Keratinases and sulfide from <Emphasis Type="Italic">Bacillus subtilis</Emphasis> SLC to recycle feather waste

The aim of this study is to investigate the culture conditions of chicken feather degradation and keratinolytic enzyme production by the recently isolated Bacillus subtilis SLC and to evaluate the potential of the SLC strain to recycle feather waste discarded by the poultry industry. The SLC strain was isolated from the agroindustrial waste of a poultry farm in Brazil and was confirmed to belong to Bacillus subtilis by rDNA gene analysis. There was high keratinase production when the medium was at pH 8 (280 U ml⁻¹). Activity was higher using the inoculum propagated for 72 h on 1% whole feathers supplemented with 0.1% yeast extract. In the enzymatic extract, the keratinases were active in the pH range from 2.0 to 12.0 with a maximum activity at pH 10.0 and temperature 60°C. For gelatinase the best pH was 5.0 and the best temperature was 37°C. All keratinases are serine peptidases. The crude enzymatic extract degraded keratin, gelatin, casein, and hemoglobin. Scanning electron microscopy showed Bacillus cells adhered onto feather surfaces after 98 h of culture and degraded feather filaments were observed. MALDI-TOF mass spectrometric analysis showed multiple peaks from 522 to 892 m/z indicating feather degradation. The presence of sulfide was detected on extracellular medium probably participating in the breakdown of sulfide bridges of the feather keratin. External addition of sulfide increased feather degradation.     

Feather degradation by a new keratinolytic <Emphasis Type="Italic">Streptomyces</Emphasis> sp. MS-2

Seventy different actinomycete isolates were evaluated for their ability to produce keratinase using a keratin-salt agar medium containing ball-milled feather as substrate. A novel feather-degrading isolate obtained from marine sediment produced the highest keratinolytic activity when cultured on broth containing whole feather as a primary source of carbon, nitrogen and energy. Based on phenotypic characterization and analysis of 16S rDNA sequencing the isolate was identified as a Streptomyces sp. MS-2. Maximum keratinase activity (11.2 U/mg protein) was achieved when cells were grown on mineral salt liquid medium containing 1% whole chicken feather adjusted to pH 8 and incubated at 35°C for 72 h at 150 rpm. Reduction of disulphide bridges was also detected, increasing with incubation time. Feather degradation led to an increase in free amino acids such as alanine, leucine, valine and isoleucine. Moreover, methionine and phenylalanine were also produced as microbial metabolites.     

Purification and characterization of thermostable β-1,3-1,4 glucanase from<Emphasis Type="Italic">Bacillus</Emphasis> sp. A8-8

In this study, the extracellular enzyme activity ofBacillus sp. A8-8 was detected on LB agar plates containing 0.5% of the following substrates: carboxymethylcellulose (CMC), xylan, cellulose, and casein, respectively. The β-1,3-1,4 glucanase produced fromBacillus sp. A8-8 was purified by ammonium sulfate and hydrophobic chromatography. The molecular size of the protein was estimated by SDS-PAGE as approximately 33 kDa. The optimum pH and temperature for the enzyme activity were 6.0 and 60°C, respectiveley. However, enzyme activity was shown over a broad range of pH values and temperatures. The purified β-1,3-1,4 glucanase retained over 70% of its original activity after incubation at 80°C for 2 h, and showed over 40% of its original activity within the pH range of 9 to 12. This suggests that β-1,3-1,4 glucanase fromBacillus sp. A8-8 is thermostable and alkalistable. In addition, β-1,3-1,4 glucanase had higher substrate specificity to lichenan than to CMC. Finally the activity of the endoglucanase was inhibited by Fe³⁺, Mg²⁺, and Mn²⁺ ions. However Co²⁺ and Ca²⁺ ions were increased its activity. These authors contributed equally to this work.     

Production and characterization of keratinase from<Emphasis Type="Italic">Paracoccus</Emphasis> sp. WJ-98

A bacterial strain WJ-98 found to produce active extracellular keratinase was isolated from the soil of a poultry factory. It was identified asParacoccus sp. based on its 16S rRNA sequence analysis, morphological and physiological characteristics. The optimal culture conditions for the production of keratinase byParacoccus sp. WJ-98 were investigated. The optimal medium composition for keratinase production was determined to be 1.0% keratin, 0.05% urea and NaCl, 0.03% K₂HPO₄, 0.04% KH₂PO₄, and 0.01% MgCl₂·6H₂O. Optimal initial pH and temperature for the production of keratinase were 7.5 and 37°C, respectively. The maximum keratinase production of 90 U/mL was reached after 84 h of cultivation under the optimal culturing conditions. The keratinase fromParacoccus sp. WJ-98 was partially purified from a culture broth by using ammonium sulfate precipitation, ion-exchange chromatography on DEAE-cellulose, followed by gel filtration chromatography on Sephadex G-75. Optimum pH and temperature for the enzyme reaction were pH 6.8 and 50°C, respectively and the enzymes were stable in the pH range from 6.0 to 8.0 and below 50°C. The enzyme activity was significantly inhibited by EDTA, Zn²⁺ and Hg²⁺. Inquiry into the characteristics of keratinase production from these bacteria may yield useful agricultural feed processing applications.     

<Emphasis Type="Bold">Characterization of nitrile hydratation catalysed by </Emphasis><Emphasis Type="BoldItalic">Nocardia</Emphasis><Emphasis Type="Bold"> sp. 108</Emphasis>

Abstract Nocardia sp. 108 exhibited strong acrylonitrile-hydrating activity and its nitrile hydratase was Co²⁺-dependent. Nocardia sp. 108 was active within a broad pH range from 6.0 to 10.0 at 30°C and thermostable at temperatures below 35°C, but became unstable at temperatures above 45°C. Furthermore, it was found that Nocardia sp. 108 can hydrate indole-3-acetonitrile, p-chlorobenzonitrile, p-hydroxybenzylcyanide, 3,4,5-trimethoxybenzonitrile, p-aminobenzonitrile, 3-cyanopyridine, o-chlorobenzonitrile to the corresponding amides and hence displayed a broad substrate specificity. The temperature and pH optima for these hydrations were 28°C and pH 7.0–7.5, respectively. At the observed concentrations, acrylonitrile was completely converted within 5 min, while 3,4,5-trimethoxybenzonitrile, p-aminobenzonitrile, indole-3-acetonitrile, p-chlorobenzonitrile were approximately 21.71, 8.98, 34.44, 93.10% hydrated. p-Chlorobenzonitrile appeared to be the preferred aromatic nitrile for Nocardia sp. 108.     

Substrate specificity characterization of a thermostable keratinase from <Emphasis Type="Italic">Pseudomonas aeruginosa</Emphasis> KS-1

A feather-degrading strain of Pseudomonas aeruginosa KS-1 was used in the present study. Its crude cell-free fermentation broth completely degraded chicken feather within 12 h, in the absence of disulphide reductase activity. Keratinase from its extracellular broth was purified and characterized, assuming that it would be a potential β-keratin-degrading enzyme with prospective applications in degradation of β-plaques of prions. The keratinase was purified by using Q-Sepharose anion exchange chromatography and its molecular weight, as determined by SDS–PAGE analysis, was 45 kDa. It was an alkaline, serine protease with pH and temperature optima of 9 and 60°C, respectively. The enzyme was highly thermostable with a t _1/2 > 2 h at 80°C and had a very high K to C (keratinolytic to caseinolytic) ratio of 2.5. Besides feather keratin, it also hydrolyzed a variety of other complex substrates including fibrin, gelatin and meat protein. Its activity on synthetic substrates revealed that it efficiently cleaves them in the order phenylalanine > lysine > alanine > leucine p-nitroanilides. It also cleaved insulin B chain between Val¹²-Glu¹³, Ala¹⁴-Leu¹⁵, Gly²⁰-Glu²¹ and Arg²²-Gly²³ residues.     

Characterization of a novel <Emphasis Type="Italic">Stenotrophomonas</Emphasis> isolate with high keratinase activity and purification of the enzyme

A feather-degrading bacterium was isolated from poultry decomposition feathers in China. The strain, named L1, showed significant feather-degrading activity because it grew and reproduced quickly on basal medium containing 10 g/L of native feather as the source of energy, carbon, and nitrogen. According to the phenotypic characteristics and 16S rRNA profile, the isolate belongs to Stenotrophomonas maltophilia. Keratinase activity of the isolate was determined during cultivation on raw feathers at different temperatures and initial pH. Maximum growth and feather-degrading activity of the bacterium were observed at 40°C and initial pH ranging from 7.5 to 8.0. The crude enzyme was purified by ammonium sulphate precipitation, Sephadex G-100 chromatographic and ceramic hydroxyapatite (CHT) chromatographic. Its molecular mass estimated as 35.2 kDa in SDS-PAGE. The enzyme had an optimum activity at the pH was 7.8 and the temperature was 40°C. The keratinase was wholly inhibited by a serine protease inhibitor, PMSF. Its activity was activated or inhibited by different metal ions. The keratinase activity of enzyme from strain L1 functioned on different keratins, such as feather, hair, wool, horn, and so on.     

Comparison of angiotensin converting enzyme-like activity in the Antarctic teleosts <Emphasis Type="Italic">Trematomus bernacchii</Emphasis> and <Emphasis Type="Italic">Chionodraco hamatus</Emphasis>

Biochemical parameters of the angiotensin converting enzyme-like activity (ACELA) in the gills of two Antarctic teleosts, Chionodraco hamatus and Trematomus bernacchii were characterized. Enzymatic activity was revealed following hydrolysis of a specific substrate of angiotensin-converting enzyme N-[3-(2-furyl)acryloyl]l-phenylalanyl-glycyl-glycine (FAPGG) and metabolites were separated by reverse phase HPLC analysis. The results showed similar Km values for the substrate FAPGG at 5°C for the two species with an increase of Km value for T. bernacchii at 25°C. The optimum pH value was 8.5 at 25°C and optimum chloride concentrations were about 300 mM. In T. bernacchii the optimum temperature for maximum enzyme activity was 50°C, while maximum activity in C. hamatus occurred at 35°C. Lisinopril was more efficient in inhibiting ACELA in C. hamatus with an I ₅₀ value of 16.83 ± 5.11 nM, compared to an I ₅₀ value of 30.66 ± 5.19 nM in T. bernacchii. In conclusion, it appears that some biochemical parameters of ACELA in C. hamatus differ from those in T. bernacchii, probably due to different ways that the enzyme adapts to the constantly cold temperatures of the animal’s environment.     

Production of a <Emphasis Type="Italic">Trichoderma reesei</Emphasis> QM9414 xylanase in <Emphasis Type="Italic">Pichia pastoris</Emphasis> and its application in biobleaching of wheat straw pulp

The purpose of this study was to produce a Trichoderma reesei xylanase (XYN2) in Pichia pastoris and to test its potential application for pulp bleaching. The recombinant xylanase was purified by a two-step process of ultrafiltration and gel filtration chromatography. The molecular mass of the recombinant enzyme was 21 and 25 kDa by SDS–PAGE analysis, due to different glycosylation of the native protein. The optimum pH and temperature of the recombinant XYN2 was 5.0 and 50 °C. Enzyme activity was stable at 50 °C and at pH 5.0–7.0. The bleaching ability of the recombinant xylanase was also studied at 50 °C and pH 6.0, using wheat straw pulp. Biobleaching of the xylanase produced chlorine dioxide savings of up to 60%, while retaining brightness at the control level and led to a lower kappa number and small enhancements in tensile, burst and tear strength of pulp fibers.     

Optimization and mechanism of diacetyl accumulation by <Emphasis Type="Italic">Enterobacter</Emphasis><Emphasis Type="Italic">aerogenes</Emphasis> mutant UV-3

A mutant designated as UV-3 was obtained from wild-type Enterobacter aerogenes 10293 through u.v. radiation. The activities of α-acetolactate decarboxylase (Ald), lactate dehydrogenase (Ldh) and diacetyl reductase (Dr) in UV-3 were strongly attenuated, with the lowest activities at pH 7.0–7.5, and temperature between 36 and 39°C. Compared to the wild-type, the yield of diacetyl by UV-3 was increased 18.7-fold, up to 1.05 ± 0.01 g l⁻¹. Acetoin and ethanol productions were decreased by 48.4 and 71.4%, respectively, but acetate yield was increased by 34.6%. Optimum medium for diacetyl production by UV-3 contained 10% glucose, 0.5% peptone, 0.5% yeast extract powder, 0.01% (NH₄)₂SO₄, 0.1% citric acid, 0.2% MnSO₄ and 0.2% MgSO_4, and this was determined by one-factor-at-a-time approach. Data from the five level central composite designs demonstrated that initial pH of 7.0, temperature of 37°C and rotational speed of 180 rev/min were optimum processing parameters for diacetyl production. The maximum yield of diacetyl could reach 1.35 g l⁻¹ in a 5-l bioreactor. These results showed an enhancement of the non-enzymatic oxidative decarboxylation of α-acetolactate and a decrease in the activities of Ald, Ldh and Dr as a consequence of diacetyl accumulation in UV-3.     

Evaluation of environmental conditions for production of bacteriocin-like substance by <Emphasis Type="Italic">Bacillus</Emphasis> sp. strain P34

The influence of temperature, pH and media on bacteriocin production by Bacillus sp. P34 was investigated. The effect of temperature and initial pH was evaluated by factorial design and response surface methodology (RSM). Statistical analysis of results showed that, in the range studied, the two variables have a significant effect on bacteriocin production. Response-surface data showed maximum antimicrobial activity production at initial pH values between 6.0 and 8.0 and temperatures between 25 and 37 °C. No relationship between bacterial growth and bacteriocin production was observed. RSM proved to be a powerful tool in optimizing the production of antimicrobial activity by Bacillus sp. P34. When different media were tested, maximum bacteriocin production was observed in soybean protein-based medium, but antimicrobial activity was not achieved by cultivation on fish meal, feather meal, whey and grape waste.     

Alkaline protease from <Emphasis Type="Italic">Bacillus sp.</Emphasis> isolated from coffee bean grown on cheese whey

Two strains of Bacillus, one from a culture collection (B. subtilis ATCC 6633) and a wild type (Bacillus sp. UFLA 817CF) isolated during coffee fermentation in the south of Minas Gerais, Brazil, were evaluated in relation to secretion of alkaline proteases. The strains were grown on nutrient broth, nutrient broth with sodium caseinate and nutrient broth with three different concentrations of cheese whey powder for 72 h. Samples were collected at 24-h intervals to evaluate the proteolytic activity, protein content and cell population. Maximum protease activity was observed after 24-h growth for both the microorganisms, a period that coincided with the end of the exponential phase. The specific activity values were, respectively, 839.8 U/mg for B. subtilis ATCC 6633 and 975.9 U/mg for Bacillus sp. UFLA 817CF. The 60% saturation presented the best results for specific protease activity in all the growth culture media tested with B. sp. UFLA 817CF. Bacillus sp. UFLA 817CF showed highest enzymatic activity at pH 9.0 and 40°C in the three culture media tested. The protease obtained from culture of the wild Bacillus strain presented stability at pH 7.0 and considerable heat stability at 40°C and 50°C, and could be an alternative for the industry to utilize cheese whey to produce proteolytic enzymes.     

Protoplast Preparation from <Emphasis Type="Italic">Laminaria japonica</Emphasis> with Recombinant Alginate Lyase and Cellulase

Functional recombinant abalone alginate lyase (rHdAly) and β-1,4-endoglucanase (rHdEG66) were expressed as secreted proteins with baculoviral expression systems. The specific activity of each recombinant enzyme, 2,490 and 18.2 U/mg for rHdAly and rHdEG66, respectively, was comparable to its native form at 30°C. Purified rHdAly and rHdEG66 showed the highest specific activity both at 35°C and optimum pH 8.7 and 5.9, respectively. These properties were also comparable to those of the native enzymes. Protoplast isolation was attempted from Laminaria japonica using both rHdAly and rHdEG66. When L. japonica blades were incubated in artificial seawater containing rHdAly and rHdEG66, very low numbers of protoplasts (<1 × 10³ protoplasts/g fresh weight) resulted. However, using blades pretreated with proteinase K, the protoplast was increased up to 5 × 10⁶ protoplasts/g fresh weight. Since the average diameter of isolated protoplasts was 11.6 μm, these cells were mostly derived from the epidermal layer rather than the cortical layer. Our results suggest that at least three enzymes, alginate lyase, cellulase, and protease, are essential for effective protoplast isolation from L. japonica. The protoplast isolation method in this study is more useful than earlier methods because it preferentially yielded protoplasts of the epidermal layer, which are known to be able to be regenerated.     

Isolation and Partial Characterization of Antifungal Metabolites Produced by <Emphasis Type="Italic">Bacillus</Emphasis> sp. IBA 33

Antifungal proteins produced by Bacillus sp. IBA 33 were purified by ammonium sulfate precipitation and DEAE-Sephacel column chromatography. The two purified proteins inhibited the growth of Geotrichum candidum, the sour rot disease agent in lemon. The proteins were stable at 20 (3 months), 40, 60 and 100°C (30 min) and remained active after sterilization at 121°C for 15 min. Their hydrophobic nature was proved and when were developed with ninhydrin they did not show any free amino groups. The infrared spectrum showed vibrational modes corresponding to peptide, ester or ketone links and saturated CH links corresponding to long chain fatty acids. UV scan spectroscopy showed tyrosine and or tryptophan amino acids in their composition. The remarkable thermo-resistance of proteins may be a good feature to be used in the development of a new biocontrol method of Geotrichum candidum.     

Production of xylanase from a newly isolated <Emphasis Type="Italic">Penicillium</Emphasis> sp. ZH-30

A new strain of Penicillium sp. ZH-30 that produces xylanase was isolated from soil. According to the morphology and comparison of internal transcribed spacer (ITS) rDNA gene sequence, the strain Penicillium sp. ZH-30 was identified as a strain of Penicillium oxalicum. When xylan or wheat bran was used as substrate at 30°C for 3 days under submerged cultivation, xylanase production was 5.3 and 13.3 U ml⁻¹, respectively. The temperature and pH for optimum activity were 50°C and 5.0–6.0, respectively.     

Efficient decomposition of shrimp shell waste using <Emphasis Type="Italic">Bacillus cereus</Emphasis> and <Emphasis Type="Italic">Exiguobacterium acetylicum</Emphasis>

Two bacterial cultures were isolated and tested for degradation of shrimp shell waste. According to morphological examination, physiological tests, and applied molecular techniques, isolates were identified as Bacillus cereus and Exiguobacterium acetylicum. Both strains were cultivated separately in flasks with 100 mL of shrimp shell waste broth (3% of washed, dried and ground shrimp shell waste in tap water, pH 7.0) at 37°C. At determined periods of time, deproteinization and demineralization of residuals were measured. Fermentation of 3% shell waste with B. cereus indicated 97.1% deproteinization and 95% demineralization. For E. acetylicum, the level of deproteinization and demineralization was 92.8 and 92%, respectively. Protein content was reduced from 18.7 to 5.3% with B. cereus and to 7.3% with E. acetylicum. No additional supplements were used during the fermentation of shell waste. B. cereus strain showed higher efficacy in decomposition of shell waste and was used for large-scale fermentation in 12 L of 10% shrimp shell waste broth. Incubation of bacteria with shell waste during 14 days at 37°C resulted in 78.6% deproteinization and 73% demineralization. High activity of isolated cultures in decomposition of shrimp shell waste suggests broad potential for application of these bacteria in environmentally friendly approaches to chitin extraction from chitin-rich wastes.     

Native granule associated short chain length polyhydroxyalkanoate synthase from a marine derived <Emphasis Type="Italic">Bacillus</Emphasis> sp. NQ-11/A2

A rapidly growing marine derived Bacillus sp. strain NQ-11/A2, identified as Bacillus megaterium, accumulated 61% polyhydroxyalkanoate by weight. Diverse carbon sources served as substrates for the accumulation of short chain length polyhydroxyalkanoate. Three to nine granules either single or attached as buds could be isolated intact from each cell. Maximum activity of polyhydroxyalkanoate synthase was associated with the granules. Granule-bound polyhydroxyalkanoate synthase had a K_m of 7.1 × 10⁻⁵ M for DL-β-hydroxybutyryl-CoA. Temperature and pH optima for maximum activity were 30°C and 7.0, respectively. Sodium ions were required for granule-bound polyhydroxyalkanoate synthase activity and inhibited by potassium. Granule-bound polyhydroxyalkanoate synthase was apparently covalently bound to the polyhydroxyalkanoate-core of the granules and affected by the chaotropic reagent urea. Detergents inhibited the granule-bound polyhydroxyalkanoate synthase drastically whilst glycerol and bovine serum albumin stabilized the synthase.     

Purification and characterization of a novel thermoacid-stable fibrinolytic enzyme from <Emphasis Type="Italic">Staphylococcus</Emphasis> sp. strain AJ isolated from Korean salt-fermented Anchovy-<Emphasis Type="Italic">joet</Emphasis>

A novel fibrinolytic enzyme (AJ) was purified from Staphylococcus sp. strain AJ screened from Korean salt-fermented Anchovy-jeot. Relative molecular weight of AJ was determined as 26 kDa by using SDS-PAGE and fibrin zymography. Based on a 2D gel, AJ was found to consist of three active isoforms (pI 5.5–6.0) with the same N-terminal amino acid sequence. AJ exhibited optimum pH and temperature at 2.5–3.0 and 85°C, respectively. AJ kept 85% of the initial activity after heating at 100°C for 20 min on the zymogram gel. The Michaelis constant (K _m) and K _cat values of AJ towards α-casein were 0.38 mM and 19.73 s⁻¹, respectively. AJ cleaved the Aα-chain of fibrinogen but did not affect the Bβ- and γ-chains, indicating that it is an α-fibrinogenase. The fibrinolytic activity was inhibited by diisopropyl fluorophosphate, indicating AJ is a serine protease. Interestingly, AJ was very stable at acidic condition, SDS, and heat (100°C), whereas it was easily degraded at neutral and alkaline conditions. In particular, AJ formed an active homo-dimer in the pH range from 7.0 to 8.0. To our knowledge, a similar combination of acid and heat stability has not yet been reported for other fibrinolytic enzymes.     

Highly selective biotransformation of ginsenoside Rb<Subscript>1</Subscript> to Rd by the phytopathogenic fungus<Emphasis Type="Italic"> Cladosporium fulvum</Emphasis> (<Emphasis Type="Italic">syn</Emphasis>.<Emphasis Type="Italic"> Fulvia fulva</Emphasis>)

Fourteen phytopathogenic fungi were tested for their ability to transform the major ginsenosides to the active minor ginsenoside Rd. The transformation products were identified by TLC and HPLC, and their structures were assigned by NMR analysis. Cladosporium fulvum, a tomato pathogen, was found to transform major ginsenoside Rb₁ to Rd as the sole product. The following optimum conditions for transforming Rd by C. fulvum were determined: the time of substrate addition, 24 h; substrate concentration, 0.25 mg ml⁻¹; temperature, 37°C; pH 5.0; and biotransformation period, 8 days. At these optimum conditions, the maximum yield was 86% (molar ratio). Further, a preparative scale transformation with C. fulvum was performed at a dose of 100 mg of Rb₁ by a yield of 80%. This fungus has potential to be applied on the preparation for Rd in pharmaceutical industry.