Occurrence of fumonisins in maize imported into Iran during 2001–2002

Fumonisins, fungal toxins found primarily in maize and produced by various Fusarium species, have been shown to cause a variety of significant adverse health effects in livestock and experimental animals, and are probable human carcinogens. Thirty-three maize samples were collected at ports from bulk shipments, which were imported into Iran from six countries during 2001–2002, and analysed by HPLC for the most abundant of the naturally occurring fumonisin analogues, namely fumonisins B₁ (FB₁), B₂ (FB₂) and B₃ (FB₃). Of the 33 samples, 21 (64%) were found to contain FB₁ (58–512 μg/kg) at levels above 10 μg/kg. The frequency of FB₁ found in maize samples imported from Uruguay and Canada was 75%, followed by China and Argentina (67%), USA (60%), and Brazil (50%). The average FB₁ level was 266 and 169 μg/kg for positive and all samples, respectively. Medians were 250 and 146 μg/kg for positive and all samples, respectively. FB₂ levels ranged from not detected (<10 μg/kg) to 53 μg/kg, whereas no sample had an FB₃ level above the detection level (10 μg/kg). This is the first report of fumonisin contamination of imported maize in Iran. Although, the level of all detected fumonisins were below the Iranian and FDA tolerance levels for foods and feeds, It is necessary to maintain the strict rules to ensure continued safety of imported maize.     

Natural multi-occurrence of mycotoxins in rice from Niger State,Nigeria

Twenty-one rice samples from field (ten), store (six) and market (five) from the traditional rice-growing areas of Niger State, Nigeria were analysed for aflatoxins (AFs), ochratoxin A (OTA), zearalenone (ZEA), deoxynivalenol (DON), fumonisin B₁ (FB₁) and B₂ (FB₂), and patulin (PAT) by thin-layer chromatography (TLC) and high-performance liquid chromatography (HPLC) respectively. T-2 toxin was determined using TLC only. AFs were detected in all samples, at total AF concentrations of 28–372 μg/kg. OTA was found in 66.7% of the samples, also at high concentrations (134–341 μg/kg) that have to be considered as critical levels in aspects of nephrotoxicity. ZEA (53.4%), DON (23.8), FB₁ (14.3%) and FB₂ (4.8%) were also found in rice, although at relatively low levels. T-2 toxin was qualitatively detected by TLC in only one sample. Co-contamination with AFs, OTA, and ZEA was very common, and up to five mycotoxins were detected in a single sample. The high AF and OTA levels as found in rice in this study are regarded as unsafe, and multi-occurrences of mycotoxins in the rice samples with possible additive or synergistic toxic effects in consumers raise concern with respect to public health.     

Co-occurrence of mycotoxins in swine feed produced in Portugal

A total of 404 samples of commercial swine feed from Portugal feed mills were analysed by HPLC methods for the presence of mycotoxins: 277 samples of feed for fattening pigs were analysed for ochratoxin A (OTA), zearalenone (ZEA), and deoxynivalenol (DON), and 127 samples of feed for sows were analysed for ZEA and fumonisins (FB₁ + FB₂). Concerning feed for fattening pigs, 21 (7.6%) samples were positive for OTA, (2–6.8 μg/kg), 69 (24.9%) were positive for ZEA (5–73 μg/kg), and 47 (16.9%) were positive for DON (100–864 μg/kg). In feed for sows, the results showed 29.9% of positive samples for ZEA (5–57.7 μg/kg) and 8.7% positive samples for FB₁ and FB₂ (50–391.4 μg/kg). Co-occurrence of DON/ZEA was found most frequently, but simultaneous contamination with OTA/ZEA and OTA/DON was also found.     

Incidence and levels of fumonisin contamination in Colombian corn and corn products

A survey was conducted to determine the levels of fumonisins B1 and B2 in corn and corn-based products available in Colombia for human and animal consumption. A total of 120 samples were analyzed by acetonitrile-water extraction, cleanup with a strong-anion-exchange column, and liquid chromatography with o-phthaldialdehyde-2-mercaptoethanol derivatization and fluorescence detection. The samples of corn and corn-based products for animal intake were taken at different feed manufacturing plants, whereas the samples used for human foods where purchased from local retail stores. The number of positive samples for fumonisin B1 was 20.0% higher in corn and corn-based products for animal intake (75.0%) than in corn and corn-based products for human consumption (55.0%). The levels of fumonisin B1 were also higher in corn and corn-based products for animal intake (mean = 694 μg/kg; range = 32–2964 μg/kg), than in corn and corn-based products for human intake (mean = 218 μg/kg; range = 24–2170 μg/ kg). The incidence and levels of fumonisin B2 were lower than those for fumonisin B1. Corn and corn-based products for animal consumption had an incidence of fumonisin B2 of 58.3%, with a mean value of 283 μg/kg, and a range of 44–987 μg/kg. The incidence of fumonisin B2 in corn-based products for human intake was 35.0%, with a mean value of 118 μg/kg and a range of 21–833 μg/kg. The highest incidence and levels of fumonisins were found in samples of hominy feed, with concentrations ranging from 86 to 2964 μg/kg fumonisin B1 and 57 to 987 μg/kg fumonisin B2.     

Occurrence of Fumonisin B<Subscript>1</Subscript> in Corn from the Main Corn-Producing Areas of China

Fumonisin B₁ (FB₁) is the most abundant of the fumonisin mycotoxins, mainly produced in maize by F. verticillioides and F. proliferatum. A total of 282 corn samples harvested in 2005 from six provinces, the main corn-producing areas of China, were analyzed for FB₁ using high-performance liquid chromatography. All samples except one were (99.6%) positive for FB₁ at levels varying from 3 to 71,121 ng/g with mean and median levels for all samples of 6,662 and 1,569 ng/g, respectively. During an analysis of the distribution pattern for FB₁, it became apparent that 43.6% of tested samples had FB₁ concentrations below 1,000 ng/g, while 25.2% contained in excess of 5,000 ng/g. The average exposure to FB₁ (1.1 μg/kg body weight/day) is within the provisional maximum tolerable daily intake of 2 μg/kg body weight/day set by the Joint FAO/WHO Expert Committee on Food Additives.     

Trends of fumonisin contamination and animal intoxication through monitoring 1991 to 1997 corn crop in the State of Paraná, Brazil

Eleven feed samples associated with six animal (horse and poultry) intoxication outbreaks (1991) in the state of Paraná, Brazil, were evaluated for fungal and fumonisin contamination. In order to estimate the␣trend of livestock intoxication, fumonisin contamination was monitored in corn produced both at the commercial level (1991, 1995 crop), and in an experimental field at a local Agronomy Institute (1997 crop). The total mould count in the feed samples ranged from 2.9 × 10³ to 1.9 × 10⁷ CFU/g, with Fusarium verticillioides as the predominant species, at a high count of 2.4 × 10⁴–6.5 × 10⁵ CFU/g. Fumonisins (FB₁ + FB₂) were detected in all corn-based feed samples at levels ranging from 2.89 to 14.54 μg/g. All 27 Northern corn samples (1991 crop) were contaminated with fumonisins at levels ranging from 2.32 to 16.64 μg/g. Twenty-six (96.3%) out of 27 corn samples from the Central-Southern region (1995 crop) were positive for fumonisins (FB₁+FB₂), with the range of 0.07–3.66 μg/g, while all 37 Northern samples (1995 crop) were contaminated with fumonisins ranging from 0.57 to 9.97 μg/g. Twenty-one out of 37 corn samples from the Northern region (1997 crop) were positive for fumonisins, but at low level (range of 0.05–2.67 μg/g). The results showed a decreasing trend in fumonisin contamination over the years. Nowadays animal intoxication outbreaks rarely occur in this State, as both animal producers and feed industries have become conscious about monitoring of corn and other raw materials at the quality control level.     

Fungi,Aflatoxins, Fumonisin B<Subscript>l</Subscript> and Zearalenone Contaminating Sorghum-based Traditional Malt,Wort and Beer in Botswana

Brewing and consumption of traditional beer have social–economic significance in most African countries including Botswana. Traditional sorghum malt, wort, and beer samples were collected from three villages around Gaborone, Botswana. Forty-six malt samples were analyzed for fungi on three different media and developing colonies were subcultured for identification. Rhizopus, Fusarium, Mucor, and Aspergillus were the most common genera isolated. Out of the 46 malt samples, 72% contained Rhizopus stolonifer, 63% Fusarium verticillioides (syn. Fusarium moniliforme), and 37% Aspergillus flavus. Although Aspergillus flavus was isolated from malt samples, aflatoxins (B₁, B₂, G₁, and G₂) were not detected in any of the samples analyzed. When the malt, wort, and beer samples were analyzed for fumonisin B_l and zearalenone, fumonisin B₁ was detected in 3 malt samples, with concentrations ranging from 47 to 1316 μg/kg, while zearalenone was detected in 56%, 48% and 48% of the malt, wort and beer samples, respectively. Zearalenone concentration in samples ranged from 102 to 2213 μg/kg in malt, 26 to 285 μg/l in wort and 20 to 201 μg/l, in beer. Zearalenone carry-over from wort to beer ranged from 23 to 403%. Therefore, although aflatoxins and fumonisin B₁ do not appear to be major contaminants, zearalenone is common and could pose a potential problem in traditional beer in Botswana.     

Zearalenone, deoxynivalenol and fumonisins in mixed-feed for laying hens

Fusarium toxins are secondary metabolites produced byfungi of these genera in many commodities under certain conditions. A study was carried out to investigate the co-occurrence of zearalenone (ZEN), deoxynivalenol (DON) and fumonisins (FB₁ and FB₂) in 52 samples of mixed-feed for poultry contaminated withFusarium verticillioides. The zearalenone and deoxynivalenol were checked using immunoaffinity column and the extraction of fumonisin was performed by strong anion exchange (SAX) solid phase column. Detection and quantification were determined by high performance liquid chromatography (HPLC). The limit of detection was 5 μg/kg for ZEN, 100 μg/kg for DON and 50 and 100 μg/kg for FB₁ and FB₂ respectively.Fusarium toxins were detected in 20 samples. Sixteen samples were positive for ZEN (30.7%) presenting levels that ranged from 7.4 μg/kg to 61.4 μg/kg (mean=27.0 μg/kg). 13.5% of the samples presented contaminations of DON, with levels ranging from 100.0 μg/kg to 253 μg/kg (mean=l18.07 μg/kg). FB₁ was detected in 19.2% of samples, with levels ranging from 50.0 μg/kg to 110.0 μg/kg (mean=73.6 μg/kg). FB2 was not detected in any sample. In positive samples simultaneously contamination with two or three mycotoxins were detected in 9 of them (17.3%).     

Mycobiota in poultry feeds and natural occurrence of aflatoxins, fumonisins and zearalenone in the Rio de Janeiro State, Brazil

The intake of mycotoxin-contaminated feeds can lead to nutrient losses and may have adverse effects on animal health and on productivity. The aims of this study were (1) to determine the mycobiota present in poultry feed samples, and (2) to evaluate the natural occurrence of aflatoxin B₁, fumonisin B₁ and zearalenone. Fungal counts were similar between all culture media tested (10³ CFU g⁻¹). The most frequent genus isolated was Penicillium spp. (41.26%) followed by Aspergillus spp. (33.33%) and Fusarium spp. (20.63%). High precision liquid chromatography was applied to quantify aflatoxin B₁ and fumonisin B₁. Thin layer chromatography was used to determine zearalenone levels. Aflatoxin B₁ values ranged between 1.2 and 17.5 μg kg⁻¹. Fumonisin B₁ levels ranged between 1.5 and 5.5 μg g⁻¹. Zearalenone levels ranged between 0.1 and 7 μg g⁻¹. The present study shows the simultaneous occurrence of two carcinogenic mycotoxins, aflatoxin B₁ and fumonisin B₁, together with another Fusarium mycotoxin (zearalenone) in␣feed intended for poultry consumption. Many samples contained AFB₁ levels near the permissible maximum and it could affect young animals. A synergistic toxic response is possible in animals under simultaneous exposure.     

Determinatıon of ochratoxin A and total aflatoxin levels in corn samples from Turkey by enzyme-linked immunosorbent assay

Forty-seven samples of corn were collected from various street bazaars and market outlets in different regions of Turkey and total aflatoxin (AF) and ochratoxin A (OTA) levels were determined by enzyme-linked immunosorbent assay (ELISA) following sample preparation. Levels of AF and OTA in corn samples ranged between 1.75–120.3 μg/kg and 1.08–8.57 μg/kg, respectively. Although 53% of the samples analysed had no detectable levels of AF, 4% of similar samples were found to contain AFs above the acceptable limit of 10 μg/kg in Turkey. For OTA, 4% of the corn samples had levels above the acceptable limit (3 μg/kg) in Turkey, with over 43% samples not found to contain this mycotoxin. Although the levels of mycotoxins analysed in this study were not found to be high and the percentage of samples contaminated above permitted limits were low, the importance of overall daily dietary intake should not be underestimated and control of these fungal metabolites in corn must be explored to minimise the hazards they may cause in humans.     

Production of Beauvericin, Moniliformin, Fusaproliferin, and Fumonisins B1, B2, and B3 by Fifteen Ex-Type Strains of Fusarium Species

Fifteen Fusarium species were analyzed by high-performance liquid chromatography for the production of six mycotoxins in corn grits cultures. Production of mycotoxins ranged from 66 to 2,500 μg/kg for fumonisin B₁, 0.6 to 1,500 μg/g for moniliformin, 2.2 to 720 μg/g for beauvericin, and 12 to 130 μg/g for fusaproliferin. Fumonisin B₂ (360 μg/kg) was produced by two species, fumonisin B₃ was not detected in any of the 15 species examined, and Fusarium bulbicola produced none of the six mycotoxins that we analyzed.     

Mycotoxins in horse feed

A total of 62 samples of commercial horse feed preparations (complementary feeds) containing cereal mixtures (“muesli” or mash, n = 39; pelleted feeds, n = 12), and plain horse feed grains (maize, n = 5; oats, n = 4; barley, n = 2) were purchased from 21 different producers/distributors from the German market. All samples were analysed by competitive enzyme immunoassays (EIA) for six different mycotoxins (mycotoxin groups). Analytes (detection limit, mean recovery) were: deoxynivalenol (DON, 10 μg/kg, 84%), zearalenone (ZEA, 5 μg/kg, 93%), fumonisin B₁ (FB₁, 2 μg/kg, 113%), T-2 toxin (T-2, 0.1 μg/kg, 71%), sum of T-2 + HT-2 toxin (T-2/HT2, 0.2 μg/kg, 97%), ochratoxin A (OTA, 0.2 μg/kg, 67%), and total ergot alkaloids (Generic Ergot Alkaloids “GEA”, 30 μg/kg, 132%). All samples contained DON (16–4,900 μg/kg, median 220 μg/kg), T-2/HT-2 (0.8–230 μg/kg, median 24 μg/kg), and T-2 (0.3–91 μg/kg, median 7 μg/kg). ZEA was detected in 98% of the samples (7–310 μg/kg, median 61 μg/kg). Most samples (94%) were positive for FB₁ (2–2,200 μg/kg, median 27 μg/kg). Ergot alkaloids were detected in 61% of samples (28–1,200 μg/kg, median 97 μg/kg), OTA was found in 42% of samples (0.2–4 μg/kg, median 0.35 μg/kg). The results demonstrate that a co-contamination with several mycotoxins is very common in commercial horse feed from the German market. The toxin concentrations were in most cases well below the levels which are usually considered as critical or even toxic. The highest mycotoxin concentrations were mostly found in single-grain cereal feed: the maximum values for DON and FB₁ were found in maize, the highest T-2/HT-2 toxin concentrations were found in oats, and the highest concentration of ergot alkaloids was found in barley. In composed feeds, no correlation between cereal composition and mycotoxin levels could be found.     

Natural occurrence of mycotoxins in different spices in Egypt

A total of 120 different samples belonging to 24 kinds of spices collected from different places atAssiut Governorate (Egypt) were examined for the natural occurrence of mycotoxins. TLC analysis of spice extracts revealed the presence of aflatoxins (8–35 μg/kg) in 16 samples of anise, black pepper, caraway, black cumin, fennel, peppermint, coriander and marjoram, sterigmatocystin (10–23 μg/kg) in ten samples of red pepper, caraway, cumin and marjoram and citrinin (8–12 ⧎g/kg) in two samples of black cumin, while ochratoxin A and zearalenone could not be detected.     

Occurrence ofAlternaria andFusarium mycotoxins in winter wheat from domestic crop in year 2003

The aim of this study was a monitoring of the occurrence ofAlternaria andFusarium mycotoxins in winter wheat from domestic crop in the year 2003. Altenuene was determined in 56 (100%) samples of winter wheat, range 14.5–41 μg/kg, mean 25 μg/kg. Alternariol was determined in 16 (28.6%) samples of winter wheat, range 6.3–22.1 μg/kg, mean 5.7 μ/kg. DON was determined in 42 (100%) samples of winter wheat, range 250–3500 μg/kg, mean 330 μg/kg. T2-toxin was determined in 42 (100%) samples of winter wheat, range 25–337 μg/kg, mean 99 μg/kg. ZEA was not determined in samples of winter wheat. Presented at the 26^th Mykotoxin-Workshop in Herrsching, Germary, May 17–19, 2004 Financial support. Supported (one part of experiments, the determination of Fusarium mycotoxins) by the Ministry of Agricu ture of the Czech Rebublic (Propect No QF3121)     

Mycotoxins in several Polish food products in 2004–2005

In 2004–2005, samples of several selected Polish foods such as cereal products, nuts, dried fruits, coffee and culinary spices collected from Warsaw market and taken from food producers were analyzed on presence of aflatoxin B₁, B₂, G₁, G₂ (AF), ochratoxin A (OTA), zearalenone (ZEA) and deoxynivalenol (DON). After extraction and clean-up of extracts on immunoaffinity columns (IAC), mycotoxin analyses were carried out by HPLC using fluorescence and UV detectors. The concentrations of aflatoxins and ochratoxin A depending on the kind of sample ranged from 0.02 to 7.8 (one sample, of peanuts) and 0.02–11.9 μg/kg (one coffee sample), respectively. The levels of ZEA and DON were found to be below 50 °g/kg.     

Mycotoxin production by Aspergillus niger aggregate strains isolated from harvested maize in three Portuguese regions

BackgroundMaize is considered one of the crops more susceptible to mycotoxins in the world. Two of the mycotoxins commonly associated with maize are fumonisins and ochratoxin A. Aspergillus niger is a known producer of ochratoxin A and is easily found in maize. Recently, however, A. niger has been reported to produce as well fumonisins, mainly fumonisin B₂.AimsThe aim of this study was to isolate A. niger strains from maize samples collected in three Portuguese maize growing regions and to detect the production of both fumonisin B₂ and ochratoxin A.MethodsNinety five maize samples were collected, plated, and all observable Aspergillus section Nigri strains were isolated. Strains were morphologically characterized and mycotoxin production was determined by HPLC-FD.ResultsIsolations resulted in a total of 270 strains of black Aspergillus from 73 samples (77% of the samples). About 14% of those strains were found to produce ochratoxin A and 39% of the strains were found to produce fumonisin B₂.ConclusionsAn association between the production of these two mycotoxins could not be found and no conclusions could be taken whether the presence of A. niger aggregate strains will increase the risk of maize contamination with fumonisins and more specifically with fumonisin B₂.     

Natural Occurrence of Mycotoxins in Staple Cereals from Ethiopia

The occurrence of mycotoxins in barley, sorghum, teff (Eragrostis tef) and wheat from Ethiopia has been studied. Samples were analyzed for aflatoxin B₁ (AFB1), ochratoxin A (OTA), deoxynivalenol (DON), nivalenol (NIV) and zearalenone (ZEN) using high performance liquid chromatography (HPLC) and for fumonisins (FUM) using enzyme linked immunosorbent assay (ELISA). AFB1 and OTA were detected in samples of all the four crops. AFB1 was detected in 8.8% of the 352 samples analyzed at concentrations ranging from trace to 26 μg kg⁻¹. OTA occurred in 24.3% of 321 samples at a mean concentration of 54.1 μg kg⁻¹ and a maximum of 2106 μg kg⁻¹. DON occurred in barley, sorghum and wheat at 40–2340 μg kg⁻¹ with an overall incidence of 48.8% among the 84 mainly ‘suspect’ samples analyzed; NIV was co-analyzed with DON and was detected at 40 μg kg⁻¹ in a wheat sample and at 50, 380, and 490 μg kg⁻¹ in three sorghum samples. FUM and ZEN occurred only in sorghum samples with low frequencies at concentrations reaching 2117 and 32 μg kg⁻¹, respectively. The analytical results indicate higher mycotoxin contamination in sorghum, which could be related to the widespread storage of sorghum grain in underground pits leading to elevated seed moisture contents. This is the first report on the occurrence of OTA in teff.     

Simultaneous occurrence of mycotoxins in human food commodities from Cameroon

Eighty-two samples of dried food commodities from Cameroon were screened and quantified for different mycotoxins, including fumonisin B₁ (FB₁), zearalenone (ZEA), deoxynivalenol (DON), aflatoxin (AF) and ochratoxin A (OTA), by thin-layer chromatography (TLC) and high-performance liquid chromatography (HPLC), respectively. The percentage of positive samples was as follows: FB₁ 41%, AF 51%, ZEA 57%, DON 65% and OTA 3%. High FB₁ contents were found in maize, averaging 3,684 μg/kg (range: 37-24,225 μg/kg), whereas the highest average ZEA level was found in peanuts (70 μg/kg), followed by maize (69 μg/kg), rice (67 μg/kg) and beans (48 μg/kg) with no ZEA was detected in soybeans. DON contents were low, ranging from 13 to 273 μg/kg, and for AF the average content was 2.6 μg/kg with peanuts and maize as principal substrates. The incidence of OTA was low, with a mean level of 6.4 μg/kg recorded. The majority (79%) of samples contained more than one mycotoxin and the most frequent co-occurrence found was FB₁ + ZEA + DON, detected in 21% of samples (mainly maize) analysed. Co-contamination with FB₁ + ZEA + DON + AF was found in 11% of the samples. Although a large proportion of samples had fairly low levels of individual mycotoxins, this should be of concern as the co-occurrence of mycotoxins may generate additive or synergistic effect in humans, especially if the respective commodities are consumed almost on a daily basis.     

Occurrence of alternariol, alternariol monomethyl ether and tenuazonic acid in Argentinean tomato puree

The occurrence ofAlternaria mycotoxins was investigated in 80 samples of tomato puree processed and sold in Argentina. Alternariol (AOH), alternariol monomethyl ether (AME) and tenuazonic acid (TA) were searched for by liquid chromatography. Thirty-nine of the 80 samples showed mycotoxin contamination. TA was found in 23 samples (39-4021 μg/kg), AOH in 5 samples (187-8756 μg/kg), and AME in 21 samples (84-1734 μg/kg). Co-occurrence of two of these toxins was detected in 10 samples. This is the first report of natural occurrence of AOH, AME and TA in tomato products in Argentina.