Cobalt-substituted Fe-type nitrile hydratase of Rhodococcus sp. N-771

When the genes encoding alpha and beta subunits of Fe-type nitrile hydratase (NHase) from Rhodococcus sp. N-771 were expressed in Escherichia coli in Co-supplemented medium without co-expression of the NHase activator, the NHase specifically incorporated not Fe but Co ion into the catalytic center. The produced Co-substituted enzyme exhibited rather weak NHase activity, initially. However, the activity gradually increased by the incubation with an oxidizing agent, potassium hexacyanoferrate. The oxidizing agent is likely to activate the Co-substituent by oxidizing the Co atom to a low-spin Co(3+) state and/or modification of alphaCys-112 to a cysteine-sulfinic acid. It is suggested that the NHase activator not only supports the insertion of an Fe ion into the NHase protein but also activates the enzyme via the oxidation of its iron center.     

Methods for increasing nitrile biotransformation into amides using Mesorhizobium sp.

Nitriles are potential soil pollutants from industrial wastewater. There has been increased demand for an efficient process for the nitrile degradation process. Nitrile hydratase (NHase) has been extensively used in the production of acrylamide and treatment of organocyanide-contaminated industrial effluents. The NHase of Mesorhizobium sp., isolated from polyacrylonitrile (PAN) activated sludge from fiber manufacturing wastewater treatment systems was studied in the whole bacterial cells. Different chemicals were added to observe the variation in the percentage of acrylonitrile converted into acrylamide. The result indicated that cobalt ions were the NHase cofactor and could increase the NHase activity. The addition of propionaldehyde, or butyraldehyde, could enhance the acrylonitrile conversion rate. Therefore, acrylamide could be accumulated effectively and the percentage of acrylonitrile converted into acrylamide increased. Propionaldehyde was the most effective NHase activator. The percentage of acrylonitrile converted into acrylamide was nearly 100% at 3.8 h when propionaldehyde was added at about 207.4 mg/l. The addition of benzaldehyde was unable to increase the percentage of acrylonitrile converted into acrylamide. EDTA and acrylamide showed no effect on NHase activity. However, 0.1 mg/l of Ag₂SO₄ would slightly inhibit NHase activity, producing an acrylonitrile conversion rate of 492.9 mg/l with 54.9% converted at 29.1 h. The ability of the acrylonitrile biotransformation was completely inhibited if the Ag₂SO₄ concentration was above 0.5 mg/l. Published in Russian in Prikladnaya Biokhimiya i Mikrobiologiya, 2008, Vol. 44, No. 3, pp. 304–307. The text was submitted in English.     

产腈水合酶菌Nocardia sp.HD9611的发酵条件优化的研究

探讨了种龄、接种量、搅拌转速、pH及补料等因素对Nocardia sp.HD9611产腈水合酶的影响.结果表明,最佳种龄为20h;接种量对酶活的提高没有明显影响,但7.5%时最佳;当搅拌转速低于400r/min时,溶解氧将成为细胞生长的限制因子;发酵过程中pH调节对细胞量及酶活的提高有积极的作用;补料对细胞密度及酶的产生有积极影响,总糖为80g/L时,细胞量31.88g/L,提高了120.8%,酶活为7100U,提高了107.6%.此研究为制定最佳控制策略提供了参考.     

Crystallization of a photosensitive nitrile hydratase from Rhodococcus sp. N-771.

A photosensitive nitrile hydratase from Rhodococcus sp. N-771 has been crystallized in two different crystal forms in its inactive form. One crystal form belongs to an orthorhombic space group P2(1)2(1)2 with unit cell dimensions of a = 117.4 A, b = 145.7 A and c = 52.1 A, and the other form belongs to a hexagonal space group P6(3)22 with unit cell dimensions of a = 110.2 A and c = 412.1 A.     

Methods for increasing nitrile biotransformation into amides using Mesorhizobium sp

Nitriles are potential soil pollutants from industrial wastewater. There has been increased demand for efficient process for nitrile degradation process. Nitrile hydratase (NHase) has been extensively used in the production of acrylamide and treatment of organocyanide contaminated industrial effluents. The NHase of Mesorhizobium sp., isolated from polyacrylonitrile activated sludge from fiber manufacturing wastewater treatment systems was studied in the whole bacterial cells. Different chemicals were added to observe the variation in the percentage of acrylonitrile converted into acrylamide. The result indicated that cobalt ions were the NHase cofactor and could increase the NHase activity. The addition of propionaldehyde, or butyraldehyde could enhance the acrylonitrile conversion rate. Therefore, acrylamide could be accumulated effectively and the percentage of acrylonitrile converted into acrylamide increased. Propionaldehyde was the most effective NHase activator. The percentage of acrylonitrile converted into acrylamide was nearly 100% at 3.8 h when propionaldehyde was added at about 207.4 mg/l. The addition of benzaldehyde was unable to increase the percentage of acrylonitrile converted into acrylamide. EDTA and acrylamide showed no effect on NHase activity. However, 0.1 mg/l of Ag2SO4 would slightly inhibit NHase activity, producing an acrylonitrile conversion rate of 492.9 mg/l with 54.9% converted at 29.1 h. The ability of the acrylonitrile biotransformation was completely inhibited if the Ag2SO4 concentration was above 0.5 mg/l.     

Purification and characterization of the enantioselective nitrile hydratase from Rhodococcus sp. AJ270

Nitrile hydratase (NHase, EC 4.2.1.84) from Rhodococcus sp. AJ270 was purified with 23.96% yield after sonication, ammonium sulfate fractionation, ion exchange, hydrophobic and gel-filtration column chromatography. The enzyme showed intriguing characteristics: it hydrated not only aliphatic and heterocyclic nitriles but also aromatic ones. Some substrates were also hydrated enantioselectively to the corresponding amides. The enantiomeric excess (ee) value of the enzyme hydrating trans-2,2-dimethyl-3-phenylcyclopropanecarbonitrile was 84.7. The enzyme is composed of two subunits: an alpha subunit and beta subunit of 22 975 Da and 23 493 Da, respectively. The optimal temperature and pH for the catalytic reaction of the enzyme was 25 degrees C and pH 7.6. The enzyme activity of the purified NHase was strongly inhibited by some oxidizing agents and heavy metals.     

诺卡氏菌腈水合酶基因在重组毕赤酵母中的表达

为从基因水平上改造腈水合酶,进行了诺卡氏菌腈水合酶基因的外源表达研究。在重组大肠杆菌表达系统内,腈水合酶的α亚基几乎不能正常表达,在重组E. coli BL21(DE3) (pET32aNHBAX)中,腈水合酶活性仅为0.04U/mg。构建重组毕赤酵母表达质粒pPIC3.5kNHBAX,采用电穿孔转化法将其转入宿主菌P. pastoris GS115中,经过菌株培养和腈水合酶的诱导表达,筛选获得了优选菌株P. pastoris NH4。对P. pastoris NH4的细胞培养和腈水合酶的诱导表达条件进行优化,结果表明,重组腈水合酶在毕赤酵母中的表达水平可以达到0.52U/mg,但不能稳定积累。     

Crystal structure of cobalt-containing nitrile hydratase.

The crystal structure of cobalt-containing nitrile hydratase from Pseudonocardia thermophila JCM 3095 at 1.8 A resolution revealed the structure of the noncorrin cobalt at the catalytic center. Two cysteine residues (alphaCys(111) and alphaCys(113)) coordinated to the cobalt were posttranslationally modified to cysteine-sulfinic acid and to cysteine-sulfenic acid, respectively, like in iron-containing nitrile hydratase. A tryptophan residue (betaTrp(72)), which may be involved in substrate binding, replaced the tyrosine residue of iron-containing nitrile hydratase. The difference seems to be responsible for the preference for aromatic nitriles rather than aliphatic ones of cobalt-containing nitrile hydratase.     

Mutational study on alphaGln90 of Fe-type nitrile hydratase from Rhodococcus sp. N771

Nitrile hydratase (NHase) from Rhodococcus sp. N771 is a non-heme iron enzyme having post-translationally modified cysteine ligands, alphaCys112-SO2H and alphaCys114-SOH. We replaced alphaGln90, which is conserved in all known NHases and involved in the hydrogen-bond network around the catalytic center, with glutamic acid or asparagine. The kcat of alphaQ90E and alphaQ90N mutants decreased to 24% and 5% that of wild type respectively, but the effect of mutations on Km was not very significant. In both mutants, the alphaCys114-SOH modification appeared to be responsible for the catalysis as in native NHase. We crystallized the nitrosylated alphaQ90N mutant and determined its structure at a resolution of 1.43 A. The structure was basically identical to that of native nitrosylated NHase except for the mutated site and its vicinity. The structural difference between native and alphaQ90N mutant NHases suggested the importance of the hydrogen bond networks between alphaGln90 and the iron center for the catalytic activity.     

Fed-batch fermentation for production of nitrile hydratase byRhodococcus rhodochrous M33

To enhance the productivity and activity of nitrile hydratase inRhodococcus rhodochrous M33, a glucose-limited fed-batch culture was performed. In a fed-batch culture where the glucose was controlled at a limited level and cobalt was supplemented during the fermentation period, the cell mass and total activity of nitrile hydratase both increased 3.3-fold compared to that in the batch fermentation. The productivity of nitrile hydratase also increased 1.9-fold compared to that in the batch fermentation. The specific activity of nitrile hydratase in the whole cell preparation when using a fed-batch culture was 120 units/mg-DCW, which was similar to that in the batch culture.     

Enzymatic production of 2-amino-2,3-dimethylbutyramide by cyanide-resistant nitrile hydratase

A novel enzymatic route for the synthesis of 2-amino-2,3-dimethylbutyramide (ADBA), important intermediate of highly potent and broad-spectrum imidazolinone herbicides, from 2-amino-2,3-dimethylbutyronitrile (ADBN) was developed. Strain Rhodococcus boritolerans CCTCC M 208108 harboring nitrile hydratase (NHase) towards ADBN was screened through a sophisticated colorimetric screening method and was found to be resistant to cyanide (5 mM). Resting cells of R. boritolerans CCTCC M 208108 also proved to be tolerant against high product concentration (40 g l⁻¹) and alkaline pH (pH 9.3). A preparative scale process for continuous production of ADBA in both aqueous and biphasic systems was developed and some key parameters of the biocatalytic process were optimized. Inhibition of NHase by cyanide dissociated from ADBN was successfully overcome by temperature control (at 10°C). The product concentration, yield and catalyst productivity were further improved to 50 g l⁻¹, 91% and 6.3 g product/g catalyst using a 30/70 (v/v) n-hexane/water biphasic system. Furthermore, cells of R. boritolerans CCTCC M 208108 could be reused for at lease twice by stopping the continuous reaction before cyanide concentration rose to 2 mM, with the catalyst productivity increasing to 12.3 g product/g catalyst. These results demonstrated that enzymatic synthesis of ADBA using whole cells of R. boritolerans CCTCC M 208108 showed potential for industrial application.     

Purification of inactivated photoresponsive nitrile hydratase

Photoresponsive nitrile hydratase from Rhodococcus sp. N-771 was purified in its inactivated form. The enzyme had a molecular weight of approximately 60 kDa and consisted of 2 subunits each having molecular weight of 27.5 and 28 kDa. The enzyme also contained 2 iron atoms/enzyme as a cofactor. The enzyme was more stable in its inactivated form, rather than the activated during storage in the dark. The enzyme was most stable in the temperature region of 0-35 degrees C, and lost its activity above 40 degrees C. The enzyme was most stable in the pH region of 6-8. The optimum temperature and pH for the enzyme activity was 30 degrees C and 7.8, respectively. The enzyme showed wide substrate specificity, and most of the metal ions did not affect enzyme activity significantly. The absorption spectrum revealed the presence of some cofactor which changed form after photoirradiation.     

Cultural factors affecting biosurfactant production by Gordonia sp. BS29

Gordonia sp. BS29 is a hydrocarbon-degrading bacterium isolated from a site chronically contaminated by diesel. The strain produces extracellular bioemulsifiers, able to produce stable emulsions, and cell-bound glycolipid biosurfactants, able to reduce surface tension. The aims of this work were to investigate the cultural factors affecting the production of the cell-bound biosurfactants by Gordonia sp. BS29 and to find the optimal composition of growth medium for the production. The cultural factors which have a significant influence on surfactant biosynthesis, identified by a two level 2^(8-2) Fractional Factorial Design, were the type and concentration of the carbon source, the concentrations of phosphates and sodium chloride, and the interactions among these factors. On these factors, a flask-scale optimisation of cultural conditions was carried out. Then, a steepest ascent procedure and a Central Composite Design were applied to obtain a second order polynomial function fitting the experimental data near the optimum. In the optimised cultural condition we obtained a 5-fold increase in the biosurfactant concentration compared to the un-optimised medium (26.00), reaching a Critical Micelle Dilution value (129.43) among the highest in literature. The optimisation procedure did not change the number and type of the glycolipid biosurfactants produced by Gordonia sp. BS29.     

Cloning and expression of the nitrile hydratase and amidase genes from Bacillus sp. BR449 into Escherichia coli

A moderate thermophile, Bacillus sp. BR449 was previously shown to exhibit a high level of nitrile hydratase (NHase) activity when growing on high levels of acrylonitrile at 55 degrees C. In this report, we describe the cloning of a 6.1 kb SalI DNA fragment encoding the NHase gene cluster of BR449 into Escherichia coli. Nucleotide sequencing revealed six ORFs encoding (in order), two unidentified putative proteins, amidase, NHase beta- and alpha-subunits and a small putative protein of 101 amino acids designated P12K. Spacings and orientation of the coding regions as well as their gene expression in E. coli suggest that the beta-subunit, alpha-subunit, and P12K genes are co-transcribed. Analysis of deduced amino acid sequences indicate that the amidase (348 aa, MW 38.6 kDa) belongs to the nitrilase-related aliphatic amidase family, and that the NHase beta- (229 aa, MW 26.5 kDa) and alpha- (214 aa, MW 24.5 kDa) subunits comprise a cobalt-containing member of the NHase family, which includes Rhodococcus rhodochrous J1 and Pseudomonas putida 5B NHases. The amidase/NHase gene cluster differs both in arrangement and composition from those described for other NHase-producing strains. When expressed in Escherichia coli DH5alpha, the subcloned NHase genes produced significant levels of active NHase enzyme when cobalt ion was added either to the culture medium or cell extracts. Presence of the P12K gene and addition of amide compounds as inducers were not required for this expression.     

Stability study on the nitrile hydratase of Nocardia sp. 108: From resting cells to crude enzyme preparation

In recent years nitrile hydratases (NHases) have drawn increasing attention due to their critical roles in organic synthesis. In the present paper an extensive investigation on the stability and activity of NHase from Nocardia sp. 108, which has succeeded in industrial application in China, was conducted by bioconversion of acrylonitrile to acrylamide in a batch manner. A study of cultivation demonstrated that biosynthesis of NHase changed significantly with the time of the culture, and the optimal NHase biosynthesis phase was 45 h after inoculation with NHase activity of a biomass of 1209.8 U/g. A stability study indicated that both crude enzyme preparations exhibited a good stability when exposed to a pH 7.2 tris-HCl buffer at 4°C for 4 h. The text was submitted by the authors in English.     

Stability study on the nitrile hydratase of Nocardia sp. 108: from resting cell to crude enzyme preparation

In recent years, nitrile hydratases (NHases) have drawn increasing attentions due to their critical roles in organic synthesis. In present paper, extensive investigation on the stability and activity of the NHase from Nocardia sp. 108, which is succeed in the industrial application in China, were conducted by the bioconversion of acrylonitrile to acrylamide in a batch manner. Cultivation study demonstrated that biosynthesis of NHase changed significantly with culture time, and the optimal NHase biosynthesis phase was 45 h after inoculation with NHase activity of 1209.8 U/g of biomass. Stability study indicated that crude enzyme preparation both exhibit a good stability when exposed to the pH 7.2 tris-HCl buffer at 4 degrees C for 4 h.     

Effects of nitriles and amides on the growth and the nitrile hydratase activity of the Rhodococcus sp. strain gt1

Effects of some nitriles and amides, as well as glucose and ammonium, on the growth and the nitrile hydratase (EC 4.2.1.84) activity of the Rhodococcus sp. strain gt1 isolated from soil were studied. The activity of nitrile hydratase mainly depended on carbon and nitrogen supply to cells. The activity of nitrile hydratase was high in the presence of glucose and ammonium at medium concentrations and decreased at concentrations of glucose more than 0.3%. Saturated unsubstituted aliphatic nitriles and amides were found to be a good source of nitrogen and carbon. However, the presence of nitriles and amides in the medium was not absolutely necessary for the expression of the activity of nitrile hydratase isolated from the Rhodococcus sp. strain gt1.     

Optimum culture conditions for the production of cobalt-containing nitrile hydratase by Rhodococcus rhodochrous J1

Summary We sought the optimum conditions for production of nitrile hydratase by Rhodococcus rhodochrous J1. The addiiion of both cobalt ions and an aliphatic nitrile or amide as an inducer was indispensable for the appearance of nitrile hydratase activity in R. rhodochrous J1 cells. Crotonamide was an efficient inducer and, moreover, urea was found to be the most powerful inducer for the production of nitrile hydratase. When R. rhodochrous J1 was cultivated under optimal conditions, the enzyme activity in the culture broth and the specific activity was approximately 32,000 and 512 times higher than the initially obtained levels, respectively. The nitrile hydratase formed corresponded to more than 45% of the total soluble protein in urea-induced cells, as judged by quantitative evaluation of the gel track.Offprint requests to: T. Nagasawa