrolysates processed by different pretreatment technologies

The inhibitory effects of furfural and acetic acid on the fermentation of xylose and glucose to ethanol in YEPDX medium by a recombinant Saccharomyces cerevisiae strain (LNH‐ST 424A) were investigated. Initial furfural concentrations below 5 g/L caused negligible inhibition to glucose and xylose consumption rates in batch fermentations with high inoculum (4.5–6.0 g/L). At higher initial furfural concentrations (10–15 g/L) the inhibition became significant with xylose consumption rates especially affected. Interactive inhibition between acetic acid and pH were observed and quantified, and the results suggested the importance of conditioning the pH of hydrolysates for optimal fermentation performance. Poplar biomass pretreated by various CAFI processes (dilute acid, AFEX, ARP, SO₂‐catalyzed steam explosion, and controlled‐pH) under respective optimal conditions was enzymatically hydrolyzed, and the mixed sugar streams in the hydrolysates were fermented. The 5‐hydroxymethyl furfural (HMF) and furfural concentrations were low in all hydrolysates and did not pose negative effects on fermentation. Maximum ethanol productivity showed that 0–6.2 g/L initial acetic acid does not substantially affect the ethanol fermentation with proper pH adjustment, confirming the results from rich media fermentations with reagent grade sugars. © 2009 American Institute of Chemical Engineers Biotechnol. Prog., 2009     

Detoxification of a lignocellulosic biomass slurry by soluble polyelectrolyte adsorption for improved fermentation efficiency

This study investigated the detoxification of a dilute acid pretreated Ponderosa pine slurry using the polyelectrolyte polyethyleneimine (PEI). The addition of polyelectrolyte to remove enzymatic and/or fermentation inhibitory compounds, that is, acetic acid, furfural, and 5-hydroxymethylfurfural (HMF), was performed either before or after enzymatic hydrolysis to determine the optimal process sequence. Negligible acetic acid, glucose, and xylose were removed regardless of where in the process the polymer addition was made. Maximum furfural and HMF separation was achieved with the addition of PEI to a clarified pre-enzymatic hydrolysis liquor, which showed that 88.3% of furfural and 66.4% of HMF could be removed. On the other hand, only 23.1% and 13.4% of furfural and HMF, respectively, were removed from a post-enzymatic hydrolysis sample; thus, the effects of enzymes, glucose, and wood solids on inhibitor removal were also investigated. The presence of solid particles >0.2 μm and unknown soluble components <10 kDa reduced inhibitory compound removal, but the presence of elevated glucose levels and enzymes (cellulases) did not affect the separation. The fermentability of detoxified versus undetoxified hydrolysate was also investigated. An ethanol yield of 92.6% of theoretical was achieved with Saccharomyces cerevisiae fermenting the detoxified hydrolyzate, while no significant ethanol was produced in the undetoxified hydrolyzate. These results indicate that PEI may provide a practical alternative for furan removal and detoxification of lignocellolosic hydrolysates, and that application before enzymatic hydrolysis minimizes separation interferences.     

Detoxification requirements for bioconversion of softwood dilute acid hydrolyzates to succinic acid

In this work an Escherichia coli metabolically engineered to ferment lignocellulosic biomass sugars to succinic acid was tested for growth and fermentation of detoxified softwood dilute sulfuric acid hydrolyzates, and the minimum detoxification requirements were investigated with activated carbon and/or overliming treatments. Detoxified hydrolyzates supported fast growth and complete fermentation of all hydrolyzate sugars to succinate at yields comparable to pure sugar, while untreated hydrolyzates were unable to support either growth or fermentation. Activated carbon treatment was able to remove significantly more HMF and phenolics than overliming. However, in some cases, overliming treatment was capable of generating a fermentable hydrolyzate where activated carbon treatment was not. The implications of this are that in addition to the known organic inhibitors, the changes in the inorganic content and/or composition due to overliming are significant to the hydrolyzate toxicity. It was also found that any HMF remaining after detoxification was completely metabolized during aerobic cell growth on the hydrolyzates that were capable of supporting growth.     

Adaptation of Candida shehatae and Pichia stipitis to wood hydrolysates for increased ethanol production

Summary Candida shehatae ATCC 22984 and Pichia stipitis CBS 5776 were tested for ethanol production from xylose, glucose-xylose mixtures, and aspen wood total hydrolysates. Adaptation of these yeasts to wood hydrolysate solutions by recycling resulted in improved substrate utilization and ethanol production. Compared to the non-adapted cultures, recycled C. shehatae and P. stipitis in aspen hydrolysate increased g ethanol/g sugar consumed from 0.39 and 0.41 to 0.45 and 0.47; while ethanol production from a 70:30 glucose-xylose solution (total sugars 140 g/L) was 45 g/L in 24 h and 60 g/L in 72 h with the adapted yeasts compared to 15 g/L and 28 g/L in the same times with the parent strains.     

Effect of nutrient supplementation of crude or detoxified concentrated distilled grape marc hemicellulosic hydrolysates on the xylitol production by Debaryomyces hansenii

Biosynthesis of xylitol using the yeast Debaryomyces hansenii NRRL Y-7426 was carried out using distilled grape marc (DGM) hemicellulosic hydrolysates directly concentrated by vacuum evaporation or after detoxification with activated charcoal. The effect of nutrient supplementation with vinasses, corn steep liquor (CSL) or commercial nutrients was explored. Using crude concentrated hemicellulosic hydrolysates, the maximum xylitol concentration, 11.3?g/L, was achieved after 172?hr (Q ( xylitol )?=?0.066?g/L-hr; Y ( xylitol ) (/SC)?=?0.21?g/g); meanwhile, using detoxified concentrated hydrolysates, the concentration increased up to 19.7?g/L after 72?hr (Q ( xylitol )?=?0.274?g/L-hr; Y ( xylitol ) (/SC)?=?0.38?g/g). On the other hand, using crude or detoxified hydrolysates, the xylose-to-xylitol bioconversion was strongly affected by the addition of nutrients, suggesting that these hydrolysates present essential nutrients favouring the growth of D. hansenii.     

Response surface optimization of oxalic acid pretreatment of yellow poplar (Liriodendron tulipifera) for production of glucose and xylose monosaccarides

The primary goal of this study was to determine the optimal condition to obtain fermentable monosaccharides (xylose and glucose) from hydrolysates of yellow poplar (Liriodendron tulipifera) by oxalic acid pretreatment as a potential bio-ethanol source. Based on 2(3) factorial design, fifteen operations were performed by varying on acid loading, reaction time and temperature, and the components of the solid and liquid fractions were analyzed. The sugar concentration (g/L) in hydrolysates and xylose solubilization (%) were applied to response surface methodology. The optimal condition for producing sugars was 151 °C, 0.042 g/g (weight of oxalic acid/dry matter), 13 min with predicted yield of 37.4 g/L, and for the xylose solubilization was 158 °C, 0.037 g/g, 13 min yielding 72.0% of the predicted value. Severe conditions generated inhibitors. By measuring the concentrations, the possibility utilizing hydrolysates for fermentation were estimated.     

Effect of inhibitors formed during wheat straw pretreatment on ethanol fermentation by Pichia stipitis

The inhibitory effect of the main inhibitors (acetic acid, furfural and 5-hydroxymethylfurfural) formed during steam explosion of wheat straw was studied through ethanol fermentations of model substrates and hydrolysates from wheat straw by Pichia stipitis. Experimental results showed that an increase in acetic acid concentration led to a reduction in ethanol productivity and complete inhibition was observed at 3.5 g/L. Furfural produced a delay on sugar consumption rates with increasing concentration and HMF did not exert a significant effect. Fermentations of the whole slurry from steam exploded wheat straw were completely inhibited by a synergistic effect due to the presence of 1.5 g/L acetic acid, 0.15 g/L furfural and 0.05 g/L HMF together with solid fraction. When using only the solid fraction from steam explosion, hydrolysates presented 0.5 g/L of acetic acid, whose fermentations have submitted promising results, providing an ethanol yield of 0.45 g ethanol/g sugars and the final ethanol concentration reached was 12.2 g/L (10.9 g ethanol/100 g DM).