在乳酸乳球菌中表达外源谷氨酰胺转胺酶显著改善宿主菌好氧生长性能

为改善乳酸乳球菌的生长性能,以轮枝链霉菌染色体DNA为模板,扩增得到编码谷氨酰胺转胺酶成熟酶的基因mtg,将其克隆到质粒pNZ8148中,电转化乳酸乳球菌NZ9000,获得乳酸乳球菌NZ9000(pFL001)(重组菌)。在不控制pH条件下,重组菌的胞外pH显著高于对照菌NZ9000(pNZ8148);前者的最高生物量可达4.13gL,而后者只有0.34gL。在控制pH为6.5±0.1的条件下,重组菌最高生物量为4.73gL,对葡萄糖的菌体最高平均得率为71.1gmol,而相同条件下对照菌最高生物量为2.6gL,对葡萄糖的菌体最高平均得率为27.3gmol。由此表明,重组菌与对照菌相比,好氧生长性能得到显著改善。可能的原因是mtg的活性表达升高了重组菌的胞内pH,原先用于泵出胞内H 所需的部分能量可能因此得到节省,这样相应增加了用于细胞生长的能量。     

Heterologous Leaky Production of Transglutaminase in Lactococcus lactis Significantly Enhances the Growth Performance of the Host

This study describes a novel strategy to improve the growth performance of Lactococcus lactis by heterologous production of food-grade transglutaminase. The mtg gene from Streptoverticillium mobaraense that encodes the transglutaminase mature protein was cloned into a nisin-inducible expression vector and transformed into L. lactis subsp. cremoris NZ9000. The leaky expression of the mtg gene from the nisA promoter resulted in ammonia formation and carbon flux redistribution at the pyruvate branch. As a consequence, medium acidification was lessened and energy utilization was improved. This led to significantly higher biomass production under aerobic conditions and particularly under non-pH-controlled conditions (up to a 12-fold increase). The results presented here provide a novel way to enhance the growth yield of L. lactis, which is an important step for the purposes of producing proteins of commercial interest using L. lactis as a host.     

Application of a gratuitous induction system in Kluyveromyces lactis for the expression of intracellular and secreted proteins during fed-batch culture

A gratuitous induction system in the yeast Kluyveromyces lactis was evaluated for the expression of intracellular and extracellular products during fed-batch culture. The Escherichia coli lacZ gene (beta-galactosidase; intracellular) and MFalpha1 leader-BPTI cassette (bovine pancreatic trypsin inhibitor; extracellular) were placed under the control of the inducible K. lactis LAC4 promotor, inserted into partial-pKD1 plasmids, and transformed into a ga1-209 K. lactis strain. To obtain a high level of production, culture conditions for growth and expression were initially evaluated in tube cultures. A selective medium containing 5 g/L glucose (as carbon source) and 0.5 g/L galactose (as inducer) demonstrated the maximum activity of both beta-galactosidase and secreted BPTI. This level of expression had no significant effect on the growth of the recombinant cells; growth rate dropped by approximately 11%, whereas final biomass concentrations remained the same. In shake-flask culture, biomass concentration, beta-galactosidase activity, and BPTI secreted activity were 4 g/L, 7664 U/g dry cell, and 0.32 mg/L, respectively. Fed-batch culture (with a high glucose concentration and a low galactose [inducer] concentration feed) resulted in a 6.5-fold increase in biomass, a 23-fold increase in beta-galactosidase activity, and a 3-fold increase in BPTI secreted activity. The results demonstrate the success of gratuitous induction during high-cell-density fed-batch culture of K. lactis. A very low concentration of galactose feed was sufficient for a high production level.     

Expression of six peptidases from Lactobacillus helveticus in Lactococcus lactis

For development of novel starter strains with improved proteolytic properties, the ability of Lactococcus lactis to produce Lactobacillus helveticus aminopeptidase N (PepN), aminopeptidase C (PepC), X-prolyl dipeptidyl aminopeptidase (PepX), proline iminopeptidase (PepI), prolinase (PepR), and dipeptidase (PepD) was studied by introducing the genes encoding these enzymes into L. lactis MG1363 and its derivatives. According to Northern analyses and enzyme activity measurements, the L. helveticus aminopeptidase genes pepN, pepC, and pepX are expressed under the control of their own promoters in L. lactis. The highest expression level, using a low-copy-number vector, was obtained with the L. helveticus pepN gene, which resulted in a 25-fold increase in PepN activity compared to that of wild-type L. lactis. The L. helveticus pepI gene, residing as a third gene in an operon in its host, was expressed in L. lactis under the control of the L. helveticus pepX promoter. The genetic background of the L. lactis derivatives tested did not affect the expression level of any of the L. helveticus peptidases studied. However, the growth medium used affected both the recombinant peptidase profiles in transformant strains and the resident peptidase activities. The levels of expression of the L. helveticus pepD and pepR clones under the control of their own promoters were below the detection limit in L. lactis. However, substantial amounts of recombinant pepD and PepR activities were obtained in L. lactis when pepD and pepR were expressed under the control of the inducible lactococcal nisA promoter at an optimized nisin concentration.     

Metabolic engineering of Lactococcus lactis: influence of the overproduction of alpha-acetolactate synthase in strains deficient in lactate dehydrogenase as a function of culture conditions.

The als gene for alpha-acetolactate synthase of Lactococcus lactis MG1363 was cloned on a multicopy plasmid under the control of the inducible L. lactis lacA promoter. More than a hundredfold overproduction of alpha-acetolactate synthase was obtained in L. lactis under inducing conditions as compared with that of the host strain, which contained a single chromosomal copy of the als gene. The effect of alpha-acetolactate synthase overproduction on the formation of end products in various L. lactis strains was studied under different fermentation conditions. Under aerobic conditions and with an initial pH of 6.0, overexpression of the als gene resulted in significant acetoin production that amounted to more than one-third of the pyruvate converted. However, the effect of the alpha-acetolactate synthase overproduction was even more pronounced in the lactate dehydrogenase-deficient strain L. lactis NZ2700. Anaerobic cultivation of this strain resulted in a doubling of the butanediol formation of up to 40% of the converted pyruvate. When cultivated aerobically at an initial pH of 6.8, overexpression of the als gene in L. lactis NZ2700 resulted in the conversion of more than 60% of the pyruvate into acetoin, while no butanediol was formed. Moreover, at an initial pH of 6.0, similar amounts of acetoin were obtained, but in addition approximately 20% of the pyruvate was converted into butanediol. These metabolic engineering studies indicate that more than 80% of the lactose can be converted via the activity of the overproduced alpha-acetolactate synthase in L. lactis.     

The peptidyl-prolyl isomerase motif is lacking in PmpA,the PrsA-like protein involved in the secretion machinery of Lactococcus lactis

The prsA-like gene from Lactococcus lactis encoding its single homologue to PrsA, an essential protein triggering the folding of secreted proteins in Bacillus subtilis, was characterized. This gene, annotated pmpA, encodes a lipoprotein of 309 residues whose expression is increased 7- to 10-fold when the source of nitrogen is limited. A slight increase in the expression of the PrsA-like protein (PLP) in L. lactis removed the degradation products previously observed with the Staphylococcus hyicus lipase used as a model secreted protein. This shows that PmpA either triggers the folding of the secreted lipase or activates its degradation by the cell surface protease HtrA. Unlike the case for B. subtilis, the inactivation of the gene encoding PmpA reduced only slightly the growth rate of L. lactis in standard conditions. However, it almost stopped its growth when the lipase was overexpressed in the presence of salt in the medium. Like PrsA of B. subtilis and PrtM of L. lactis, the L. lactis PmpA protein could thus have a foldase activity that facilitates protein secretion. These proteins belong to the third family of peptidyl-prolyl cis/trans-isomerases (PPIases) for which parvulin is the prototype. Almost all PLP from gram-positive bacteria contain a domain with the PPIase signature. An exception to this situation was found only in Streptococcaceae, the family to which L. lactis belongs. PLP from Streptococcus pneumoniae and Enterococcus faecalis possess this signature, but those of L. lactis, Streptococcus pyogenes, and Streptococcus mutans do not. However, secondary structure predictions suggest that the folding of PLP is conserved over the entire length of the proteins, including the unconserved signature region. The activity associated with the expression of PmpA in L. lactis and these genomic data show that either the PPIase motif is not necessary for PPIase activity or, more likely, PmpA foldase activity does not necessarily require PPIase activity.     

Fine tuning of the lactate and diacetyl production through promoter engineering in Lactococcus lactis

Lactococcus lactis is a well-studied bacterium widely used in dairy fermentation and capable of producing metabolites with organoleptic and nutritional characteristics. For fine tuning of the distribution of glycolytic flux at the pyruvate branch from lactate to diacetyl and balancing the production of the two metabolites under aerobic conditions, a constitutive promoter library was constructed by randomizing the promoter sequence of the H(2)O-forming NADH oxidase gene in L. lactis. The library consisted of 30 promoters covering a wide range of activities from 7,000 to 380,000 relative fluorescence units using a green fluorescent protein as reporter. Eleven typical promoters of the library were selected for the constitutive expression of the H(2)O-forming NADH oxidase gene in L. lactis, and the NADH oxidase activity increased from 9.43 to 58.17-fold of the wild-type strain in small steps of activity change under aerobic conditions. Meanwhile, the lactate yield decreased from 21.15 ± 0.08 mM to 9.94 ± 0.07 mM, and the corresponding diacetyl production increased from 1.07 ± 0.03 mM to 4.16 ± 0.06 mM with the intracellular NADH/NAD(+) ratios varying from 0.711 ± 0.005 to 0.383 ± 0.003. The results indicated that the reduced pyruvate to lactate flux was rerouted to the diacetyl with an almost linear flux variation via altered NADH/NAD(+) ratios. Therefore, we provided a novel strategy to precisely control the pyruvate distribution for fine tuning of the lactate and diacetyl production through promoter engineering in L. lactis. Interestingly, the increased H(2)O-forming NADH oxidase activity led to 76.95% lower H(2)O(2) concentration in the recombinant strain than that of the wild-type strain after 24 h of aerated cultivation. The viable cells were significantly elevated by four orders of magnitude within 28 days of storage at 4°C, suggesting that the increased enzyme activity could eliminate H(2)O(2) accumulation and prolong cell survival.     

Heterologous complementation of the Klaac null mutation of Kluyveromyces lactis by the Saccharomyces cerevisiae AAC3 gene encoding the ADP/ATP carrier

The KlAAC gene, encoding the ADP/ATP carrier, has been assumed to be a single gene in Kluyveromyces lactis, an aerobic, petite-negative yeast species. The Klaac null mutation, which causes a respiratory-deficient phenotype, was fully complemented by AAC2, the Saccharomyces cerevisiae major gene for the ADP/ATP carrier and also by AAC1, a gene that is poorly expressed in S. cerevisiae. In this study, we demonstrate that the Klaac null mutation is partially complemented by the ScAAC3 gene, encoding the hypoxic ADP/ATP carrier isoform, whose expression in S. cerevisiae is prevented by oxygen. Once introduced into K. lactis, the AAC3 gene was expressed both under aerobic and under partial anaerobic conditions but did not support the growth of K. lactis under strict anaerobic conditions.     

Citrate Fermentation by Lactococcus and Leuconostoc spp

Citrate and lactose fermentation are subject to the same metabolic regulation. In both processes, pyruvate is the key intermediate. Lactococcus lactis subsp. lactis biovar diacetylactis homofermentatively converted pyruvate to lactate at high dilution (growth) rates, low pH, and high lactose concentrations. Mixed-acid fermentation with formate, ethanol, and acetate as products was observed under conditions of lactose limitation in continuous culture at pH values above 6.0. An acetoin/butanediol fermentation with alpha-acetolactate as an intermediate was found upon mild aeration in continuous culture and under conditions of excess pyruvate production from citrate. Leuconostoc spp. showed a limited metabolic flexibility. A typical heterofermentative conversion of lactose was observed under all conditions in both continuous and batch cultures. The pyruvate produced from either lactose or citrate was converted to d-lactate. Citrate utilization was pH dependent in both L. lactis and Leuconostoc spp., with maximum rates observed between pH 5.5 and 6.0. The maximum specific growth rate was slightly stimulated by citrate, in L. lactis and greatly stimulated by citrate in Leuconostoc spp., and the conversion of citrate resulted in increased growth yields on lactose for both L. lactis and Leuconostoc spp. This indicates that energy is conserved during the metabolism of citrate.     

Cloning and heterologous production of Hiracin JM79, a Sec-dependent bacteriocin produced by Enterococcus hirae DCH5, in lactic acid bacteria and Pichia pastoris

Hiracin JM79 (HirJM79), a Sec-dependent bacteriocin produced by Enterococcus hirae DCH5, was cloned and produced in Lactococcus lactis, Lactobacillus sakei, Enterococcus faecium, Enterococcus faecalis, and Pichia pastoris. For heterologous production of HirJM79 in lactic acid bacteria (LAB), the HirJM79 structural gene (hirJM79), with or without the HirJM79 immunity gene (hiriJM79), was cloned into the plasmid pMG36c under the control of the constitutive promoter P(32) and into the plasmid pNZ8048 under the control of the inducible P(NisA) promoter. For the production of HirJM79 in P. pastoris, the gene encoding the mature HirJM79 protein was cloned into the pPICZalphaA expression vector. The recombinant plasmids permitted the production of biologically active HirJM79 in the supernatants of L. lactis IL1403, L. lactis NZ9000, L. sakei Lb790, E. faecalis JH2-2, and P. pastoris X-33, the coproduction of HirJM79 and nisin A in L. lactis DPC5598, and the coproduction of HirJM79 and enterocin P in E. faecium L50/14-2. All recombinant LAB produced larger quantities of HirJM79 than E. hirae DCH5, although the antimicrobial activities of most transformants were lower than that predicted from their production of HirJM79. The synthesis, processing, and secretion of HirJM79 proceed efficiently in recombinant LAB strains and P. pastoris.     

Functional analysis of the Lactococcus lactis galU and galE genes and their impact on sugar nucleotide and exopolysaccharide biosynthesis.

We studied the UDP-glucose pyrophosphorylase (galU) and UDP-galactose epimerase (galE) genes of Lactococcus lactis MG1363 to investigate their involvement in biosynthesis of UDP-glucose and UDP-galactose, which are precursors of glucose- and galactose-containing exopolysaccharides (EPS) in L. lactis. The lactococcal galU gene was identified by a PCR approach using degenerate primers and was found by Northern blot analysis to be transcribed in a monocistronic RNA. The L. lactis galU gene could complement an Escherichia coli galU mutant, and overexpression of this gene in L. lactis under control of the inducible nisA promoter resulted in a 20-fold increase in GalU activity. Remarkably, this resulted in approximately eightfold increases in the levels of both UDP-glucose and UDP-galactose. This indicated that the endogenous GalE activity is not limiting and that the GalU activity level in wild-type cells controls the biosynthesis of intracellular UDP-glucose and UDP-galactose. The increased GalU activity did not significantly increase NIZO B40 EPS production. Disruption of the galE gene resulted in poor growth, undetectable intracellular levels of UDP-galactose, and elimination of EPS production in strain NIZO B40 when cells were grown in media with glucose as the sole carbon source. Addition of galactose restored wild-type growth in the galE disruption mutant, while the level of EPS production was approximately one-half the wild-type level.     

Mutational analysis of the Lactococcus lactis NIZO B40 exopolysaccharide (EPS) gene cluster: EPS biosynthesis correlates with unphosphorylated EpsB

AIMS: To determine the role of the EpsA, EpsB, and EpsC proteins encoded at the 5'-end of the exopolysaccharide (EPS) gene cluster in regulation of EPS production in Lactococcus lactis. METHODS AND RESULTS: Deletion and paralog-replacement mutants of epsABCD were used to determine the function of EpsA, EpsB and EpsC in EPS production and polymer chain length determination in L. lactis. EpsA and EpsB appeared to be essential for EPS biosynthesis in L. lactis, while deletion of the phosphatase (EpsC) only had a minor effect on the EPS production level. Determination of the phosphorylation state of EpsB and analysis of a C-terminally truncated EpsB variant indicate that EPS biosynthesis in L. lactis is driven by a nonphosphorylated form of EpsB. CONCLUSIONS: The data presented here show that in L. lactis, EPS production is under control of a phosphoregulatory system and that EPS biosynthesis correlates with an unphosphorylated EpsB. SIGNIFICANCE AND IMPACT OF THE STUDY: This study provides molecular understanding of polysaccharide production in L. lactis that could eventually enable novel approaches to control EPS production by lactic acid bacteria during industrial fermentation processes.     

Respiration Capacity of the Fermenting Bacterium Lactococcus lactis and Its Positive Effects on Growth and Survival

Oxygen is a major determinant of both survival and mortality of aerobic organisms. For the facultative anaerobe Lactococcus lactis, oxygen has negative effects on both growth and survival. We show here that oxygen can be beneficial to L. lactis if heme is present during aerated growth. The growth period is extended and long-term survival is markedly improved compared to results obtained under the usual fermentation conditions. We considered that improved growth and survival could be due to the capacity of L. lactis to undergo respiration. To test this idea, we confirmed that the metabolic behavior of lactococci in the presence of oxygen and hemin is consistent with respiration and is most pronounced late in growth. We then used a genetic approach to show the following. (i) The cydA gene, encoding cytochrome d oxidase, is required for respiration and plays a direct role in oxygen utilization. cydA expression is induced late in growth under respiration conditions. (ii) The hemZ gene, encoding ferrochelatase, which converts protoporphyrin IX to heme, is needed for respiration if the precursor, rather than the final heme product, is present in the medium. Surprisingly, survival improved by respiration is observed in a superoxide dismutase-deficient strain, a result which emphasizes the physiological differences between fermenting and respiring lactococci. These studies confirm respiratory metabolism in L. lactis and suggest that this organism may be better adapted to respiration than to traditional fermentative metabolism.     

The level of pyruvate-formate lyase controls the shift from homolactic to mixed-acid product formation in Lactococcus lactis

Regulation of pyruvate-formate lyase (PFL) activity in vivo plays a central role in the shift from homolactic to mixed-acid product formation observed during the growth of Lactococcus lactis on glucose and galactose, respectively. Characterisation of L. lactis MG1363 in anaerobic batch cultures showed that the specific in vivo activity (flux) of PFL was 4-fold higher in L. lactis cells grown with galactose, compared with cells grown with glucose. The change in the PFL flux correlated with the observed variation in the PFL enzyme level, i.e. the PFL enzyme level was 3.4-fold higher in L. lactis cells grown on galactose than in those grown on glucose. To investigate whether a variation in the level of PFL was responsible for the shift in pyruvate metabolism, L. lactis strains with altered expression of pfl were constructed. The pfl gene was expressed under the control of different constitutive promoters in L. lactis MG1363 and in the PFL-deficient strain CRM40. Strains with five different PFL levels were obtained. Variation in the PFL level markedly affected the resulting end-product formation in these strains. During growth on galactose, the flux towards mixed-acid products was to a great extent controlled by the PFL level. This demonstrates that a regulated PFL level plays a predominant role in the regulation of the metabolic shift from homolactic to mixed-acid product formation in L. lactis.     

The effects of osmotic stress on survival and alkaline phosphatase activity of Aeromonas hydrophila

Abstract Lactococcus lactis MG5267 is a plasmid-free strain in which the lactose operon is integrated in the bacterial chromosome. The chromosomal lac G gene which encodes phospho-β-galactosidase was inactivated by a double cross-over integration event. Unexpectedly, the resultant mutant was shown to retain a Lac-positive phenotype. The lysin gene from Listeria monocytogenes bacteriophage LM-4 was subsequently integrated into the chromosome of this strain such that expression of the heterologous gene was mediated by the lactose operon promoter. Expression of the lysin gene was shown to be regulated by growth on lactose. This represents an important strategy for the controlled and stabilised expression of biotechnologically useful genes in L lactis .     

The development of TnNuc and its use for the isolation of novel secretion signals in Lactococcus lactis

We have previously used Tn917 for the identification and characterization of regulated promoters from Lactococcus lactis [Israelsen et al., Appl. Environ. Microbiol. 61 (1995) 2540-2547]. We describe here the construction of a new Tn917-transposon derivative, termed TnNuc, which includes the Staphylococcus aureus nuclease gene (nuc) as a reporter for secretion. Transposition of TnNuc into the L. lactis chromosome allows the generation of fusions in-frame with the nuc gene. TnNuc includes also lacZ, a reporter used for identification of relevant clones from the library, i.e. clones with Lac+ phenotype result from transposition of TnNuc into a functional gene on the L. lactis chromosome. The presence of a functional signal sequence at the upstream flanking region of the left repeat of the transposed element results in the detection of nuclease activity using a sensitive plate assay. TnNuc was used for the identification of novel secretion signals from L. lactis. The sequences identified included known and unknown lactococcal-secreted proteins containing either a signal peptidase-I or -II recognition sequence. In one case, the gene identified codes for a transmembrane protein. The sequences identified were used to study functionality when located in a plasmid under the control of the pH and growth phase-dependent promoter P170 [Madsen et al., Mol. Microbiol. 32 (1999) 75-87]. In all cases, concurrent secretion of nuclease was observed during induction of P170 in a fermentor.