好氧和缺氧条件下游离亚硝酸对氨氧化菌和亚硝酸盐氧化菌的选择性抑制

【背景】稳定短程硝化是实现城市污水厌氧氨氧化技术的瓶颈,目前国内外关于游离亚硝酸(Free nitrous acid,FNA)对硝化菌活性的影响大多是在曝气条件下进行研究,鲜有关于缺氧条件下FNA对硝化菌活性影响的报道。【目的】探究好氧和缺氧下FNA对氨氧化菌(Ammonia oxidizing bacteria,AOB)和亚硝酸盐氧化菌(Nitrite oxidizing bacteria,NOB:Nitrospira和Nitrobacter)活性的抑制影响。【方法】采用序批式反应器(Sequencing batch reactor,SBR),基于混合液悬浮固体浓度(Mixed liquid suspended solids,MLSS)为8 300 mg/L的全程硝化污泥条件,通过批次试验分别考察好氧和缺氧下FNA(初始浓度为1.16 mg/L)处理48 h后,AOB和NOB活性的变化情况。【结果】好氧FNA处理活性污泥48 h后,FNA浓度维持在1.16-1.17 mg/L,游离氨(Free ammonia,FA)浓度小于0.017 mg/L,AOB、Nitrospira、Nitrobacter丰度均未发生明显变化;过曝气至99 h时,与空白组相比,比氨氮氧化速率(r~+_(NH4-N))、比亚硝酸盐氮氧化速率(r_(NO2-N))均出现小幅下降,分别由3.5、4.828 mg N/(g VSS·h)降至3.3、4.668 mg N/(g VSS·h),且亚硝酸盐氮累积率(Nitrite accumulation rate,NAR)始终低于33.2%。缺氧FNA处理活性污泥48 h后,FNA浓度维持在0.64-1.16 mg/L,FA浓度低于0.039 mg/L,AOB丰度变化较小,而Nitrospira、Nitrobacter丰度均明显下降,分别由3.002 9×10~9、4.245×10~8 copies/g VSS降至1.666 5×10~8、5.163 8×10~7 copies/g VSS;过曝气至99 h时,与空白组相比,r~+_(NH4-N)值下降幅度较小,而r_(NO2-N)值明显降低,由4.828 mg N/(g VSS·h)降至0.007 mg N/(g VSS·h),且在过曝气0-292 h内,NAR均大于94%。【结论】好氧FNA处理活性污泥48 h后对AOB和NOB无明显抑制作用,但缺氧FNA处理活性污泥48 h后对AOB具有轻微抑制作用,而对NOB具有强烈的抑制作用,可以实现稳定的短程硝化。     

Unravelling the reasons for disproportion in the ratio of AOB and NOB in aerobic granular sludge

In this study, we analysed the nitrifying microbial community (ammonium-oxidizing bacteria (AOB) and nitrite-oxidizing bacteria (NOB)) within three different aerobic granular sludge treatment systems as well as within one flocculent sludge system. Granular samples were taken from one pilot plant run on municipal wastewater as well as from two lab-scale reactors. Fluorescent in situ hybridization (FISH) and quantitative PCR (qPCR) showed that Nitrobacter was the dominant NOB in acetate-fed aerobic granules. In the conventional system, both Nitrospira and Nitrobacter were present in similar amounts. Remarkably, the NOB/AOB ratio in aerobic granular sludge was elevated but not in the conventional treatment plant suggesting that the growth of Nitrobacter within aerobic granular sludge, in particular, was partly uncoupled from the lithotrophic nitrite supply from AOB. This was supported by activity measurements which showed an approximately threefold higher nitrite oxidizing capacity than ammonium oxidizing capacity. Based on these findings, two hypotheses were considered: either Nitrobacter grew mixotrophically by acetate-dependent dissimilatory nitrate reduction (ping-pong effect) or a nitrite oxidation/nitrate reduction loop (nitrite loop) occurred in which denitrifiers reduced nitrate to nitrite supplying additional nitrite for the NOB apart from the AOB.     

泉州西湖沉积物中硝化细菌的分布及其作用

比较研究泉州西湖沉积物中氨氧化细菌(AOB)和亚硝酸盐氧化细菌(NOB)的分布及氨氧化潜力和亚硝酸盐(NO2?)氧化潜力。结果表明: 西湖沉积物中存在高浓度的有机质(OM)、总氮(TN)和氨氮。AOB生物量为1.1×106?6.4×106 个/g干土, 显著高于NOB生物量4.2×105?7.4×105 个/g 干土(配对t-检验, P<0.05)。对于NOB, 硝化杆菌属(Nitrobacter)和硝化螺菌属(Nitrospira)同时存在于西湖沉积物中, 以Nitrobacter为优势种群。AOB和NOB生物量的差异一定程度上导致西湖沉积物中氨氧化潜力显著高于NO2?氧化潜力(配对t-检验, P<0.05), NO2?氧化过程成为硝化作用的限制步骤。另外, 西湖沉积物中存在的较高浓度氨氮, 一方面促进了AOB的生长和活性, 导致较高速率的氨氧化过程, 另一方面却对亚硝酸盐氧化过程产生选择性抑制, 这也是导致NO2?氧化潜力较低的主要原因之一。     

Effects of aeration cycles on nitrifying bacterial populations and nitrogen removal in intermittently aerated reactors

The effects of the lengths of aeration and nonaeration periods on nitrogen removal and the nitrifying bacterial community structure were assessed in intermittently aerated (IA) reactors treating digested swine wastewater. Five IA reactors were operated in parallel with different aeration-to-nonaeration time ratios (ANA). Populations of ammonia-oxidizing bacteria (AOB) and nitrite-oxidizing bacteria (NOB) were monitored using 16S rRNA slot blot hybridizations. AOB species diversity was assessed using amoA gene denaturant gradient gel electrophoresis. Nitrosomonas and Nitrosococcus mobilis were the dominant AOB and Nitrospira spp. were the dominant NOB in all reactors, although Nitrosospira and Nitrobacter were also detected at lower levels. Reactors operated with the shortest aeration time (30 min) showed the highest Nitrosospira rRNA levels, and reactors operated with the longest anoxic periods (3 and 4 h) showed the lowest levels of Nitrobacter, compared to the other reactors. Nitrosomonas sp. strain Nm107 was detected in all reactors, regardless of the reactor's performance. Close relatives of Nitrosomonas europaea, Nitrosomonas sp. strain ENI-11, and Nitrosospira multiformis were occasionally detected in all reactors. Biomass fractions of AOB and effluent ammonia concentrations were not significantly different among the reactors. NOB were more sensitive than AOB to long nonaeration periods, as nitrite accumulation and lower total NOB rRNA levels were observed for an ANA of 1 h:4 h. The reactor with the longest nonaeration time of 4 h performed partial nitrification, followed by denitrification via nitrite, whereas the other reactors removed nitrogen through traditional nitrification and denitrification via nitrate. Superior ammonia removal efficiencies were not associated with levels of specific AOB species or with higher AOB species diversity.     

焦化废水工业处理装置和实验室装置硝化菌群的分子比较

反应器的群落结构分析有助于对工业装置的故障原因进行诊断。为了解决某焦化废水处理装置硝化功能低下的故障,构建了一套相似的实验室装置作为参照系统,该装置的硝化功能良好。通过工业装置和实验室装置好氧池生物膜16SrDNA克隆文库的比较,分析了它们之间硝化菌群的组成差异。实验室装置克隆文库的构成说明Nitrosomonas europaea-Nitrosoccus mobilis类群和Nitrospira属Ⅰ亚区系分别是该工艺条件下优势的氨氧化菌和亚硝酸氧化菌,但工业装置的克隆文库中却没有找到任何与硝化菌序列相近的克隆,这说明工业装置中硝化菌的多度较低。进一步使用Taqman荧光探针实时定量PCR测定了样品中Nitrospira属的多度,实验室装置中Nitrospira属16S rDNA的拷贝数达到3.4×106个/微克基因组DNA,而工业装置的测定值不到实验室装置的1/300。这些试验结果都表明工业装置好氧池微生物群落中缺少适当的硝化菌群是造成其硝化能力低下的重要原因。提高菌群中Nitrosomonas属和Nitrospira属的多度是解决工业装置硝化能力低下的关键。     

Spatial distribution and viability of nitrifying, denitrifying and ANAMMOX bacteria in biofilms of sponge media retrieved from a full-scale biological nutrient removal plant

The spatial distribution and activities of nitrifying and denitrifying bacteria in sponge media were investigated using diverse tools, because understanding of in situ microbial condition of sponge phase is critical for the successful design and operation of sponge media process. The bacterial consortia within the media was composed of diverse groups including a 14.5% Nitrosomonas spp.-like ammonia oxidizing bacteria (AOB), 12.5% Nitrobacter spp.-like nitrite oxidizing bacteria (NOB), 2.0% anaerobic ammonium-oxidizing (ANAMMOX) bacteria and 71.0% other bacteria. The biofilm appeared to be most dense in the relatively outer region of the media and gradually decreased with depth, but bacterial viabilities showed space-independent feature. The fluorescent in situ hybridization results revealed that AOB and NOB co-existed in similar quantities on the side fragments of the media, which was reasonably supported by the microelectrode measurements showing the concomitant oxidation of NH(4) (+) and production of NO(3) (-) in this zone. However, a significantly higher fraction of AOB was observed in the center than side fragment. As with the overall biofilm density profile, the denitrifying bacteria were also more abundant on the side than in the center fragments. ANAMMOX bacteria detected throughout the entire depth offer another advantage for the removal of nitrogen by simultaneously converting NH(4) (+) and NO(2) (-) to nitrogen gas.     

In situ characterization of nitrifiers in an activated sludge plant: detection of Nitrobacter Spp

Aims: The purpose of this work was to investigate microbial ecology of nitrifiers at the genus level in a typical full-scale activated sludge plant. Methods and Results: Grab samples of mixed liquor were collected from a plug-flow reactor receiving domestic wastewater. Fluorescent in situ hybridization technique (FISH) was used to characterize both ammonia oxidizing bacteria (AOB) and nitrite oxidizing bacteria (NOB) in combination with Confocal Scanning Laser Microscope (CSLM). Fluorescently labelled, 16S rRNA-targeted oligonucleotide probes were used in this study. Both Nitrosomonas and Nitrosospira genera as AOB and Nitrobacter and Nitrospira genera as NOB were sought with genus specific probes Nsm156, Nsv443 and NIT3 and NSR1156, respectively. Conclusions: It was shown that Nitrosospira genus was dominant in the activated sludge system studied, although Nitrosomonas is usually assumed to be the dominant genus. At the same time, Nitrobacter genus was detected in activated sludge samples. Significance and Impact of the Study: Previous studies based on laboratory scale pilot plants employing synthetic wastewater suggested that only Nitrospira are found in wastewater treatment plants. We have shown that Nitrobacter genus might also be present. We think that these kinds of studies may not give a valid indication of the microbial diversity of the real full-scale plants fed with domestic wastewater.     

Structure and activity of multiple nitrifying bacterial populations co-existing in a biofilm

A biofilm from a nitrifying pilot-scale sequencing batch reactor was investigated for effects of varying process conditions on its microscale activity and structure. Microsensor measurements of oxygen, substrates and products of nitrification were applied under incubation at different ammonium and oxygen concentrations which reflected various situations during a treatment cycle. A high net N loss was observed under high ammonium (HA) concentrations in contrast to low ones. Additionally, results indicated inhibition of nitrite-oxidizing bacteria (NOB), but not of ammonia-oxidizing bacteria (AOB) by free ammonia under HA conditions. Diversity, spatial distribution, and abundance of nitrifying bacteria as analysed by fluorescence in situ hybridization (FISH) revealed six different nitrifying populations with heterogeneous distributions. Nitrosococcus mobilis formed conspicuous microcolonies locally surrounded by cells of the dominating N. europaea/eutropha-related AOB population. A third less abundant population was affiliated to N. oligotropha. Nitrite-oxidizing bacteria of the genera Nitrobacter and Nitrospira (with at least two distinct populations) showed a large scale heterogeneity in their distribution. Nitrospira spp. were also found in deeper inactive layers where they might persist rather than thrive, and act as seed population when detached. Results of functional and structural analyses are discussed with respect to specific niches of individual populations in this system.     

Multi‐species nitrifying biofilm model (MSNBM) including free ammonia and free nitrous acid inhibition and oxygen limitation

A multi‐species nitrifying biofilm model (MSNBM) is developed to describe nitrite accumulation by simultaneous free ammonia (FA) and free nitrous acid (FNA) inhibition, direct pH inhibition, and oxygen limitation in a biofilm. The MSNBM addresses the spatial gradient of pH with biofilm depth and how it induces changes of FA and FNA speciation and inhibition. Simulations using the MSNBM in a completely mixed biofilm reactor show that influent total ammonia nitrogen (TAN) concentration, bulk dissolved oxygen (DO) concentration, and buffer concentration exert significant control on the suppression of nitrite‐oxidizing bacteria (NOB) and shortcut biological nitrogen removal (SBNR), but the pH in the bulk liquid has a weaker influence. Ammonium oxidation increases the nitrite concentration and decreases the pH, which together can increase FNA inhibition of NOB in the biofilm. Thus, a low buffer concentration can accentuate SBNR. DO and influent TAN concentrations are efficient means to enhance DO limitation, which affects NOB more than ammonia‐oxidizing bacteria (AOB) inside the biofilm. With high influent TAN concentration, FA inhibition is dominant at an early phase, but finally DO limitation becomes more important as TAN degradation and biofilm growth proceed. MSNBM results indicate that oxygen depletion and FNA inhibition throughout the biofilm continuously suppress the growth of NOB, which helps achieve SBNR with a lower TAN concentration than in systems without concentration gradients. Biotechnol. Bioeng. 2010;105: 1115–1130. © 2009 Wiley Periodicals, Inc.     

Identification of novel small molecule enhancers of protein production by cultured mammalian cells

Shortcut nitrogen removal, that is, removal via formation and reduction of nitrite rather than nitrate, has been observed in membrane-aerated biofilms (MABs), but the extent, the controlling factors, and the kinetics of nitrite formation in MABs are poorly understood. We used a special MAB reactor to systematically study the effects of the dissolved oxygen (DO) concentration at the membrane surface, which is the biofilm base, on nitrification rates, extent of shortcut nitrification, and microbial community structure. The focus was on anoxic bulk liquids, which is typical in MAB used for total nitrogen (TN) removal, although aerobic bulk liquids were also studied. Nitrifying MABs were grown on a hollow-fiber membrane exposed to 3 mg N/L ammonium. The MAB intra-membrane air pressure was varied to achieve different DO concentrations at the biofilm base, and the bulk liquid was anoxic or with 2 g m(-3) DO. With 2.2 and 3.5 g m(-3) DO at the biofilm base, and with an anoxic bulk-liquid, the ammonium fluxes were 0.75 and 1.0 g N m(-2) day(-1), respectively, and nitrite was the main oxidized nitrogen product. However, with membrane DO of 5.5 g m(-3), and either zero or 2 g m(-3) DO in the bulk, the ammonium flux was around 1.3 g N m(-2) day(-1), and nitrate flux increased significantly. For all experiments, the cell density of ammonium oxidizing bacteria (AOB) was relatively uniform throughout the biofilm, but the density of nitrite oxidizing bacteria (NOB) decreased with decreasing biofilm DO. Among NOB, Nitrobacter spp. were dominant in biofilm regions with 2 g m(-3) DO or greater, while Nitrospira spp. were dominant in regions with less than 2 g m(-3) DO. A biofilm model, including AOB, Nitrobacter spp., and Nitrospira spp., was developed and calibrated with the experimental results. The model predicted the greatest extent of nitrite formation (95%) and the lowest ammonium oxidation flux (0.91 g N m(-2) day(-1)) when the membrane DO was 2 g m(-3) and the bulk liquid was anoxic. Conversely, the model predicted the lowest extent of nitrite formation (40%) and the highest ammonium oxidation flux (1.5 g N m(-2) day(-1)) when the membrane-DO and bulk-DO were 8 g m(-3) and 2 g m(-3), respectively. The estimated kinetic parameters for Nitrospira spp., revealed a high affinity for nitrite and oxygen. This explains the dominance of Nitrospira spp. over Nitrobacter spp. in regions with low nitrite and oxygen concentrations. Our results suggest that shortcut nitrification can effectively be controlled by manipulating the DO at the membrane surface. A tradeoff is made between increased nitrite accumulation at lower DO, and higher nitrification rates at higher DO.     

Ammonia- and nitrite-oxidizing bacterial communities in a pilot-scale chloraminated drinking water distribution system.

Nitrification in drinking water distribution systems is a common operational problem for many utilities that use chloramines for secondary disinfection. The diversity of ammonia-oxidizing bacteria (AOB) and nitrite-oxidizing bacteria (NOB) in the distribution systems of a pilot-scale chloraminated drinking water treatment system was characterized using terminal restriction fragment length polymorphism (T-RFLP) analysis and 16S rRNA gene (ribosomal DNA [rDNA]) cloning and sequencing. For ammonia oxidizers, 16S rDNA-targeted T-RFLP indicated the presence of Nitrosomonas in each of the distribution systems, with a considerably smaller peak attributable to Nitrosospira-like AOB. Sequences of AOB amplification products aligned within the Nitrosomonas oligotropha cluster and were closely related to N. oligotropha and Nitrosomonas ureae. The nitrite-oxidizing communities were comprised primarily of Nitrospira, although Nitrobacter was detected in some samples. These results suggest a possible selection of AOB related to N. oligotropha and N. ureae in chloraminated systems and demonstrate the presence of NOB, indicating a biological mechanism for nitrite loss that contributes to a reduction in nitrite-associated chloramine decay.     

Microenvironments and distribution of nitrifying bacteria in a membrane-bound biofilm

The distribution of nitrifying bacteria of the genera Nitrosomonas, Nitrosospira, Nitrobacter and Nitrospira was investigated in a membrane-bound biofilm system with opposed supply of oxygen and ammonium. Gradients of oxygen, pH, nitrite and nitrate were determined by means of microsensors while the nitrifying populations along these gradients were identified and quantified using fluorescence in situ hybridization (FISH) in combination with confocal laser scanning microscopy. The oxic part of the biofilm which was subjected to high ammonium and nitrite concentrations was dominated by Nitrosomonas europaea -like ammonia oxidizers and by members of the genus Nitrobacter. Cell numbers of Nitrosospira sp. were 1–2 orders of magnitude lower than those of N. europaea . Nitrospira sp. were virtually absent in this part of the biofilm, whereas they were most abundant at the oxic–anoxic interface. In the totally anoxic part of the biofilm, cell numbers of all nitrifiers were relatively low. These observations support the hypothesis that N. europaea and Nitrobacter sp. can out-compete Nitrosospira and Nitrospira spp. at high substrate and oxygen concentrations. Additionally, they suggest microaerophilic behaviour of yet uncultured Nitrospira sp. as a factor of its environmental competitiveness.     

Nitrite-oxidizing bacteria guild ecology associated with nitrification failure in a continuous-flow reactor

Nitrification is an important process for nitrogen removal in many wastewater treatment plants, which requires the mutualistic oxidation of ammonia to nitrate by ammonia-oxidizing bacteria (AOB) and nitrite-oxidizing bacteria (NOB). However, this process can be quite unpredictable because both guilds are conditionally sensitive to small changes in operating conditions. Here, dynamics are examined within the NOB guild in two parallel chemostats operated at low and high dilution rates (0.10 and 0.83 day(-1), respectively) during periods of varying nitrification performance. NOB and AOB guild abundances and nitrogen-oxidation efficiency were relatively constant over time in the 0.10 day(-1) reactor; however, the 0.83 day(-1) reactor had two major disturbance episodes that caused destabilization of the NOB guild, which ultimately led to nitrification failure. The first episode caused the extinction of Nitrospira spp. from the system, resulting in chronic incomplete ammonia oxidation and nitrite accumulation. The second episode caused complete loss of nitrification activity, likely resulting from metal toxicity and the previous extinction of Nitrospira spp. from the system. These results exemplify the types of changes that can occur within the NOB guild that result in process impairment or failure, and provide one possible explanation for why nitrification is often unstable at higher dilution rates.     

High abundance of ammonia-oxidizing archaea in acidified subtropical forest soils in southern China after long-term N deposition

Nitrification has been believed to be performed only by autotrophic ammonia-oxidizing bacteria (AOB) and nitrite-oxidizing bacteria (NOB) until the recent discovery of ammonia-oxidizing archaea (AOA). Meanwhile, it has been questioned whether AOB are significantly responsible for NH(3) oxidation in acidic forest soils. Here, we investigated nitrifying communities and their activity in highly acidified soils of three subtropical forests in southern China that had received chronic high atmospheric N deposition. Nitrifying communities were analyzed using PCR- and culture (most probable number)-based approaches. Nitrification activity was analyzed by measuring gross soil nitrification rates using a (15) N isotope dilution technique. AOB were not detected in the three forest soils: neither via PCR of 16S rRNA and ammonia monooxygenase (amoA) genes nor via culture-based approaches. In contrast, an extraordinary abundance of the putative archaeal amoA was detected (3.2?×?10(8) -1.2?×?10(9) g?soil(-1) ). Moreover, this abundance was correlated with gross soil nitrification rates. This indicates that amoA-possessing archaea rather than bacteria were predominantly responsible for nitrification of the soils. Furthermore, sequences of the genus Nitrospira, a dominant group of soil NOB, were detected. Thus, nitrification of acidified subtropical forest soils in southern China could be performed by a combination of AOA and NOB.     

Rapid start-up of nitrifying MBBRs at low temperatures: nitrification,biofilm response and microbiome analysis

The moving bed biofilm reactor (MBBR), operated as a post carbon removal system, requires long start-up times in comparison to carbon removal systems due to slow growing autotrophic organisms. This study investigates the use of carriers seeded in a carbon rich treatment system prior to inoculation in a nitrifying MBBR system to promote the rapid development of nitrifying biofilm in an MBBR system at temperatures between 6 and 8 °C. Results show that nitrification was initiated by the carbon removal carriers after 22 h of operation. High throughput 16S-rDNA sequencing indicates that the sloughing period was a result of heterotrophic organism detachment and the recovery and stabilization period included a growth of Nitrosomonas and Nitrospira as the dominant ammonia oxidizing bacteria (AOB) and nitrite oxidizing bacteria (NOB) in the biofilm. Peripheral microorganisms such as Myxococcales, a rapid EPS producer, appear to have contributed to the recovery and stabilization of the biofilm.

     

硝化作用研究的新发现:单步硝化作用与全程氨氧化微生物

硝化作用是氨被微生物氧化为硝酸盐的过程,分别由氨氧化微生物(AOB和AOA)和亚硝酸盐氧化细菌(NOB)主导完成.一个世纪以来,我们把这个分步硝化过程当成唯一的硝化途径来学习和研究.虽然根据动力学理论推测,环境中应该存在单步硝化作用,即由一种微生物单独完成整个硝化过程,将NH₃氧化为NO₃^-,但一直没有研究能直接证明该种微生物的存在.直到2015年底,3个科研团队分别在不同环境中发现了3种不同的经过纯培养的细菌(Candidatus Nitrospira nitrosa、Candidatus Nitrospira nitrificans和Candidatus Nitrospira inopinata)和一种未经过纯培养的细菌(类Nitrospira),它们都具备单独将氨氧化为硝酸盐的能力,这些微生物被定义为全程氨氧化微生物(Comammox).单步硝化作用和全程氨氧化微生物的发现终结了传承百年的理论,并引发了众多关于全球氮素循环的重要科学问题,如这些微生物在环境中的生态位点及其在硝化作用中的相对贡献等.本文就单步硝化作用及全程氨氧化微生物的发现作了简要概述.     

Distinctive microbial ecology and biokinetics of autotrophic ammonia and nitrite oxidation in a partial nitrification bioreactor

Biological nitrogen removal (BNR) based on partial nitrification and denitrification via nitrite is a cost-effective alternate to conventional nitrification and denitrification (via nitrate). The goal of this study was to investigate the microbial ecology, biokinetics, and stability of partial nitrification. Stable long-term partial nitrification resulting in 82.1 +/- 17.2% ammonia oxidation, primarily to nitrite (77.3 +/- 19.5% of the ammonia oxidized) was achieved in a lab-scale bioreactor by operation at a pH, dissolved oxygen and solids retention time of 7.5 +/- 0.1, 1.54 +/- 0.87 mg O(2)/L, and 3.0 days, respectively. Bioreactor ammonia oxidizing bacteria (AOB) and nitrite oxidizing bacteria (NOB) populations were most closely related to Nitrosomonas europaea and Nitrobacter spp., respectively. The AOB population fraction varied in the range 61 +/- 45% and was much higher than the NOB fraction, 0.71 +/- 1.1%. Using direct measures of bacterial concentrations in conjunction with independent activity measures and mass balances, the maximum specific growth rate (micro(max)), specific decay (b) and observed biomass yield coefficients (Y(obs)) for AOB were 1.08 +/- 1.03 day(-1), 0.32 +/- 0.34 day(-1), and 0.15 +/- 0.06 mg biomass COD/mg N oxidized, respectively. Corresponding micro(max), b, and Y(obs) values for NOB were 2.6 +/- 2.05 day(-1), 1.7 +/- 1.9 day(-1), and 0.04 +/- 0.02 mg biomass COD/mg N oxidized, respectively. The results of this study demonstrate that the highly selective partial nitrification operating conditions enriched for a narrow diversity of rapidly growing AOB and NOB populations unlike conventional BNR reactors, which host a broader diversity of nitrifying bacteria. Further, direct measures of microbial abundance enabled not only elucidation of mixed community microbial ecology but also estimation of key engineering parameters describing bioreactor systems supporting these communities.     

Nitrification in hybrid bioreactors treating simulated domestic wastewater

Aim

To provide deeper insights into nitrification process within aerobic bioreactors containing supplemental physical support media (hybrid bioreactors).

Methods and Results

Three bench‐scale hybrid bioreactors with different media size and one control bioreactor were operated to assess how biofilm integrity influences microbial community conditions and bioreactor performance. The systems were operated initially at a 5‐day hydraulic retention time (HRT), and all reactors displayed efficient nitrification and chemical oxygen demand (COD) removal (>95%). However, when HRT was reduced to 2·5 days, COD removal rates remained high, but nitrification efficiencies declined in all reactors after 19 days. To explain reduced performance, nitrifying bacterial communities (ammonia‐oxidizing bacteria, AOB; nitrite‐oxidizing bacteria, NOB) were examined in the liquid phase and also on the beads using qPCR, FISH and DGGE. Overall, the presence of the beads in a reactor promoted bacterial abundances and diversity, but as bead size was increased, biofilms with active coupled AOB–NOB activity were less apparent, resulting in incomplete nitrification.

Conclusions

Hybrid bioreactors have potential to sustain effective nitrification at low HRTs, but support media size and configuration type must be optimized to ensure coupled AOB and NOB activity in nitrification.

Significance and Impact of the Study

This study shows that AOB and NOB coupling must be accomplished to minimize nitrification failure.     

Effective and robust partial nitrification to nitrite by real-time aeration duration control in an SBR treating domestic wastewater

Achieving sustainable partial nitrification to nitrite has been proven difficult in treating low strength nitrogenous wastewater. Real-time aeration duration control was used to achieve efficient partial nitrification to nitrite in a sequencing batch reactor (SBR) to treat low strength domestic wastewater. Above 90% nitrite accumulation ratio was maintained for long-term operation at normal condition, or even lower water temperature in winter. Partial nitrification established by controlling aeration duration showed good performance and robustness even though encountering long-term extended aeration and starvation period. Process control enhanced the successful accumulation of ammonia oxidizing bacteria (AOB) and washout of nitrite oxidizing bacteria (NOB). Scanning electron microscope observations indicated that the microbial morphology showed a shift towards small rod-shaped clusters. Fluorescence in situ hybridization (FISH) results demonstrated AOB were the dominant nitrifying bacteria, up to 8.3 ± 1.1% of the total bacteria; on the contrary, the density of NOB decreased to be negligible after 135 days operation since adopting process control.     

Partial nitrification in a sequencing batch reactor treating acrylic fiber wastewater

A sequencing batch reactor was employed to treat the acrylic fiber wastewater. The dissolved oxygen and mixed liquor suspended solids were 2–3 and 3,500–4,000 mg/L, respectively. The results showed ammonium oxidizing bacteria (AOB) had superior growth rate at high temperature than nitrite oxidizing bacteria (NOB). Partial nitrification could be obtained with the temperature of 28 °C. When the pH value was 8.5, the nitrite-N accumulation efficiency was 82 %. The combined inhibitions of high pH and free ammonium to NOB devoted to the nitrite-N buildup. Hydraulic retention time (HRT) was a key factor in partial nitrification control, and the optimal HRT was 20 h for nitrite-N buildup in acrylic fiber wastewater treatment. The ammonium oxidation was almost complete and the transformation from nitrite to nitrate could be avoided. AOB and NOB accounted for 2.9 and 4.7 %, respectively, corresponding to the pH of 7.0. When the pH was 8.5, they were 6.7 and 0.9 %, respectively. AOB dominated nitrifying bacteria, and NOB was actually washed out from the system.