Peptone,a low-cost growth-promoting nutrient for intensive animal cell culture

The effect of addition of peptone to serum-free and serum supplemented media for the growth of hybridoma cells in various systems was studied. Supplementation of defined medium with either proteose peptone or meat peptone resulted in significant increases in cell number and specific monoclonal antibody production in batch culture system. Other peptones were either inactive or less effective. In continuous culture, using medium supplemented with new born calf serum, the addition of peptone resulted in 125% and 150% increases in cell and antibody concentrations respectively. Similar increase in cell number (128%) was also obtained in spin-filter perfusion culture when medium was supplemented with peptone. By comparison, the substitution of a defined 1xMEM amino acids mixture resulted in only a 50% increase. At higher perfusion rates the cell number maintained in steady state using peptone supplement could be increased to 1.3×10⁷ cells ml^–1 while the serum concentration was reduced from 5% to 1% at a perfusion rate of 2.5 volumes per day.     

Identification of lactoferrin as an essential growth factor for human lymphocytic cell lines in serum-free medium

A serum-free medium supplemented with growth factor(s) was devised to grow human lymphocytic cell lines. The medium was developed using human lymphocytic cell line, Bri 7 cells. In the process of constructing the medium, human lactoferrin was found to be an essential growth factor for the cell line. Human lactoferrin has higher growth stimulatory activity than human transferrin, and was sensitive to heat. Long-term cultivation of the cells was achieved in the defined medium supplemented with human lactoferrin only. The defined medium specifically supported the growth of various other human B- and T-lymphocytic cell lines but not the growth of various mouse lymphocytic cell lines. In lactoferrin-supplemented medium, the growth of some human cell lines were further stimulated by the addition of a combination of insulin, ethanolamine and selenium, or another combination of 2-mercaptoethanol and the above three factors. Bovine lactoferrin could be substituted for human lactoferrin.     

Identification of lactoferrin as an essential growth factor for human lymphocytic cell lines in serum-free medium

A serum-free medium supplemented with growth factor(s) was devised to grow human lymphocytic cell lines. The medium was developed using human lymphocytic cell line, Bri 7 cells. In the process of constructing the medium, human lactoferrin was found to be an essential growth factor for the cell line. Human lactoferrin has higher growth stimulatory activity than human transferrin, and was sensitive to heat. Long-term cultivation of the cells was achieved in the defined medium supplemented with human lactoferrin only. The defined medium specifically supported the growth of various other human B- and T-lymphocytic cell lines but not the growth of various mouse lymphocytic cell lines. In lactoferrin-supplemented medium, the growth of some human cell lines were further stimulated by the addition of a combination of insulin, ethanolamine and selenium, or another combination of 2-mercaptoethanol and the above three factors. Bovine lactoferrin could be substituted for human lactoferrin.     

A chemically defined and minimal medium for Clostridium difficile

A chemically defined medium (CDCDM) has been developed for Clostridium difficile. The medium contains nine amino acids, five mineral salts, N -acetylglucosamine and the growth factors riboflavin and nicotinic acid. Ten strains of C. difficile have been subcultured repeatedly in this medium with no apparent changes in colonial or cellular morphology. The metabolic end-products of strains grown in this medium were reproducible and yielded patterns similar to those produced by cells cultured in Brain Heart Infusion broth (BHI). The growth rates were approximately 40% slower than those in a complex medium and the growth rate constants ranged between 0·011 and 0·087 h^-1. When the defined medium was supplemented with proteose peptone, yeast extract or caesin hydrolysate at concentrations of 1%, growth increased. No such growth increase was observed when the medium was supplemented with casamino acids or glucose.     

Development of improved media for axenic cultivation of Acanthamoeba culbertsoni, Singh and Das 1970

Several varieties of peptone supported growth of A. culbertsoni to different extents reaching a maximum cell density of 1-2 X 10(6)/ml. Proteose peptone and tryptone also yielded good growth when combined with thiamine and vitamin B12. A combination of proteose peptone with glucose, yeast extract and salts promoted excellent growth of A. culbertsoni with cell density reaching 1-2 X 10(7) cells/ml; tryptone and one of the indigenous peptones also yielded comparable growth when substituted for proteose peptone in this medium. Casamino acids also supported good growth of amoebae and requirement of yeast extract could be met by a combination of thiamine, vitamin B12 and biotin. Bacto peptone did not support good growth of this amoeba but supplementation of peptone with casamino acids or amino acid mixture improved the growth supporting capacity of the medium. Development of several media with or without glucose will aid in cultivation of A. culbertsoni, studies on its metabolism as well as screening of potential drugs.     

Transforming viruses directly reduce the cellular growth requirement for a platelet derived growth factor

Early passage mouse embryo fibroblasts, mouse 3T3 cell lines, and early passage diploid human fibroblasts grew to higher cell densities in tissue culture medium supplemented with serum than in medium supplemented with defibrinogenated platelet-poor plasma (PPP). Unlike the mouse cells, the human fibroblasts displayed this differential growth response only in the presence of hypophysiologic concentrations of calcium. The addition of heat-treated extracts of human platelets to PPP-supplemented medium stimulated the replication of both the normal mouse cells and early passage human embryo fibroblasts. Human or mouse fibroblasts transformed by either retroviruses or by SV40, including SV40 infected “serum revertants” and “flat transformants,” grew to equal cell densities in medium supplemented with either serum or PPP. Infection of Balb/c-3T3 cells with SV40 rapidly induced them to grow in PPP-supplemented medium demonstrating that the ability of SV40-transformed cell lines to proliferate in PPP-supplemented medium does not arise from the cell culture selection procedures usually employed to obtain stable virus-transformed cell lines. 3T3 cells infected but not transformed by retroviruses do not replicate in PPP-supplemented medium demonstrating that reduction of the growth requirement for the platelet growth factor(s) by retroviruses is a transformation-specific response. Cell cultures that did not proliferate well in PPP-supplemented medium did not form tumors when inoculated into athymic nude mice. Many, although not all, of the lines which grew well in PPP medium were tumorigenic in nude mice. Together, these findings indicate that: (1) normal fibroblast-like cells display a growth requirement for factor(s) present in serum but not found in PPP; (2) this serum specific growth factor is derived from platelets; (3) a primary response to viral transforming genes is a reduction in the growth requirement for these platelet-derived factors; and (4) cells that have a reduced requirement for the platelet-derived growth factor are often tumorigenic.     

ras and neu oncogenes reverse serum inhibition and epidermal growth factor dependence of serum-free mouse embryo cells

Serum-free mouse embryo cells, cultured in basal nutrient medium supplemented with insulin, transferrin, epidermal growth factor, fibronectin, and high-density lipoprotein, do not exhibit growth crisis, lack detectable chromosomal aberrations, are nontumorigenic in vivo, are dependent on epidermal growth factor for survival, and are growth inhibited by serum or platelet-free plasma. These cells after transfection with the human Ha-ras or rat neu oncogenes no longer required epidermal growth factor for survival, were tumorigenic in vivo, and also proliferated in serum-containing medium. Autocrine activity capable of replacing epidermal growth factor was detected in conditioned medium from ras-transformed cultures, but little such activity was detected in medium from neu-transformed cultures. In addition, the capability of ras or neu-transformed cells to grow in serum-containing medium could not be mimicked in untransformed cells by the addition of growth factors or conditioned medium from transformed cells. These results suggest that the known structural similarity of the neu gene product to the EGF receptor is also reflected in a functional similarity by which the mutationally activated neu protein can replace the ligand-activated EGF receptor. These results also suggest that the ability of ras- and neu-transformed cells to escape the effect of the inhibitory serum activity is a nonautocrine property distinct from the acquisition of EGF autonomy.     

Chemically defined and minimal media forBacteroides gingivalis

A chemically defined medium (BGDM) has been developed specifically forBacteroides gingivalis. The medium contains 4 amino acids, 5 mineral salts, cysteine hydrochloride as a reducing agent, and the growth factors hemin and menadione. Eight strains ofB. gingivalis have been subcultured repeatedly in this medium with no apparent changes in colonial or cellular morphology. The metabolic end products of strains grown in this medium were reproducible and yielded patterns similar to those produced by cells cultured in complex media. The growth rates were about 50% slower than those of cells grown in a complex medium, and the growth rate constants ranged between 0.013 and 0.067 H^–1. When the defined medium was supplemented with protein hydrolysates such as trypticase, proteose peptone, bactocasitone, or yeast extract, at concentrations up to 1.0%, growth increased. No such growth increase was observed in the medium supplemented with casamino acids. Thus a minimal medium can be formulated by adding one of the growth-enhancing protein hydrolysates to the defined medium at varying concentrations depending upon the growth yield required.     

Growth hormone is a growth factor for the differentiated pancreatic beta-cell

The regulation of the growth of the pancreatic beta-cell is poorly understood. There are previous indications of a role of GH in the growth and insulin production of the pancreatic islets. In the present study we present evidence for a direct long-term effect of GH on proliferation and insulin biosynthesis of pancreatic beta-cells in monolayer culture. In culture medium RPMI 1640 supplemented with 2% normal human serum islets or dissociated islet cells from newborn rats maintained their insulin-producing capacity. When supplemented with 1-1000 ng/ml pituitary or recombinant human GH the islet cells attached, spread out, and proliferated into monolayers mainly consisting of insulin-containing cells. The number of beta-cells in S-phase was increased from 0.9-6.5% as determined by immunochemical staining of bromodeoxyuridine incorporated into insulin-positive cells. The increase in cell number was accompanied with a continuous increase in insulin release to the culture medium reaching a 10- 20-fold increase after 2-3 months with a half-maximal effect at about 10 ng/ml human GH. The biosynthesis of (pro)insulin was markedly increased with a normal rate of conversion of proinsulin to insulin. It is concluded that GH is a potent growth factor for the differentiated pancreatic beta-cell.     

The growth requirements of BHK-21 cells in serum-free culture

A serum-free medium for serial culture of baby hamster kidney cell line 21 (BHK-21) as container-adherent cells was developed. The medium is a 1:1 (v/v) mixture of Dulbecco's modified Eagle's medium and Ham's F-12 medium supplemented with fibroblast growth factor, fibronectin, insulin, oleic acid (preincubated with fatty-acid-free bovine serum albumin as carrier), and transferrin. The fibronectin was required for cell adherence, the other factors for optimal cell multiplication. When cell input was greater than about 1,900 cells/cm², this serum-free medium supported cell multiplication at a rate approximately equal to the rate in medium with 10% serum. At lower cell input, growth in the serum-free medium was poor unless it was supplemented with serum-free medium which had been conditioned by BHK-21 cells. The conditioned medium contained a factor(s) which enabled or stimulated cell multiplication.     

Effects of peptone on hybridoma growth and monoclonal antibody formation

Hybridoma WuT3 secreting a monoclonal antibody against T lymphocytes was grown in RPMI 1640 medium supplemented with 1% human serum. The effect of the concentration of peptone, as an additive, was investigated on cell growth, monoclonal antibody formation, and cell metabolism over 0–10 g l^–1 range. It was found that 1–5 g l^–1 peptone can significantly promote the growth of cells and increase the formation of monoclonal antibody, especially at 3–5 g l^–1, when both the accumulating level and secretion rate of monoclonal antibody are higher than that at other peptone concentrations. Based on glucose, lactate and ammonia analysis data, the efficiency of glycolysis was assessed and the utilization of amino acids was more efficient at 3–5 g l^–1 peptone. The cell growth and monoclonal antibody formation were inhibited at higher peptone concentrations, e.g. 10 g l^–1.     

Leucine stimulates the secretion of hepatocyte growth factor by hepatic stellate cells

Branched-chain amino acids (BCAAs) modulate various cellular functions, in addition to providing substrates for the production of proteins. In this study, we examined the effect of BCAAs on the secretion of hepatocyte growth factor (HGF) by hepatic stellate cells. A hepatic stellate cell clone was cultured in medium supplemented with various concentrations of valine, leucine, or isoleucine. Of these BCAAs, leucine markedly induced an increase in the levels of HGF in the medium in a dose-dependent manner. The addition of valine or isoleucine had no significant effect on HGF levels in the medium. The difference in levels of HGF in the medium between leucine-treated and non-treated cells was enhanced by the incubation period. These results demonstrate that, among BCAAs, leucine stimulates the secretion of HGF by cultured hepatic stellate cells.     

Dependence of the proliferation of cell line 3T6 on a totally serum-free medium on epidermal growth factor

The Eagle medium containing the epidermal growth factor (EGF), insulin, transferrin and a source of iron is able to support proliferation of 3T6 cells in the absence of serum. The formation of 3T6 cell clones in the similar medium supplemented with non-essential amino acids confirms the usefulness of such a medium for cell cultivation. It has been found that the exclusion of EGF rather than other above components from the medium inhibits most highly the increase in cell number.     

Study of amino acid utilization by isogenic strains of Escherichia coli in relation to the culture growth and biosynthesis of penicillin amidase

Dynamics of free amino acid utilization by isogenic strains of Escherichia coli differing in intensity of their growth and levels of penicillin acylase biosynthesis in media containing corn steep liquor or peptone was studied. It was shown that in both the media some amino acids such as serine, threonine, glutaminic and asparaginic acids were actively utilized by the strains mainly during the culture intensive growth while others such as glycine, alanine and tyrosine were actively utilized during the enzyme biosynthesis. Intensively utilized arginine and proline were probably used for the growth and biosynthesis. The other amino acids were not utilized completely from the media. The lowest levels of their utilization were observed when the strains were cultivated in the medium with peptone.     

Effect of oleic acid on vegetative growth of the aphid-pathogenic fungus Erynia neoaphidis

Abstract The aphid-pathogenic fungus Erynia neophidis grew on a semi-defined medium containing 16 g·1⁻¹ glucose, 3 g·1⁻¹ yeast extract and 5 g·1⁻ mycological peptone only when the medium was supplemented with low concentrations of certain fatty acids. Of these, oleic acid fulfilled the growth requirement at a concentration of 0.02% (v/v), but higher concentrations were toxic, causing complete loss of viability of cultures at a concentration of 0.2% (v/v) in liquid medium and at 4% (v/v) on solid medium. The reduced viability of the fungus in liquid culture compared to that on equivalent solid medium, and at low inoculum density compared to high inoculum density in liquid medium, is explicable in terms of this toxicity.     

The growth of mouse melanoma cells in hormone-supplemented, serum-free medium.

A mouse melanoma line, M2R, derived from the B₁₆ transplantable tumor can be grown in a hormone-supplemented serum-free medium. Cells grown in medium supplemented with insulin, transferrin, testosterone (or progesterone), follicle-stimulating hormone, nerve growth factor (NGF) and leutinizing releasing hormone show growth rates equivalent to that seen in medium supplemented with 5% fetal calf serum (FCS). This hormone-supplemented medium will support the growth of cells indefinitely. In cells grown in hormone-supplemented medium, insulin is shown to increase incorporation of glucose into glycogen and fatty acids. Transferrin is shown to act in part as an iron transport protein, although another role in growth stimulation cannot be eliminated. It is suggested that progesterone stimulates growth via an androgenic breakdown product and thus acts in a manner similar to testosterone.     

Modification of the technical properties of Lactobacillus johnsonii NCC 533 by supplementing the growth medium with unsaturated fatty acids

The aim of this study was to investigate the influence of supplementing growth medium with unsaturated fatty acids on the technical properties of the probiotic strain Lactobacillus johnsonii NCC 533, such as heat and acid tolerance, and inhibition of Salmonella enterica serovar Typhimurium infection. Our results showed that the membrane composition and morphology of L. johnsonii NCC 533 were significantly changed by supplementing a minimal Lactobacillus medium with oleic, linoleic, and linolenic acids. The ratio of saturated to unsaturated plus cyclic fatty acids in the bacterial membrane decreased by almost 2-fold when minimal medium was supplemented with unsaturated fatty acids (10 μg/ml). The subsequent acid and heat tolerance of L. johnsonii decreased by 6- and 20-fold when the strain was grown in the presence of linoleic and linolenic acids, respectively, compared with growth in oleic acid (all at 10 μg/ml). Following acid exposure, significantly higher (P < 0.05) oleic acid content was detected in the membrane when growth medium was supplemented with linoleic or linolenic acid, indicating that saturation of the membrane fatty acids occurred during acid stress. Cell integrity was determined in real time during stressed conditions using a fluorescent viability kit in combination with flow cytometric analysis. Following heat shock (at 62.5°C for 5 min), L. johnsonii was unable to form colonies; however, 60% of the bacteria showed no cell integrity loss, which could indicate that the elevated heat inactivated vital processes within the cell, rendering it incapable of replication. Furthermore, L. johnsonii grown in fatty acid-enriched minimal medium had different adhesion properties and caused a 2-fold decrease in S. enterica serovar Typhimurium UK1-lux invasion of HT-29 epithelial cells compared with bacteria grown in minimal medium alone. This could be related to changes in the hydrophobicity and fluidity of the membrane. Our study shows that technical properties underlying probiotic survivability can be affected by nutrient composition of the growth medium.     

Anchorage-dependent growth factor(s) produced by rat sarcoma (XC) cells.

The autocrine growth factor(s) was isolated from serumfree conditioned medium of rat sarcoma (XC) cells. Autocrine activity was enriched by ultrafiltration using Amicon YM 10 membrane, extraction with 1 M acetic acid and partially purified (650-fold) by chromatography on Bio-Gel P-100 and P-60. The final recovery of the autocrine factor(s) was 4 micrograms from 1800 ml of the conditioned medium (a yield of 6%). The factor(s) with molecular weight 6-10 kDa was heat and acid stable but inactivated by trypsin and dithiothreitol. It stimulated anchorage-dependent (but not anchorage-independent) growth of XC cells as well as untransformed, established lines of rat (NRK) and mouse (3T3) cells. The results obtained may suggest that autocrine factor(s) produced by XC cells can be one of EGF-like or/and insulin-like growth factors.     

Difference in growth factor requirements of rat 3Y1 cells among growth in mass culture, clonal growth in low density culture, and stimulation to enter S phase in resting culture

A semiserum-free medium was developed for monolayer culture of rat 3Y1 fibroblastic cells. The main components of the developed medium added to Dulbecco's modified Eagle's medium (DMEM) were insulin, transferrin, epidermal growth factor, poly-D-lysine, bovine albumin, oleic acid, and bovine alpha-globulin. In this medium, 3Y1 cells grew in mass culture at much the same rate as in DMEM supplemented with 10% fetal bovine serum (FBS), and colonies, albeit of smaller sizes, did form. Virally transformed derivatives of 3Y1 (simian virus 40-3Y1, polyoma virus-3Y1 and adenovirus type 12-3Y1) also formed colonies in the semiserum-free medium. When trypsinized 3Y1 cells were seeded with the medium lacking alpha-globulin, neither growth in the mass culture nor clonal growth in the low density culture (clonal growth) occurred. In this case, cell spreading was inhibited by albumin, and this inhibition was overcome by adding alpha-globulin or treating dishes with serum. When albumin was excluded from the semiserum-free medium, clonal growth did not occur, whereas growth in mass culture and stimulation of DNA synthesis in the resting mass culture (stimulation of DNA synthesis) were not so drastically affected. When oleic acid was removed, growth in mass culture was inhibited considerably, but no considerable effect was seen on clonal growth or on stimulation of DNA synthesis. In the absence of insulin, stimulation of DNA synthesis was inhibited more markedly than when other components were removed, but such was not the case with growth in mass culture and clonal growth.     

alpha-Factor directed expression of the human epidermal growth factor in Saccharomyces cerevisiae

Expression kinetics of the human Epidermal Growth Factor (hEGF) from the alpha-factor prepro region in a 2-mum based plasmid was studied in Saccharomyces cerevisiae. Production of hEGF was highly medium de pendent as a chemically defined, nonenriched media had a significantly lower yield than did enriched media. Also cells grown on yeast nitrogen base without amino acids with casamino acids degraded the hEGF after cell growth as opposed to a yeast extract, peptone, and dextrose (YEPD) medium, which elicited no measurable extracellular proteolysis of the hEGF. alpha-factor directed production kinetics of hEGF on the YEPD medium were growth associated, secretion limitations and extracellular degradation were negligible, and the hEGF was nearly 100% selectively secreted. With sufficient agitation, shake flask experiments were representative of aerated controlled batch fermentations. No effect of high cell density was observed on cell growth or hEGF production kinetics. The hollow fiber bioreactor had no direct effect on the substrate or protein yields of S. cerevisiae, however the low oxygen transfer capacity of the membrane was not sufficient to support respiration.